2001 Subaru Outback

2001 SUBARU OUTBACK LEAKS FUEL IN COLD WEATHER. READ ON THE WEB ABOUT HUNDREDS OF OWNERS WITH THIS COMPLAINT. LIVE IN MASSACHUSETTS AND WHEN THE WEATHER GETS BELOW ABOUT 25 DEGREES FUEL SMELL FILLS THE PASSENGER CABIN. APPEARS TO COME FROM UNDER THE ENGINE MANIFOLD. HOPE TO NOT PASS OUT FROM FUEL VAPORS. HAVEN'T HAD A FIRE YET. 2ND ISSUE IS HEAD GASKET LEAK WHICH WAS A $1500 REPAIR. ALSO APPEARS TO BE A COMMON ISSUE WITH SUBARU. *TR

IN COLD WEATHER OUR CAR BEGAN EMITTING A VERY STRONG FUEL SMELL IN THE PASSENGER COMPARTMENT. OUR SUBARU DEALER DENIES THERE IS ANYTHING WRONG THAT WOULD WARRANT A SAFETY RECALL OR BULLETIN. THEY WILL NOT ACCEPT IT IS A DESIGN DEFECT WHEN CLEARLY THE FUEL LINES BEGIN TO LEAK IN COLD (SUB-FREEZING) TEMPERATURES. AS GASOLINE IS A SERIOUS CARCINOGEN AND EXPOSURE TO ITS FUMES CAUSES BRAIN DAMAGE, THIS SHOULD BE REGARDED AS AN EXTREMELY SERIOUS HEALTH ISSUE. *TR

1) UPON COLDER WEATHER STARTING AND DURING THE FIRST 30-40 MINUTES OF OPERATION OUR 2001 SUBARU OUTBACK GETS FUEL VAPORS IN THE PASSENGER COMPARTMENT. 2) FUEL SMELLS CAUSE USE TO ROLL WINDOWS DOWN TO KEEP BREATHABLE AIR AVAILABLE. FUEL VAPOR IS A CARCINOGEN, OF COURSE. OCCUPANTS COMPLAINED OF NAUSEA AND HEADACHES. 3) TOOK CAR TO PAUL BROS. SUBARU AND THEY TOLD US THIS WAS A COMMON COMPLAINT BUT NOTHING TO WORRY ABOUT. 4) SUBSEQUENTLY, LEARNED OF HUNDREDS OF LIKE COMPLAINTS AND A SUBARU SERVICE BULLETIN REGARDING LEAKY HOSES DUE TO LOOSE FUEL CLAMPS AND POOLING FUEL ON CREVICES ON THE ENGINE BLOCK. CONSIDERED NOT A "ENGINE/DRIVETRAIN ISSUE IN WARRANTY AND COST TO REPLACE HOSES HAS BEEN CHARGED TO OWNERS AT MORE THAN $600. PERSONS "INJURED" IS HARD TO DETERMINE DUE TO CHRONIC EXPOSURE OF FUMES IS AN UNCLEAR CONNECTION TO A SINGULAR INJURY. THIS SITUATION SHOULD BE ADDRESSED BY A RECALL AND REPLACEMENT OF HOSES AT SUBARU'S EXPENSE. THE HOSES PERFORMANCE IN COLD WEATHER WAS KNOWN TO SUBARU BEFORE I PURCHASED THE CAR (IN CANADA THIS IS A FAR LARGER ISSUE BTW). I SHOULD EXPECT HOSES TO PERFORM OVER THE PUBLISHED OPERATING TEMPERATURE OF THE VEHICLE OR IN WHAT EVER REGION SUBARUS ARE SOLD. *JB

I HAVE GONE THROUGH ONE HEAD GASKET ON JAN 2003. THE HEAD GASKET WENT OUT IN DEC OF 2003 AND THE WHOLE ENGINE HAD TO BE REPLACED. IN JANUARY OF 2004 I HAD THE OVERHEAD CAMGASKETS GO OUT ON THE CAR AS WELL AS THE THE OXYGEN SENSOR. I HAVE HAD MORE ISSUES BUT IT WOULD BE A SMALL BOOK. SUBARU HAS BEEN RELATIVLY UNRESPONSIVE EVEN AFTER MANY PHONE CALLS AND LETTERS TO MY CONCERNS. EVERY PART WAS REPLACED HOWEVER THERE SEEMS TO BE A POROBLEM WITH MY NEW ENGINE SINCE THERE IS NOW AN INVESTIGATION WITHIN SUBARU. THEY REFUSE TO PAY THE DEALERSHIP FOR THE NEW ENGINE REPLACEMENT WHICH RAISES THE QUESTION OF WAS THIS A NEW ENGINE OR WHAT IS WRONG WITH THE NEW ENGINE. *AK