2015 Subaru Forester

My issue (which started a week ago) is that the Occupant Detection System (ODS) shows the passenger airbag as OFF and gives an SRS Airbag warning when my spouse is sitting in the passenger seat. When I sit in the passenger seat, the passenger airbag shows ON. But then when the car is driven with no passenger, the system dings until the driver hooks the passenger seatbelt--it thinks the passenger is still there. (I weigh 190; my spouse weighs 125). The consequences are that if the vehicle is involved in a crash and my spouse is in the passenger seat, her airbag will fail to deploy. If anyone is driving without a passenger (after I have been in the passenger seat) the passenger airbag may deploy unnecessarily, should a crash occur. My ODS harness was replaced in Feb., 2020 as part of NTSA Safety Recall ID 19V-701 (Subaru Safety Recall WUM-98) to address faulty ODS issues. (I was not having an issue then). Yesterday my local Subaru dealer recommended "Seat frame bottom replacement and ODS harness DTC B1760, 17067" to address this "ODS Internal Failure." "Part is on back order" so repair is pending.

The passenger occupancy sensor does not accurately detect if there is a passenger. This results in the airbag being "off" when a passenger is in the car. This is a known defect for other 2015 subaru foresters, but is not listed as a defect with my VIN. The sensor will also error and require a buckle when there is no weight on the seat.

A small crack appeared mysteriously on the front windshield and has spread - over the past month - where it now covers 1/2 of the windshield. Nothing hit my car, to create the crack or make it spread. The right air bag light keeps going on and keeps beeping when there is no one sitting in the seat. The only way i can get it to stop is to engage the seat belt - again, even though there is no one in the seat.

The contact owned a 2015 Subaru Forester. The contact stated while his wife was driving at approximately 25 MPH, and moving into an intersection following a traffic sign stop, the contact's vehicle was crashed into by another vehicle that ran a stop sign. The other vehicle crashed the contact's vehicle on the passenger side front door. The contact stated that all the air bags had deployed. The contact stated that his wife had broken her right thigh and right ankle. The contact stated he suffered severe whiplash and concussion. The contact stated that he and his wife were transported to the emergency room. The contact stated that he later had to undergo a fusion of several neck vertebrae. The contact stated that the air bag on the passenger side had exploded and he had burns and abrasions on the right side of his face due to the exploding air bag. The contact stated that the exploding air bag fragments had penetrated the right side of his face and neck. The vehicle had been towed away and later declared a total loss by the contact's insurance provider. The manufacturer had not been informed of the failure. The failure mileage was 12,000.

Info Center showed a message Air Bag System needs servicing. Return codes B160 when codes were checked. Dealer said The Occupant Detection Pad needed to be replaced, must have got wet. there are over a page of 2015 Owners @ [XXX] with the same issue and same explanation, most indicate they had the recall work for the connection performed when the recall was issued. Seems Subaru has an Issue with the Occupant Detection Pad! This puts passengers in danger of the air bag not deploying. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Subaru just failed inspection for a defective airbag sensor in the front passenger side. We had this repaired at a Subaru dealer in Jan 2020, to the tune of $1500. There was a recall in 2020 for this exact problem, and our vehicle fell with the guidelines (2015-2018 Foresters equipped with heated seats), but for some reason our vehicle wasn't included in the recall. So we paid for our fix out of pocket. Now 2 years later we are seeing the same problem. This is unacceptable on Subaru's part. Why is our vehicle excluded from the recall when it is obviously having the same problem?

When passenger sitting in front right seat, airbag indicator says "airbag off" and warning light flashes "check airbag system". This is an intermittent problem occurring a few times over the past three months. Brought it into the Subaru dealer who recommended replacement of the seat cushion for $1425. I checked the Internet and found Subaru recall WUM-98 describing the same problem. I checked repair history and found that the dealer had performed the recall repairs in December 2020. I now suspect a faulty recall repair at that time since I now have the exact problem described in the recall notice even though there was no problem before they did repair. Subaru customer service refuses to cover the expense of a new repair.