2023 Subaru Forester

I am writing to formally report a critical safety defect regarding the driver-side footwell design in my 2023 Subaru Forester Sport, which poses an immediate and severe risk of a crash. A hard plastic lower extension for the HVAC air duct sits dangerously low directly above the brake and accelerator pedals. For drivers with larger or longer feet, this duct extension acts as a physical obstruction that interferes with safe pedal operation in two specific, highly dangerous ways: Delayed Braking: When attempting to transition from the accelerator to the brake pedal, the toe of the driver's shoe frequently catches on the lip of the air duct extension, delaying the ability to depress the brake pedal in time-sensitive or emergency situations. Pedal Entrapment: When the brake pedal is depressed, the driver's foot can become completely wedged between the brake pedal arm and the air duct extension. This traps the foot, making it impossible to smoothly or quickly release the brake. The physical proximity of this hard plastic duct to the primary driving controls is a severe design flaw. The air duct should not protrude into the clearance space required for standard footwear, as it directly compromises the driver's ability to control the vehicle's speed and braking. I have photo and video documentation clearly demonstrating the lack of clearance and exactly how a shoe becomes caught and wedged during normal driving maneuvers. I am requesting that the NHTSA Office of Defects Investigation (ODI) review this hazard immediately, as this spatial interference requires a recall and physical redesign of the lower ductwork to prevent potential collisions, injuries, or fatalities. The component causing the issue is the physical HVAC ductwork extension, and the vehicle is available for inspection upon request. Because this is a physical design flaw rather than an breakdown, there were no warning lamps or dashboard messages. I have photo and video documentation.

Eyesight collision braking system engaged as I was rolling up my driveway to go into garage. Garage door was rolling up and was about 5 feet off the ground when Anti Collision system engaged and slammed the brakes on. I was going under 1 mph and would not have hit the door. It beeped right before brakes engaged. This is the second time it has engaged when it shouldn't have. The first time was in a right lane, a car about 6 car lengths in front of me was and did turn right as I was driving down the road. It almost caused an accident with the car behind me. The brakes slammed on so hard my back and neck are now sore and it bent my fingernail backwards somehow on the steering wheel.

The contact owned a 2023 Subaru Forester. The contact stated that while driving at an undisclosed speed, the vehicle independently accelerated, and the Forward Collision Avoidance system was inoperative, causing the front center of the vehicle to crash into five other vehicles while trying to stop the vehicle. The air bags deployed as needed. No warning lights were illuminated. The vehicle was deemed a total loss at the scene. A Police report was filed. No injuries were sustained, and medical attention was not needed. The manufacturer was not notified of the failure. The failure mileage was approximately 15,000.

My vehicle has experienced repeated stalling events, including while the vehicle is in operation. The first occurrence began at approximately [mileage] and has continued intermittently despite multiple service visits. During these incidents, the vehicle unexpectedly loses power without warning. This creates a serious safety concern, particularly when driving in traffic, as it increases the risk of collision due to sudden loss of acceleration and potential impact on vehicle control. The issue appears to be intermittent and cannot be reliably reproduced. In some instances, a check engine light has appeared in connection with the events. Despite multiple attempts to diagnose and repair the vehicle at an authorized dealership, the problem has not been resolved. I have been informed that prior issues may have been addressed; however, I was also told that the root cause has not been definitively identified, and there is no assurance that the stalling will not occur again. The vehicle has been in service multiple times without a confirmed fix. Despite this, I have also been told that there are “no safety concerns” and that the vehicle is safe to operate. This is concerning given the unresolved and recurring nature of the issue. The vehicle is primarily used to transport my young children, which heightens the urgency of this safety risk.

This vehicle has died 4 times in one week. when this happens, multiple lights have flashed in the dash board, including the "eye sight" warning. Then, it would not restart but continued to "turn over" when the ignition button was pushed. One instance was on a busy street at a stop light, another at a busy intersection in the inner left turn lane, the other 2 instances were in parking lots. The first 2 times the vehicle was able to be jump started and was not taken to the dealership. The 3rd, it was jump started and taken to the dealership. They said the battery was slightly low, but had sufficient charge. They changed the fob battery, and topped off the car battery. That was all. The next day was the episode where it died in the turn lane. I had it towed to the dealership. This time they changed the battery to a more high capacity battery, and admitted that these vehicles have a battery put in them at the manufacturer that is not strong enough for the systems it runs. I even found a service bulletin about it online, #TSB 07-218-23R. This should be a recall item, and they should have changed this battery at my first visit! A vehicle suddenly dying on a busy roadway puts those inside at risk, as well as everyone around them. Very disappointed in this 2023 Subaru Forester Premium.