TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC BODY CONTROL MODULE WAS FAULTY AND NEEDED TO …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE OPERATING THE VEHICLE, THE SPEED SENSOR AND TRACTION CONTROL SENSOR LIGHTS ILLUMINATED AND THE BRAKING DISTANCE INCREASED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ELECTRONIC BODY CONTROL MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. ALSO, THE SLIDING DOOR CHIME ACTIVATED EVEN THOUGH BOTH SLIDING DOORS WERE CLOSED. ALSO, THE STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN. THE CAUSE OF THE FAILURES WERE NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 90,000. UPDATED 09/08/16*LJ *CN
NHTSA ODI #10885096
111,934 miles · Mar 21, 2011
Electrical SystemEngine And Engine CoolingTraction Control System
I HAVE A PROBLEM WITH THE ABS/TRACTION CONTROL LIGHT COMING ON AND THE BRAKING SYSTEM WILL NOT OPERERATE PROPERLY. THERE HAS BEEN A FEW TIMES WHERE THE BRAKES WILL NOT STOP THE VEHICLE PROPERLY OR HAVE LOCKED UP A COUPLE OF TIMES. WE ALSO HAD TO REPLACE THE EGR VALVE DO TO A CODE 0414/0414. WE ALSO HAD TO REPLACE THE PCM BECAUSE…
Read full complaint
I HAVE A PROBLEM WITH THE ABS/TRACTION CONTROL LIGHT COMING ON AND THE BRAKING SYSTEM WILL NOT OPERERATE PROPERLY. THERE HAS BEEN A FEW TIMES WHERE THE BRAKES WILL NOT STOP THE VEHICLE PROPERLY OR HAVE LOCKED UP A COUPLE OF TIMES. WE ALSO HAD TO REPLACE THE EGR VALVE DO TO A CODE 0414/0414. WE ALSO HAD TO REPLACE THE PCM BECAUSE THE SYSTEM LOCKED UP AND DELETED ALL THE CODES CAUSING THE ENGINE TO FAIL TO START WHILE TRING TO UPDATE THE PCM TO RECOGNIZE THE NEW EGR. I ALSO HAVE PROPLEMS WITH THE LIGHTS FLICKERING AND DIMMING ALL THE TIME. THESE PROBLEMS EXIST EVERY DAY AND I FEEL THE VEHICLE IS GETTING UNSAFE TO DRIVE. I HAVE CONTACTED GM SEVERAL TIMES AND TOOK THE VEHICLE TO A LOCAL DEALERSHIP TO GET THE PCM REPLACED. THEY WOULD NOT GIVE ME THE OLD PCM BUT I HAVE THE ORIGINAL DELPHI EGR VALVE. GM SAID THTHAT THE 2005 RELAY HAS RECALLS ON THE EGR AND PCM BUT MY VIN WAS NOT AFFECTED AND REFUSED TO PAY ANY ON THE REPAIRS OR PAY TO HAVE THE VAN CHECKED OUT AT A GM DEALERSHIP. *TR
NHTSA ODI #10392413
148,000 miles · Nov 19, 2010
Electrical SystemService Brakes, HydraulicTraction Control System
I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DR…
Read full complaint
I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DRIVING! SECOND ISSUE IS ABS/TRACTION CONTROL LIGHTS HAVE BEEN COMING ON SPORADICALLY SINCE I PURCHASED IT. OF COURSE, NO ONE CAN FIND THE PROBLEM BECAUSE THEY CAN'T REPLICATE IT. IT DOESN'T MATTER THE DRIVING CONDITIONS, DRIVING TIME, WEATHER OR ANYTHING ELSE. BOTH HAVE HAPPENED AT VARIOUS SPEEDS. CURRENTLY THE LIGHTS ARE STAYING ON MORE THAN OFF AND YESTERDAY WHILE DRIVING, THE WARNING LIGHTS WERE OFF UNTIL I STEPPED ON THE BRAKES, FELT AND HEARD A CLUNKING SOUND, THE BRAKE PETAL GAVE WAY SOME, AND THE SERVICE ABS/NO TRACTION CONTROL LIGHTS CAME BACK ON AGAIN. THE CAR DID STOP. TALKED TO THE USED CAR DEALERSHIP THAT SOLD IT TO ME AND I AM CURRENTLY MAKING ARRANGEMENTS TO HAVE VEHICLE LOOKED AT. IN RESEARCHING I HAVE FOUND NUMEROUS COMPLAINTS ABOUT THESE SAME ISSUES ON A NUMBER OF FORUMS. *TR
NHTSA ODI #10366814
79,761 miles · Jun 28, 2010
Traction Control System
I HAVE A 2005 SATURN RELAY. I PURCHASED THE VEHICLE "USED" FROM SATURN OF TEMPE ON MARCH 1ST, 2009. THE MILEAGE ON THE VEHICLE WHEN I PURCHASED IT WAS 62,245. ONE YEAR LATER I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT OCCASIONALLY, BUT BOTH WER…
Read full complaint
I HAVE A 2005 SATURN RELAY. I PURCHASED THE VEHICLE "USED" FROM SATURN OF TEMPE ON MARCH 1ST, 2009. THE MILEAGE ON THE VEHICLE WHEN I PURCHASED IT WAS 62,245. ONE YEAR LATER I STARTED GETTING "SERVICE TRACTION CONTROL SYSTEM" WARNING MESSAGE AND LIGHT WITH "SERVICE ABS SYSTEM" WARNING MESSAGE AND LIGHT OCCASIONALLY, BUT BOTH WERE ALWAYS AT THE SAME TIME. SHUTTING OFF THE ENGINE AND RESTARTING (PER OWNER?S MANUAL) TEMPORARILY CAUSED THE LIGHTS AND MESSAGES TO TURN OFF, BUT RETURNED DAYS LATER. I TOOK THE VEHICLE TO FLETCHER'S TIRE AND AUTO SERVICE IN MARICOPA, AZ ON 3/23/2010. THE SERVICE SHOP (FLETCHER'S) PERFORMED A DIAGNOSTIC CHECK OF THE ABS SYSTEM; DETERMINING THE REPLACEMENT OF THE FRONT LEFT WHEEL HUB ASSEMBLY; COSTING ME $452.36. THIS REPAIR TEMPORARILY CORRECTED THE PROBLEM. ONE MONTH LATER ON 5/26/2010 I BEGIN TO GET THE SAME WARNING LIGHTS AND MESSAGES. SO I TAKE THE VEHICLE BACK TO FLETCHER?S AUTO BECAUSE THEY GUARANTEE THEIR WORK. UNFORTUNATELY THEY WERE UNABLE TO REPRODUCE THE ERROR AND HAD THE SAME FRONT LEFT WHEEL HUB REPLACED UNDER WARRANTY WITH THE PARTS MANUFACTURER AT NO COST TO ME. NOW ONE MONTH LATER I AM HAVING THE SAME ISSUES. SO I START LOOKING ONLINE FOR THIS PROBLEM. THERE ARE MULTIPLE FORUMS AND CHAT ROOM DISCUSSIONS WITH A SUFFICIENT NUMBER OF COMPLAINTS, FOR THE SAME ISSUE, AT SUCH WEB ADDRESSES AS; WWW.ABOUTAUTOMOBILE.COM AND WWW.SATURNFANS.COM NOW WITH THIS INFORMATION I LOOK FOR RECALLS AND FIND NOTHING. SO I CALL SATURN OF TEMPE AND SPEAK TO A GENTLEMAN IN THE SERVICE DEPARTMENT WHO GAVE ME THE NAME MIKE. I EXPLAINED TO HIM THE PROBLEM THAT I WAS HAVING WITH MY VEHICLE. I EXPLAINED TO HIM THAT I HAD TAKEN IT TO A LOCAL MECHANIC (FLETCHER'S) AND HAD THE HUB ASSEMBLY REPLACED TWICE WITH NO RESOLUTION. HE STATED THAT I COULD BRING IT IN FOR HIM TO LOOK AT, BUT THAT THERE WOULD BE A $65 ?DIAGNOSTIC? FEE. I DECLINED EXPLAINING TO HIM THAT I HAD ALREADY INVESTED $450 DOLLARS IN IT AND WOULD RETURN TO THE PREVIOUS MECHANIC. *TR
NHTSA ODI #10340533
45,000 miles · Aug 20, 2009
Traction Control System
ABS SYSTEM WARNING KEEPS LIGHTING UP. WENT TO DEALER AND THEY SAID SENSOR ARE BAD AND WILL $600 TO REPLACE. THERE ARE MULTIPLE REPORTS FROM THE SATURN FORUM REGARDING SAME FAILURES. THIS IS A HAZARD AND THERE NEEDS TO BE A BULLETIN FOR GM TO FIX IT FOR FREE. *TR
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
2005 Saturn Relay Problems, Complaints & Recalls | Skip That Year
Illustration