2001 Subaru Outback

2001 SUBARU OUTBACK AT 90K AFTER 2.5 ENGINE IS STARTED IT RATTLES LIKE THE VALVE LIFTERS ARE NOT GETTING OIL LUBRICATION. IT LAST FOR ABOUT 10 MINUTES OR UNTIL THE ENGINE TEMP GAUGE IS IN THE NORMAL RANGE. IT DOES THIS WHEN THE ENGINE HAS BEEN SITTING MORE THAT 8 HOURS WITHOUT STARTING. CHANGING OF OIL IN CRANKCASE, DID NOT CHANGE THE RATTLING SOUND. UPON TAKING THE VEHICLE TO THE SUBARU DEALER, THE SERVICE MANAGER INFORMED ME THIS WAS A NORMAL CHARACTER FEATURE OF 2001 AND NEWER SUBARU'S THAT HAD THE 2.5 ENGINE AND WAS CAUSED BY PISTON SLAP IN THE ENGINE. THE CORRECT THE NOISE THE OWNER WOULD HAVE TO HAVE THE ENGINE REBUILT TO STOP THE PISTON SLAP. *JB

TL*THE CONTACT OWNS A 2001 SUBARU OUTBACK. THE CONTACT STATED THAT THE ENGINE LIGHT CONTINUES TO ILLUMINATE ON THE INSTRUMENT PANEL AND THE ENGINE SEIZED TWO WEEKS AGO. SHE NOTIFIED THE DEALER AND THE MANUFACTURER AND THEY REQUESTED THAT SHE SEND THE INVOICES FROM THE DEALER, WHERE THEY WOULD MOSTLY LIKELY REPLACE THE ENGINE. THE CONTACT STATED, HOWEVER, THAT THE INVOICES AND REPAIRS WERE DONE SOMEWHERE OTHER THAN AN AUTHORIZED DEALER. THE FAILURE MILEAGE WAS 30,000 AND CURRENT MILEAGE WAS 54,500.

1) UPON COLDER WEATHER STARTING AND DURING THE FIRST 30-40 MINUTES OF OPERATION OUR 2001 SUBARU OUTBACK GETS FUEL VAPORS IN THE PASSENGER COMPARTMENT. 2) FUEL SMELLS CAUSE USE TO ROLL WINDOWS DOWN TO KEEP BREATHABLE AIR AVAILABLE. FUEL VAPOR IS A CARCINOGEN, OF COURSE. OCCUPANTS COMPLAINED OF NAUSEA AND HEADACHES. 3) TOOK CAR TO PAUL BROS. SUBARU AND THEY TOLD US THIS WAS A COMMON COMPLAINT BUT NOTHING TO WORRY ABOUT. 4) SUBSEQUENTLY, LEARNED OF HUNDREDS OF LIKE COMPLAINTS AND A SUBARU SERVICE BULLETIN REGARDING LEAKY HOSES DUE TO LOOSE FUEL CLAMPS AND POOLING FUEL ON CREVICES ON THE ENGINE BLOCK. CONSIDERED NOT A "ENGINE/DRIVETRAIN ISSUE IN WARRANTY AND COST TO REPLACE HOSES HAS BEEN CHARGED TO OWNERS AT MORE THAN $600. PERSONS "INJURED" IS HARD TO DETERMINE DUE TO CHRONIC EXPOSURE OF FUMES IS AN UNCLEAR CONNECTION TO A SINGULAR INJURY. THIS SITUATION SHOULD BE ADDRESSED BY A RECALL AND REPLACEMENT OF HOSES AT SUBARU'S EXPENSE. THE HOSES PERFORMANCE IN COLD WEATHER WAS KNOWN TO SUBARU BEFORE I PURCHASED THE CAR (IN CANADA THIS IS A FAR LARGER ISSUE BTW). I SHOULD EXPECT HOSES TO PERFORM OVER THE PUBLISHED OPERATING TEMPERATURE OF THE VEHICLE OR IN WHAT EVER REGION SUBARUS ARE SOLD. *JB

IT'S BEEN RATHER COLD HERE THE PAST COUPLE DAYS (SINGLE DIGITS, -20 WIND CHILL). I WAS SITTING IN MY 2001 OUTBACK YESTERDAY EVENING LETTING IT WARM UP. I TURNED ON THE DEFROSTER, WINDSHIELD WIPER DEFROSTER INCLUDED. AFTER A FEW MINUTES, I ACTUALLY WATCHED THE WINDSHIELD CRACK FROM BOTH ENDS OF THE DEFROSTER ELEMENT! WHEN I GOT HOME I CHECKED IT OUT FURTHER. THE CRACK EXTENDS THE FULL LENGTH OF THE DEFROSTER ELEMENT ON THE WINDSHIELD. THERE WAS NO IMPACT OF ANY KIND. AS THIS IS OBVIOUSLY UNSAFE, I AM HAVING TO PAY $300 FOR A WINDSHIELD REPLACEMENT. THIS APPEARS TO BE AN ONGOING ISSUE WITH THE SUBARU OUTBACKS. I FEEL THAT THIS IS A DEFECTIVE COMPONENT AND A MAJOR SAFETY RISK. THOUGH THE GLASS MAY NOT BLOW IN, THE SHATTER WHILE DRIVING DOWN THE EXPRESSWAY AT 65 MPH WOULD CERTAINLY CAUSE A MAJOR ACCIDENT. *JB

2001 SUBARU OUTBACK. WHEN THE TEMP FALLS BELOW 20, AND THE CAR HAS SAT FOR SEVERAL HOURS, BRAKES WILL MOMENTARILY NOT WORK. SPECIFICALLY, I APPLY THE BRAKES TO SLOW DOWN, THEY WILL FEEL HARD TO PUSH AND WILL SLOW THE CAR, I LET UP AND PUSH AGAIN, THEY FEEL EVEN HARDER, AND WILL NOT SLOW THE CAR. USUALLY THE FOURTH TIME I PUMP THEM THEY RETURN TO NORMAL OPERATION. THIS HAS HAPPENED IN THE PAST, I TOOK THE CAR TO THE SHOP, WHO SAID THERE WAS NOTHING WRONG. PADS WERE FINE, NO WATER IN THE FLUID. FLUID WAS CHANGED AND PROBLEM HAS RECURRED SINCE THEN. *NM

POWER SUBARU OF SCOTTSDALE FINALIZED THE REPAIR OF THE HEAD GASKET PROBLEM ON DECEMBER 28, 2006 ON OUR SUBARU OUTBACK WAGON. WHILE IN FOR REPAIR FOR THE HEAD GASKET, THE DEALER NOTED THAT THE TIMING BELT TENSIONER NEEDED TO BE REPLACED. POWER SUBARU REPLACED THE TENSIONER WITH A NEW SUBARU TENSIONER (PART #13033AA042.) IT DOES NOT APPEAR THAT POWER SUBARU TEST DROVE THE CAR AFTER THE REPAIRS BASED ON THE MILEAGE IN AND OUT SHOWN ON THE SERVICE INVOICE. THE CAR HAD A CATASTROPHIC ENGINE FAILURE APPROXIMATELY 12 MILES FROM THE DEALERSHIP ON STATE HIGHWAY 87 WHILE BEING DRIVEN AT THE POSTED HIGHWAY SPEED OF 65 MILES PER HOUR AS WE LEFT THE DEALER THAT DID THE REPAIR. THAT ENGINE FAILURE CREATED A SAFETY HAZARD FOR MY WIFE, MARGARET, WHO HAD TO COAST DOWN THE HIGHWAY TO A SMALL ROAD TO SAFELY PULL OFF. IF THE ROAD/PULL OUT AREA HAD NOT BEEN AVAILABLE TO HER, SHE WOULD HAVE HAD TO PARTIALLY BLOCK THE HIGHWAY LANE OF TRAFFIC SHE WAS IN. SHE COULD HAVE BEEN HIT BY ANOTHER CAR COMING BEHIND HER AT A HIGH RATE OF SPEED INJURING/KILLING HER OR POSSIBLY OTHERS. IT APPEARS THAT THIS PART HAS FAILED ON OTHER SUBARU VEHICLES CREATING CATASTROPHIC ENGINE FAILURE AND A VERY HAZARDOUS SITUATION. POWER SUBARU TOLD ME SINCE THAT THE ENGINE WILL REQUIRE A COMPLETE REBUILD SINCE THE FAILURE OF THE TENSIONER THEY INSTALLED SUBSEQUENTLY CAUSED THE NEW TIMING BELT TO BREAK WHICH THEN CAUSED SEVERE DAMAGE TO THE ENGINE. SUBARU HAS OFFERED TO REPLACE THE ENGINE WITH A MANUFACTURE REBUILT ENGINE AND WILL WARRANTY THE ENGINE FOR 36,000 MILES OR THREE YEARS, BUT HAVE FAILED TO PROVIDE US WITH A RENTAL CAR REPLACEMENT FOR THE TWO WEEK REPAIR TIME. WE NEED AN ALL-WHEEL DRIVE OR 4 WHEEL DRIVE REPLACEMENT VEHICLE SINCE WE HAVE SNOW. THEY ONLY OFFERED TO PAY FOR 1/2 THE RENTAL COST OF A SMALL TWO WHEEL DRIVE VEHICLE WHICH IS NOT ADEQUATE. SUBARU SHOULD CHANGE THE MANUFACTURING OF IT'S TIMING BELT TENSIONER SINCE THIS FAILURE HAS HAPPENED IT'S OTHER VEHICLES AND IS HIGHLY DANGEROUS. *NM

WITHIN 4 YEARS, MY SUBARU OUTBACK VCD NEEDED 3 SETS OF BRAKES AND 4 SETS OF ROTORS (NOT INCLUDING THE "RESURFACING" TO EXTEND THE ROTORS). EVERYTIME WHEN I BROUGHT THE CAR TO THE DEALERSHIP, THEY ATTRIBUTE THE PROBLEMS TO MY DRIVING PATTERN. BUT I OWNED THREE OTHER CARS BEFORE (ALL WERE LESS EXPENSIVE), AND NEVER NEEDED TO REPLACE BRAKES NOR ROTORS. AS POSTED IN THIS WEBSITE, THERE ARE 13 OTHER COMPLAINS, WITH VIRTUALLY IDENTICAL PROBLEMS. I STRONGLY RECOMMEND NHTSA ENGINEERS TO ANALYZE THE 2001 SUBARU OUTBACK BRAKES AND ROTORS. NOT ONLY IT IS A PUBLIC SAFETY ISSUE, IT IS ALSO A COMPANY RESPONSIBILITY ISSUE: SUBARU SHOULD BE RESPONSIBLE FOR ALL REPAIR COST, NOT TO MENTION THE INCONVENIENCE, OUR TIME, EMOTIONAL STRESS CAUSED TO THE VEHICLE OWNERS. *NM

2001 OUTBACK HAD A HEAD GASKET PROBLEM THAT NEEDED TO BE REPLACED. *TS THE CONSUMER WAS INFORMED BY CUSTOMER SERVICE THAT A RECALL HAD BEEN ISSUED REGARDING THE PROBLEM THEY WERE HAVING, AND THE VEHICLE NEEDED TO BE TAKEN TO AN AUTHORIZED SERVICE DEALER. THE CONSUMER HAD ALREADY HAD THE WORK DONE BY HIS LOCAL REPAIR SHOP. THE CONSUMER WAS THEN TOLD TO TAKE THE VEHICLE TO AN AUTHORIZED DEALER TO HAVE THEM VERIFY THAT THE WORK WAS DONE. THE CONSUMER LEARNED THAT THE HEAD GASKET HAD BEEN REPLACED PRIOR TO HIM PURCHASING THE VEHICLE. THE CONSUMER ALSO DISCOVERED THE HEAD GASKET USED WAS 3 PIECES AND THE WORK DONE PREVIOUSLY ONLY 1 PIECE WAS REPLACED, WHICH WAS OPPOSITE FROM THE # CYLINDER. THE LOCAL REPAIR SHOP THAT REPLACED THE HEAD GASKET FOR THE THIRD TIME, TOLD THE CONSUMER HE UTILIZES ONLY A SOLID ONE PIECE GASKET AND HAD THE BEEN DONE ORIGINALLY, THE CONSUMER MAY NOT HAVE HAD ANY PROBLEMS. *JB

CONSUMER SUBARU OUTBACK TAIL LIGHTS BURNED OUT QUITE OFTEN. AFTER REPLACING THE BULB CONSUMER NOTICED THAT THE SOCKET WAS CORRODED. *TS THE ENGINE STALLED WHILE DRIVING UP A SMALL HILL. THE VEHICLE WAS TOWED WHERE IT WAS DISCOVERED A BLOWN 30 AMP FUSE IN THE MOTOR SIDE FUSE BOX. THE INCIDENT HAPPENED A SECOND TIME AND THE VEHICLE WAS TAKEN TO A DIFFERENT DEALER WHERE THE PROBLEM WAS DIAGNOSED AS A BLOWN FUSE AGAIN. WHEN THE CONSUMER OPENED THE HATCH, WATER WAS POURING OUT OF THE LITTLE DOORS THAT HOUSED THE TAIL LIGHTS BULBS AND WIRES. THE CONSUMER BELIEVED THE LEAKING HATCH WAS RESPONSIBLE NOT ONLY FOR THE BURNED OUT TAIL LIGHTS AND ROTTING WIRES, BUT ALSO FOR THE ELECTRICAL SHORTS THAT BLEW OUT THE 30 AMP FUSE IN THE ENGINE COMPARTMENT AND CAUSED THE ENGINE THE DIE.*JB