IllustrationDT*: THE CONTACT STATED THE EXTERIOR AND INTERIOR LIGHTS BECAME DIM AND BRIGHTENED WHILE DRIVING. THE PROBLEM WORSENED WHILE THE CRUISE CONTROL WAS ON. THE DEALERSHIP WAS MADE AWARE OF THE PROBLEM, BUT THERE WERE NO REPAIRS PERFORMED.
2005 Saturn Relay
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Relay years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
260–25K
1825–50K
1050–75K
1175–100K
9100–150K
5150K+
79 reports with mileage · 12 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports1 injury reports
Interior Lighting complaints
2 reportsDT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM.…
Read full complaint
DT: THE CONTACT STATES THERE WAS AN ONGOING PROBLEM WITH EXTERIOR AND INTERIOR LIGHTING. WHILE DRIVING, THE HEADLIGHTS AND THE DASHBOARD PANEL LIGHTS FLICKERED FROM BRIGHT TO DIM. ALSO, THE IDLE WAS VERY LOUD AND ROUGH. SHE TOOK THE VEHICLE TO THE DEALER. THE DEALER REPLACED THE ALTERNATOR. THIS DID NOT CORRECT THE PROBLEM. THE DEALER WAS UNABLE TO ACCURATELY DIAGNOSE THE PROBLEM, AND NO FURTHER REPAIRS WERE MADE. *AK UPDATED 12/27/2005. THE HORN SPRINGS WERE DEFORM WHICH RESULTED IN THE HORN BEING INOPERATIVE. THE SLIDING DOOR WOULD CHIME AS IF THE DOOR WAS NOT CLOSED. THE TECH ADJUSTED THE TOP MIDDLE AND BOTTOM LATCHES. THE BRAKES PULSATED WHEN BRAKING. THE TECHNICIAN HAD TO RESURFACE BOTH FRONT ROTORS. *NM
Official recalls
205V287000 · Parking Brake
Jun 20, 2005
CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 135, 'PASSENGER CAR BRAKE SYSTEMS.' TO MEET THE STANDARD, THE VEHICLE MUST NOT MOVE FOR FIVE MINUTES WHEN STOPPED ON A STEEP HILL WITH THE PARKING BRAKE APPLIED AND THE VEHICLE IN NEUTRAL (N). SOME OF THESE VEHICLES FAILED THIS TEST.
Consequence & remedy
Consequence: WHEN THE PARKING BRAKE IS RELEASED, THE DRIVER MAY NOTICE UNINTENDED BRAKING WHEN ACCELERATING, DECELERATING, OR COASTING, AND A NOISE COMING FROM THE REAR OF THE VEHICLE. UNINTENDED VEHICLE MOVEMENT COULD OCCUR INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT FOR PARKING BRAKE LEVER SLIPPAGE AT EACH REAR BRAKE CALIPER AND REPLACE THE CALIPER IF LEVER SLIPPAGE IS IDENTIFIED. THE RECALL BEGAN ON NOVEMBER 14, 2005. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, PONTIAC AT 1-800-620-7668, OR SATURN AT 1-800-972-8876.
05V061000 · Seats:mid/rear Assembly
Feb 18, 2005
ON CERTAIN MINIVANS, THE OUTBOARD RELEASE HANDLE ON THE IMPACT-SIDE SECOND-ROW BUCKET SEAT MAY BE ACTUATED AND THE REAR LATCHES MAY UNLATCH EARLY IN A SIDE IMPACT CRASH. THIS WAS DISCOVERED IN A SIDE IMPACT TEST RUN BY GM, UNDER CONDITIONS SIMILAR TO NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) SIDE IMPACT TEST.
Consequence & remedy
Consequence: IF THE REAR LATCHES OF THE SEAT RELEASE EARLY IN A SEVERE SIDE IMPACT, THE FRONT OUTBOARD LATCH MAY DISENGAGE AND INCREASE THE POTENTIAL FOR INJURY TO THE OCCUPANT OF THE SEAT.
Remedy: DEALERS WILL REMOVE THE SEAT LATCH RELEASE HANDLE AND INSTALL A BLACK PLASTIC CAP OVER THE EXPOSED METAL STUD TO ELIMINATE THE SIDE IMPACT SAFETY CONCERN FREE OF CHARGE. THE RECALL BEGAN ON APRIL 5, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876, CHEVROLET AT 1-800-630-2438, AND PONTIAC AT 1-800-620-7668.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.