Engine And Engine CoolingFuel System, GasolinePower Train
RECALL CAMPAIGN FOR THE SUZUKI RECOMMENDED REPLACING THE 4 OXYGEN SENSORS. *BF THE 4-WHEEL DRIVE GEAR WOULD NO LONGER SHIFT, IT WAS DISCOVERED YEARS LATER THAT IT WAS NOT ASSEMBLED CORRECTLY. THE CONSUMER HAD EMISSION PROBLEMS. THE CONSUMER STATED WHEN HE TOOK THE VEHICLE IN FOR REPAIRS FOR TWO PROBLEMS, THE VEHICLE CAME…
Read full complaint
RECALL CAMPAIGN FOR THE SUZUKI RECOMMENDED REPLACING THE 4 OXYGEN SENSORS. *BF THE 4-WHEEL DRIVE GEAR WOULD NO LONGER SHIFT, IT WAS DISCOVERED YEARS LATER THAT IT WAS NOT ASSEMBLED CORRECTLY. THE CONSUMER HAD EMISSION PROBLEMS. THE CONSUMER STATED WHEN HE TOOK THE VEHICLE IN FOR REPAIRS FOR TWO PROBLEMS, THE VEHICLE CAME BACK WITH UNRELATED PROBLEMS SUCH AS THE BRAKES WHICH THE DEALER STATED NEEDED TO BE ADJUSTED, THE FRONT BUMPER WAS HANGING OFF AND WAS MISSING THE SECURING BOLTS, THE VEHICLE DID NOT HAVE ANY HEAD LIGHTS, IT WAS SUBSEQUENTLY DETERMINED BY AN ELECTRICAL REPAIR SPECIALIST THAT THE HEAD LIGHT RELAY WAS INTERNALLY DAMAGED, THE CONSUMER STATED THE WAS ALSO AN UNIDENTIFIABLE FUEL LEAK. *JB
NHTSA ODI #10109353
45,000 miles · Feb 19, 2004
Structure
THE FENDER ON THE FRONT PASSENGER'S SIDE IS VERY LOOSE. THE ENTIRE FENDER IS HELD ON BY PLASTIC FASTENERS. VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE FASTENERS WITH OTHERS THAT WERE ALSO MADE OF PLASTIC. THE MANUFACTURER WAS AWARE OF THE PROBLEM. *AK THREE MONTHS LATER THE FASTENERS STARTED TO FALL OUT AGAIN. *…
Read full complaint
THE FENDER ON THE FRONT PASSENGER'S SIDE IS VERY LOOSE. THE ENTIRE FENDER IS HELD ON BY PLASTIC FASTENERS. VEHICLE WAS TAKEN TO THE DEALER, WHO REPLACED THE FASTENERS WITH OTHERS THAT WERE ALSO MADE OF PLASTIC. THE MANUFACTURER WAS AWARE OF THE PROBLEM. *AK THREE MONTHS LATER THE FASTENERS STARTED TO FALL OUT AGAIN. *SC
NHTSA ODI #10053702
Mileage unknown · Mar 31, 2002
Structure
ALUMINUM SUBFRAMES ARE FAILING, SUBFRAMES ARE CRACKING CAUSING THE RIDERS AND PASSENGERS SEAT TO COLLASPE ONTO THE REAR WHEEL.*AK
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN PASSENGER VEHICLES, UNDER AMBIENT TEMPERATURES BELOW -25 DEGREES CELSIUS, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. AS A RESULT, FUEL SYSTEM PRESSURE MAY INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PRESSURE REGULATOR, THE FUEL DELIVER HOSE AND REPLACE THE HOSE CLAMP WITH AN IMPROVED CLAMP. THE RECALL BEGAN ON SEPTEMBER 29, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. UNDER TEMPERATURES BELOW -25 DEGREES, MOISTURE CAN FREEZE IN THE FUEL PRESSURE REGULATOR. FUEL SYSTEM PRESSURE COULD INCREASE AT THE TIME OF ENGINE START UP, CAUSING FUEL LOSS AT THE FUEL PIPE/FUEL HOSE CONNECTION.
Consequence & remedy
Consequence: FUEL LOSS IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL A REDESIGNED INTAKE MANIFOLD VACUUM UNION AND A NEW FUEL PRESSURE REGULATOR. OWNER NOTIFICATION BEGAN JUNE 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Suzuki Grand Vitara Problems, Complaints & Recalls | Skip That Year
Illustration