IllustrationELECTRIC SLIDING DOOR WILL OPEN BY ITSELF ON MY 2005 SATURN RELAY. HAVE TO DISABLE DOOR TO BE SURE IT DOES NOT OPEN WHILE DRIVING, BUT WILL ENABLE ITSELF AND START OPENING BY ITSELF AGAIN. AS SATURN IS OUT OF BUSINESS, DO NOT KNOW WHERE TO TURN. *TR
2005 Saturn Relay
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Relay years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1825–50K
1050–75K
1175–100K
9100–150K
5150K+
79 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Structure complaints
10 reportsPOWER SLIDING DOORS DON'T LATCH PROPERLY. MOTOR WILL KEEP RUNNING ON DOORS & AS YOU ARE DRIVING, IF YOU HIT A BUMP OR MAKE A SHARP TURN, THE CAR DINGS LIKE THE DOOR HAS OPENED. THE ONLY WAY TO STOP THIS IS TO PULL OVER & OPEN & THEN RECLOSE THE DOOR. *TR
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHENEVER THE CONTACT TURNS ON THE VEHICLE REGARDLESS IF IT IS DRIVEN OR NOT THE REAR DRIVER SIDE SLIDING DOOR OPENED ON ITS OWN WITHOUT WARNING. THE DOOR HAS ALSO OPENED AND WAS EXTREMELY DIFFICULT TO CLOSE MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT…
Read full complaint
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHENEVER THE CONTACT TURNS ON THE VEHICLE REGARDLESS IF IT IS DRIVEN OR NOT THE REAR DRIVER SIDE SLIDING DOOR OPENED ON ITS OWN WITHOUT WARNING. THE DOOR HAS ALSO OPENED AND WAS EXTREMELY DIFFICULT TO CLOSE MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE FAILURE COULD NOT BE REPRODUCED. THE VIN WAS NOT AVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 89000.
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING THE REAR SLIDING DOOR OPENED WITHOUT WARNING. HE PULLED OVER AND IT TOOK 10 MINUTES TO CLOSE THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CENSORS AND MOTOR WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED AN IDENTICAL FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEA…
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING THE REAR SLIDING DOOR OPENED WITHOUT WARNING. HE PULLED OVER AND IT TOOK 10 MINUTES TO CLOSE THE DOOR. THE VEHICLE WAS TAKEN TO THE DEALER, AND THE CENSORS AND MOTOR WERE REPLACED. AFTER THE REPAIR HE EXPERIENCED AN IDENTICAL FAILURE. THE VEHICLE WAS TAKEN BACK TO THE DEALER AND REPAIRED AT HIS EXPENSE. NONE ON THE REPAIRS HAVE REMEDIED THE FAILURE. THE FAILURE MILEAGE WAS 30000. THE CURRENT MILEAGE WAS 112107.
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING 35 MPH, THE DOOR ALARM SOUNDS AND INDICATES THAT BOTH REAR PASSENGER DOORS ARE OPEN. THE CONTACT MUST PULL THE VEHICLE OVER AND CLOSE THE DOORS. THE MANUFACTURER STATED THAT THE VEHICLE DID NOT HAVE ANY RECALLS; THEREFORE, SHE WOULD NEED TO PAY FOR A DIAGNOSTIC. THE CONT…
Read full complaint
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING 35 MPH, THE DOOR ALARM SOUNDS AND INDICATES THAT BOTH REAR PASSENGER DOORS ARE OPEN. THE CONTACT MUST PULL THE VEHICLE OVER AND CLOSE THE DOORS. THE MANUFACTURER STATED THAT THE VEHICLE DID NOT HAVE ANY RECALLS; THEREFORE, SHE WOULD NEED TO PAY FOR A DIAGNOSTIC. THE CONTACT WILL TAKE THE VEHICLE TO THE DEALER. THE FAILURE MILEAGE WAS 54,000 AND CURRENT MILEAGE WAS 55,442. UPDATED 02/02/09.*LJ UPDATED 02/03/09. *JB
WE PURCHASE THE VAN MARCH 2006 AS THE FIRST OWNERS. THE ORIGINAL PROBLEM STARTED IN JUNE OF 2007 WHEN THE PASSENGER SIDE POWER SLIDING DOOR WOULD OPEN BACK UP WHEN CLOSING. WE TOOK THE VAN TO THE DEALER AND THEY REPLACED THE DOOR JAM SWITCH. THE MILEAGE AT THE TIME WAS 11,584. FROM THAT TIME TO NOW DEC 2008, WITH 31,000 MILES, T…
Read full complaint
WE PURCHASE THE VAN MARCH 2006 AS THE FIRST OWNERS. THE ORIGINAL PROBLEM STARTED IN JUNE OF 2007 WHEN THE PASSENGER SIDE POWER SLIDING DOOR WOULD OPEN BACK UP WHEN CLOSING. WE TOOK THE VAN TO THE DEALER AND THEY REPLACED THE DOOR JAM SWITCH. THE MILEAGE AT THE TIME WAS 11,584. FROM THAT TIME TO NOW DEC 2008, WITH 31,000 MILES, THE PROBLEM HAS CONTINUED AND ADDING IN THE DRIVER SIDE POWER SLIDING DOOR. THE PROBLEMS RANGED FROM DOORS CLOSING AND GETTING AN ALARM INDICATING THAT THE DOOR(S) WERE OPEN TO HAVING TO PLACE THE DOORS IN MANUAL IN ORDER TO CLOSE THEM AND STILL GETTING THE ALARM AS IF THE DOORS WERE OPEN. AFTER 15 VISITS TO THE DEALER AND ALL INTERNAL AND EXTERNAL PARTS REPLACED, THE PROBLEMS STILL COME BACK. THERE WERE TWO INSTANCES THAT WE FOUND, AFTER THE DOORS WERE REPAIRED, THEY WOULD NOT LOCK. THIS WAS FOUND BY ONE OF OUR CHILDREN OPENING THE DOOR BEFORE IT WAS UNLOCKED AND THE SECURITY SYSTEM SOUNDED. AFTER THE SECOND TIME, THE DEALER INFORMED US THAT IT WOULD NOT LOCK BECAUSE OF THE DOOR COMING OUT OF ALIGNMENT NOT ALLOWING IT TO ENGAGE. THIS MAKES ME WONDER IF THIS HAS HAPPENED BEFORE AND WE WERE NOT AWARE. ALSO THE FACT THAT IF IT DOES NOT LOCK, THEN IT COULD OPEN WHILE THE VEHICLE IS IN MOTION. I HAVE BEEN IN CONTACT WITH SATURN CUSTOMER SERVICE NUMEROUS TIMES WITH OUR CONCERNS TO NO RESOLVE OF THE PROBLEMS. ALL THEY COULD DO IS OFFER MINIMAL COVERAGE THAT DOES NOT CORRECT THE PROBLEMS WITH THE DOORS AND I HAVE NO PEACE OF MIND WHILE TRAVELING IN THE VAN WITH MY FAMILY. I HAVE READ OF NUMEROUS OTHER 2005 SATURN RELAY OWNERS WITH THE SAME PROBLEMS AS WE HAVE. I AM AFRAID THAT IT WILL TAKE A SERIOUS INJURY OR DEATH BEFORE GENERAL MOTORS TAKES THIS PROBLEM SERIOUSLY. THEY OBVIOUSLY KNOW THERE IS A DEFECT/DESIGN PROBLEM DUE TO THE FACT THAT EVEN THE DEALER ACKNOWLEDGES CONTINUOUS REPAIRS TO THIS MODEL OF GM VAN AND A DESIGN CHANGE IN THE 2008 MODELS OF GM VANS WITH POWER SLIDING DOORS. *TR
RIGHT SIDE AUTOMATIC SLIDING DOOR WILL NOT STAY SHUT. THE DOOR HAS NEVER OPENED DURING DRIVING, BUT WE HAD TO SHUT THE DOOR PROBABLY 6 TIMES BEFORE IT WOULD FINALLY STAY CLOSE. THIS HAS HAPPENED AT LEAST 3 OR 4 TIMES. *TR
FAILURE OF SLIDING SIDE DOOR TO LOCK FAILURE OF WINDSHIELD WIPERS FAILURE OF REAR BRAKES. *TR
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING BETWEEN 5-45 MPH, THE CONTACT HEARD A BEEPING NOISE. THE NOISE INDICATED THAT THE PASSENGER SIDE DOOR WAS OPEN, HOWEVER, THE DOOR WAS CLOSED. SHE HAD TO OPEN AND CLOSE THE DOOR FOR THE BEEPING NOISE TO STOP. THE DEALER STATED THAT THEY CLEANED THE DOOR PINS. APPROXIMATE…
Read full complaint
TL*THE CONTACT OWNS A 2005 SATURN RELAY. WHILE DRIVING BETWEEN 5-45 MPH, THE CONTACT HEARD A BEEPING NOISE. THE NOISE INDICATED THAT THE PASSENGER SIDE DOOR WAS OPEN, HOWEVER, THE DOOR WAS CLOSED. SHE HAD TO OPEN AND CLOSE THE DOOR FOR THE BEEPING NOISE TO STOP. THE DEALER STATED THAT THEY CLEANED THE DOOR PINS. APPROXIMATELY A YEAR AND A HALF LATER, THE FAILURE RECURRED. THE DEALER STATED THAT THEY CHANGED THE HARD SIDE TRIM. APPROXIMATELY SIX MONTHS LATER, THE FAILURE RECURRED FOR THE THIRD TIME. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CURRENT MILEAGE IS 12,500 AND FAILURE MILEAGE WAS 5,000.
SATURN RELAY STARTED LEAKING WATER A MONTH AFTER PURCHASE. TOOK IN FOR REPAIR SEVERAL TIMES, FILED FOR LEMON LAW, SATURN HAD THEIR FINAL ATTEMPT TO FIX THE PROBLEM AND FAILED. I WAS TOLD BY THE CORP OFFICE TO TAKE CAR BACK IN SO THEY COULD VERIFY THAT IT WAS STILL LEAKING, DID THAT AND THEY DID IN FACT VERIFY IN WRITING THAT I…
Read full complaint
SATURN RELAY STARTED LEAKING WATER A MONTH AFTER PURCHASE. TOOK IN FOR REPAIR SEVERAL TIMES, FILED FOR LEMON LAW, SATURN HAD THEIR FINAL ATTEMPT TO FIX THE PROBLEM AND FAILED. I WAS TOLD BY THE CORP OFFICE TO TAKE CAR BACK IN SO THEY COULD VERIFY THAT IT WAS STILL LEAKING, DID THAT AND THEY DID IN FACT VERIFY IN WRITING THAT IT WAS LEAKING, SATURN REFUSES TO ABIDE BY THE LAW AND GIVE ME A REFUND OR NEW VEHICLE, IN FACT THEY WOULDN'T GIVE ME ANY OPTION OTHER THAN TAKE IT TO BE FIXED. AGAIN??? GOT MYSELF AN ATTORNEY!!! *JB
Official recalls
205V287000 · Parking Brake
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
05V061000 · Seats:mid/rear Assembly
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.