2020 Subaru Forester

**Component or System:** Subaru EyeSight Driver Assist System (specifically the Pre-Collision Throttle Management system). **Incident Description & Warning Messages:** There were no warning lamps, messages, or symptoms of any problem prior to this failure. The incident occurred while I was stopped at a red light at a busy intersection. When the light turned green, I removed my foot from the brake and pressed the gas pedal to proceed, but the vehicle would not accelerate. The system had engaged a false-positive throttle cut. At that exact moment, the car began beeping repeatedly and the EyeSight logo flashed on the dashboard, incorrectly indicating an obstacle or imminent collision, even though the path in front of my vehicle was completely clear. **Safety Risk:** My safety and the safety of others were put at significant risk because the vehicle was unexpectedly immobilized in an active intersection during a green light. This sudden, unwarranted loss of acceleration created a high risk of being rear-ended by the drivers behind me who were expecting the flow of traffic to resume. **Reproduced, Confirmed, or Inspected:** Because this incident just occurred, the problem has not yet been reproduced or confirmed by a dealer or independent service center. Furthermore, the vehicle has not yet been inspected by the manufacturer, police, or insurance representatives.

While driving on public roads, all dash warning lights illuminated simultaneously. The instrument cluster displayed “EyeSight OFF.” At the same time, the electronic parking brake engaged / the vehicle would not accelerate and required me to stop and shift to Park. The only way to restore drivability was to turn the vehicle off and restart. This has occurred intermittently, including in traffic, creating a serious safety hazard for myself and surrounding drivers.

I, the owner of a 2020 Subaru Forester am writing to you in regards to an issue with my vehicle’s Eyesight program. Over the past month, there have been several instances where the Eyesight program fails and caused the vehicle to suddenly stop without warning. This prevents me from safely moving the vehicle to the side of the road as the car stops. In other words, the car abruptly stops on the spot. This creates an immediate danger to life and health to myself and to other motorists. This issue must be addressed immediately and the necessary steps taken to ensure the safety the driver, passengers and other motorists on the road. Thank you for understanding.

In April 2022 after owning the car for 4 weeks the Eyesight went out. I was told it was due to the thermal control module. That was replaced. I’m n June 2023 the AC went out. They said it was the blower motor. That was replaced. In September 2023 the AC went out again. At that point they found the cause was actually a fully melted fuse box and fuses. They replaced the fusebox and the entire AC system. I have had 3 batteries in the vehicle since March 2022. In December 2024 they found that my car needed an update and the update friend the transmission controls module. Then the starter went out at the same time. After that was fixed a week later all the lights in my dash came on and there were no safety features running in the vehicle. I reach out to Subaru and I was told this was all normal wear and tear in the vehicle and it just happens. A melted fuse box and safely features just randomly dying on a 4.5 year old car goes deeper than that. There has been almost $12000 in repaired performed on this car and the ones remaining are undiagnosed as they have never seen the codes before. This is a mush larger issue and Subaru refuses to do anything.

The contact owns a 2020 Subaru Forester. The contact stated that while driving at approximately 30 MPH, the brake pedal of the vehicle was applied inadvertently without any vehicles surrounding the vehicle. The contact stated that simultaneously a " Pre collision braking system was activated " message appeared. The vehicle was taken to the residence. The vehicle was towed to a dealer where the failure was not replicated. The manufacturer was notified of the failure. The failure mileage was approximately 26,000.

"Check Engine" light along with "Eye Sight" appeared suddenly on Nov. 22, 2024. All safety systems along with cruise control became inoperable. Took car to Subaru dealer and it was confirmed to be the catalytic converter. My VIN is covered under extended warranty, but I was never notified of this. Plus, now repairs are of an emergency nature. Also, I do a lot of driving including on the NJ Turnpike, I-95, etc., and while I am awaiting car to be repaired, I have no safety features to rely on--which was one of the reasons I bought a Subaru. They will not pay for a courtesy car loan. Another issue is the Thermo Control Valve. I was notified that I have an extended warranty for this, but part has to FAIL before Subaru will make repairs. Once again this becomes an emergency repair situation instead of a proactive one.

Eyesight pre-collision braking feature and pre-collision throttle management feature malfunctioned and caused the 2020 Forester to accelerate unexpectedly and lurch forward while I was manually braking and slowing to come to a complete stop behind two other vehicles stopped at a steady red light. See class action lawsuit Weston, et al. v. Subaru of America, Inc., et al. In US District Court Case No. [XXX] which alleges that the vehicle contains certain defects that caused sudden and unintended acceleration without driver input; acceleration while manually braking; and that these defects created a safety risk, because they severely affected the driver's ability to control the car's speed, acceleration, and deceleration, and increase the risk of a collision, which did in fact occur. The defective car was completely totaled and towed to a salvage yard by the police and the insurance company. Defect malfunction caused a collision which resulted in property damage and personal injury to three vehicles and three people. I mentioned the defect to my insurance company at the time of the accident. I do not know if they chose to follow up and inspect the vehicle. The problem occurred twice before ( not resulting in property damage or injury) and I took it to my Subaru dealer both times and they claim that they could not find anything wrong, but oddly did not note that they checked for the problem which I brought to their attention on the written summary/invoice for my service visit. See the class action lawsuit- this is apparently the typical dealer non-response to the problem. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Within one month the same thing happened. I turn on the car and the eyesight warning light is on (eyesight feature disabled), flashing "S" drive is on, "break" light is on, and check engine light is on. Due to this cruise control isn't working. My plan was to take it to a mechanic/dealership that Monday. By Monday morning, after about 15 minutes of driving, all warning signs disappeared. This exact thing happened a few weeks later (this morning). I started googling issues and seems like this is an issue for many customers and is just a malfunctioning Thermo Control Valve, no actual problem. What do I do about this? This is much less important - but also seems like a quality issue, at drivers side, the seat cover is starting to crack, looking like this is car is over 10 years old, we've had it for less than 4 years and this shouldn't be happening on a car of this caliber. Photos attached

2020 SUBARU FORESTER JUST HAD A CHECK ENGINE LIGHT APPEAR. THE ENGINE MALFUNCTION CODE IS P26A3, WHICH IS A DEFECTIVE THERMOSTATIC CONTROL VALVE. THIS MALFUNCTION ALSO AFFECTS THE VEHICLE MANUFACTURERS ADVANCED DRIVER ASSITANCE SYSTEMS SUCH AS: "EYESIGHT" BLIND SPOT MONITORING, LANE KEEP ASSIST, ETC. VEHICLE ONLY HAS 51,000 MILES ON IT.

I was driving to work and many of my warning lights suddenly came on. This includes my check engine light, my lane assist light, my auto collision braking, my eye sight disabled and my cool engine light keeps going on and off. My cabin heating also isn’t working. There is no reason for this happening other than my thermo control valve failing.