2021 Subaru Forester

My Subaru Forester has a significant safety defect. If my web searches are representative this software problem affects multiple models and years of Subaru. I have addressed this problem with the local dealer, Subaru America, and Subaru Japan and have been told "that is the way it was designed and it is supposed to do that." As you may imagine that is not a satisfactory answer to a significant safety issue; I can only imagine Ford saying the Pinto was designed with a gas tank that explodes in a collision or a more recent Takata claiming that their seatbelts were designed that way. So here is the problem in a nutshell (and I have a host of Emails from various levels of Subaru if you want the details of how I have attempted to get them to address the issue.) There is a sensor on the gas cap that detects if it is not fully closed since that is a pollution control issue. (More on that later) When that sensor is activated, it disables the Subaru Eyesight system and when the Eyesight system is disabled it disables every safety feature except the seatbelt and it lights up the dash with a dozen alarms none of which have anything to do with the gas cap. That takes down collision avoidance, lane changing, and autodim headlights among others. It also wants you to check the engine and consult the users manual. None of that has anything to do with the actual situation. Now I have taken the car to the dealer who assures me it is operating as designed and there is no fault in the sensor. When you close the gas cap there are audible clicks and as a 190 pound man I can assure you that the cap is fully closed when I close it. But on a random basis the dashboard lights up despite the fact that the gas cap is fully engaged and the safety systems become disabled. Usually it stays lit up until I refill the tank, but its behavior is not predictable - occasionally it just resets as I drive. Besides the obvious hazard of having safety systems which do not work, havi

I am writing to file a formal complaint regarding repeated, severe, and dangerous malfunctions of the vehicle's engine Start/Stop (Idle Stop) feature. The system is failing to operate as intended, resulting in the engine stalling while the vehicle is in motion or under crucial driving circumstances, creating significant safety hazards. History of Incidents I have experienced four separate incidents where the engine unexpectedly stalled or shut down, creating extreme risk: Incident 1 (Railroad Tracks): The engine stopped while I was actively driving over railroad tracks. The car stalled on the tracks, and within seconds of the engine restarting, the crossing gates came down and a train passed. I narrowly avoided being hit by the train, missing the impact by approximately ten seconds. Incident 2 (Heavy Traffic/Bridge): During heavy, back-to-back traffic as a bridge (PGA bridge) was opening, the car momentarily stopped and then resumed movement. The unpredictable stopping motion created a severe risk of being rear-ended, as the following vehicle would have had difficulty anticipating the sudden, unintended stop. Incident 3 (December 2025): While taking a right turn, the engine stopped suddenly, with dash lights blinking, during only a slight pause in vehicle movement. This occurred while the vehicle was still maneuvering. Incident 4 (The following day): The engine stopping malfunction described in Incident 3 occurred again the next day. Attempted Repair and Ongoing Concern Two years ago, the dealership installed a new battery following the first two incidents. However, the problem has now recurred this week (December 2025). The dealership has informed me that using a third-party device to permanently disable the Start/Stop function would void the powertrain warranty. Causing Mechanical Stress: I believe the continuous, potentially faulty activation is putting unnecessary stress on the battery, electrical system, and engine components, which may ultimately shor

After arriving home from a short drive to the grocery store I parked my car in the drive way and went inside. On the drive home I could hear a low humming coming from the speakers and the car was decelerating when the accelerator was not being pressed, no warning lights or sounds came on. About 10 minutes after I parked a neighbor knocked on the door letting me know my car was smoking from inside the hood. Within a minute or 2 the entire hood of the car was engulfed in flames. The entire front half of the car burned to a crisp, the fire also burned half a tree. The car was burning so hot that it melted the hood of the car, had I parked it with the hood facing my house my house would have caught fire. The problem has not been reduced or confirmed by dealer or independent service. The vehicle is being stored by the insurance and for the time being is accessible for investigation. Because I was having trouble with the infotainment system, the humming coming from the speakers, and a recent warranty extension by from Subaru for the infotainment system due to known issues I suspect that the fire was caused by electrical issues.

On August 12, 2025, at approximately 10:16 AM, while driving at normal speed on CR-43 NW southbound just past Minnesota Ave in Big Lake, MN, my Subaru’s EyeSight Driver Assist System, specifically the Automatic Emergency Braking (AEB) / Pre-Collision Braking System, suddenly activated without warning and with no obstacle present. The braking was abrupt and unnecessary, causing the vehicle behind me to nearly rear-end mine. Road conditions were clear, dry, and unobstructed, with no pedestrians, vehicles, or hazards in my lane. This appears to have been a “false positive” from the AEB system. This sudden stop placed both my safety and the safety of other drivers at serious risk, and in different circumstances could have caused a collision resulting in injury or death. The vehicle is available for inspection upon request. The problem has not been reproduced or confirmed by a dealer or service center because Subaru requires a $200 diagnostic fee, which I have not paid. The vehicle has not been inspected by Subaru, police, insurance, or any other parties for the same reason. No warning lamps, error messages, or other indicators appeared prior to the incident. All systems appeared to be functioning normally before the unexpected braking occurred. I am concerned this defect persists beyond 48,000 miles, outside the limits of prior settlements, and believe Subaru should issue a recall covering all affected vehicles, regardless of mileage, to prevent potential crashes.

Was stopped at traffic light. Start Stop system was engaged. Engine turned off as normal. When I took my foot off the brake the engine did not engage and the Eyesight warning light came on that the Eyesight system was not functioning. Put the car in park and engaged the ignition button and the engine started. Turned off the Start Stop system and the car functioned normally after that. Have read postings on Subaru forum that this has happened to others.

**Component Malfunction**: The windshield developed cracks shortly after purchase, which expanded without impact, affecting visibility and causing the Safety Eyesight system to malfunction. **Safety Risk**: The expanding crack impaired vision and led to safety system malfunctions, posing a risk to driver and passenger safety. **Problem Reproduction**: It is unclear if the issue has been reproduced or confirmed by a dealer or service center. **Inspection Status**: The vehicle has not been inspected by the manufacturer, police, or insurance representatives. **Warning Signs**: There were no warning lamps or messages prior to the failure; the issue appeared in the first week after purchase.

The contact owns a 2021 Subaru Forester. The contact stated while driving 40 MPH, the automatic emergency braking system activated, bringing the vehicle to a complete stop. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to duplicate the failure. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was 24,000.

Braking system sometimes is activated by a sign on the side of the road, by a tree if we are turning, or nothing at all. Nearly in 2 rear end collisions when the system activated incorrectly. We cannot drive into our garage with the system activated...brakes keep slamming on. The only safe way to operate this subaru is to manually turn it off every time we start the car. Subaru dealership states it cannot recalibrate the eyesight system as it does not have that ability. Dealership is in Corvallis oregon. Lane notification system also has issues in construction zones (it tries to steer the car into the water barriers marking the lane changes. At least the side warning system can be permanently disabled. We have filed many complaints with subaru to no avail. Promised return phone calls never happen, phone transfers to their technical department result in dropped calls. This system is dangergous!!!