NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
24 reportsClear category filter91,652 miles · Mar 7, 2014
Electrical System
TL* THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE ENGINE STALLED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS SHUT OFF AND ONCE RESTARTED, RESUMED NORMALLY FOR A HALF A MILE BEFORE THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE IGNITION SWITCH WAS REPLACED BUT TO NO AVAIL. …
Read full complaint
TL* THE CONTACT OWNS A 2005 SATURN RELAY. THE CONTACT STATED THAT THE ENGINE STALLED AND THE STEERING WHEEL SEIZED. THE VEHICLE WAS SHUT OFF AND ONCE RESTARTED, RESUMED NORMALLY FOR A HALF A MILE BEFORE THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE IGNITION SWITCH WAS REPLACED BUT TO NO AVAIL. THE FAILURE WAS RECURRING. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THE CONNECTOR HARNESS TO THE FUEL PUMP WAS REWIRED AND REPLACED. THE CONTACT INDICATED THAT THE FAILURE RECURRED AFTER THE SECOND REPAIR. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 91,652.
NHTSA ODI #10567799
80,000 miles · Dec 18, 2012
Electrical SystemExterior LightingService Brakes
ABS WARNING LIGHT APPEARS INTERMITTENTLY EVEN AFTER BRAKES WERE REPLACED. SEEMS TO BE ELECTRICAL ISSUE AS OPENING THE DOOR DOESN'T ALWAYS TURN ON LIGHT OR TURN OFF RADIO. DRAINED BATTERY. NOW I HAVE TO PULL FUSE. STEERING WHEEL RADIO CONTROLS HAVE NEVER WORKED PROPERLY OFTEN PERFORMING OPPOSITE FUNCTIONS. *TR
NHTSA ODI #10489110
86,000 miles · Jan 13, 2012
Electrical SystemElectronic Stability Control (esc)Service Brakes, Hydraulic
12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT …
Read full complaint
12/19/2011 WIFE WAS DRIVING CAR ON 4 LANE HIGHWAY WHEN BRAKES ENGAGED FOR NO REASON. FOOT WAS NOT EVEN ON THE PEDAL. VAN LURCHED, TIRES SQUEALED, DRASTICALLY REDUCED SPEED DOWN TO 20 MPH, AND CAR PULLED TO THE RIGHT. SHE PULLED OFF ONTO SHOULDER OF ROAD. T/C LIGHT CAME ON. VAN DROVE NORMALLY AFTER THAT UNTIL 1/5/12 WHEN IT HAPPENED AGAIN. THIS TIME IT HAPPENED AT A LOWER SPEED, WHILE SLOWING TO TURN LEFT THROUGH AN INTERSECTION. MADE CAR SKID AND SHE ALMOST MISSED THE TURN. IT HAPPENED AGAIN ON 1/6/11 WHILE TURNING INTO A PARKING LOT. SAME SYMPTOMS, THIS TIME CAR PULLED TO LEFT. I INSPECTED VEHICLE TO FIND THAT RIGHT REAR BRAKE CALIPER WAS LEAKING BRAKE FLUID. THOUGHT THAT WOULD SOLVE PROBLEM, HOWEVER, IT WAS AN UNRELATED ISSUE. HAPPENED 5 TIMES ON 1/10/11, ONCE AGAIN ON 1/11/11 AT 60 MPH, AND ON 1/12/11 AT A LOWER SPEED. DIAGNOSIS BY A GM CERTIFIED MECHANIC DETERMINED THE PROBLEM TO BE THE EBCM. CURRENTLY THE FUSE HAS BEEN REMOVED FROM THE ABS AND ABS PUMP TO PREVENT THIS VERY DANGEROUS CONDITION FROM HAPPENING AGAIN. SWITCH IN CAR TO DEACTIVATE TRACTION CONTROL WAS NOT STOPPING IT FROM MALFUNCTIONING. MY WIFE AND KIDS USE THIS CAR, AND I WAS VERY WORRIED ABOUT THEIR SAFETY, AND I HAD TO CONSULT 3-4 DIFFERENT MECHANICS TO BRAINSTORM AND FIGURE OUT WHAT WAS CAUSING THIS PROBLEM. *TR
NHTSA ODI #10443718
111,934 miles · Mar 21, 2011
Electrical SystemEngine And Engine CoolingTraction Control System
I HAVE A PROBLEM WITH THE ABS/TRACTION CONTROL LIGHT COMING ON AND THE BRAKING SYSTEM WILL NOT OPERERATE PROPERLY. THERE HAS BEEN A FEW TIMES WHERE THE BRAKES WILL NOT STOP THE VEHICLE PROPERLY OR HAVE LOCKED UP A COUPLE OF TIMES. WE ALSO HAD TO REPLACE THE EGR VALVE DO TO A CODE 0414/0414. WE ALSO HAD TO REPLACE THE PCM BECAUSE…
Read full complaint
I HAVE A PROBLEM WITH THE ABS/TRACTION CONTROL LIGHT COMING ON AND THE BRAKING SYSTEM WILL NOT OPERERATE PROPERLY. THERE HAS BEEN A FEW TIMES WHERE THE BRAKES WILL NOT STOP THE VEHICLE PROPERLY OR HAVE LOCKED UP A COUPLE OF TIMES. WE ALSO HAD TO REPLACE THE EGR VALVE DO TO A CODE 0414/0414. WE ALSO HAD TO REPLACE THE PCM BECAUSE THE SYSTEM LOCKED UP AND DELETED ALL THE CODES CAUSING THE ENGINE TO FAIL TO START WHILE TRING TO UPDATE THE PCM TO RECOGNIZE THE NEW EGR. I ALSO HAVE PROPLEMS WITH THE LIGHTS FLICKERING AND DIMMING ALL THE TIME. THESE PROBLEMS EXIST EVERY DAY AND I FEEL THE VEHICLE IS GETTING UNSAFE TO DRIVE. I HAVE CONTACTED GM SEVERAL TIMES AND TOOK THE VEHICLE TO A LOCAL DEALERSHIP TO GET THE PCM REPLACED. THEY WOULD NOT GIVE ME THE OLD PCM BUT I HAVE THE ORIGINAL DELPHI EGR VALVE. GM SAID THTHAT THE 2005 RELAY HAS RECALLS ON THE EGR AND PCM BUT MY VIN WAS NOT AFFECTED AND REFUSED TO PAY ANY ON THE REPAIRS OR PAY TO HAVE THE VAN CHECKED OUT AT A GM DEALERSHIP. *TR
NHTSA ODI #10392413
148,000 miles · Nov 19, 2010
Electrical SystemService Brakes, HydraulicTraction Control System
I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DR…
Read full complaint
I BOUGHT A USED 2005 SATURN RELAY 3 IN JANUARY 2010. I HAVE 2 MAJOR ISSUES GOING ON: POWER SLIDING DOORS WILL NOT RECOGNIZE THAT THEY ARE CLOSED AND WILL CONTINUE TO DING AS IF I WAS DRIVING WITH THEM OPEN...ON A FEW OCCASIONS I HAVE HEARD THE POWER DOOR MOTOR START ON ITS OWN AS IF IT WAS TRYING TO OPEN THE DOORS WHILE I AM DRIVING! SECOND ISSUE IS ABS/TRACTION CONTROL LIGHTS HAVE BEEN COMING ON SPORADICALLY SINCE I PURCHASED IT. OF COURSE, NO ONE CAN FIND THE PROBLEM BECAUSE THEY CAN'T REPLICATE IT. IT DOESN'T MATTER THE DRIVING CONDITIONS, DRIVING TIME, WEATHER OR ANYTHING ELSE. BOTH HAVE HAPPENED AT VARIOUS SPEEDS. CURRENTLY THE LIGHTS ARE STAYING ON MORE THAN OFF AND YESTERDAY WHILE DRIVING, THE WARNING LIGHTS WERE OFF UNTIL I STEPPED ON THE BRAKES, FELT AND HEARD A CLUNKING SOUND, THE BRAKE PETAL GAVE WAY SOME, AND THE SERVICE ABS/NO TRACTION CONTROL LIGHTS CAME BACK ON AGAIN. THE CAR DID STOP. TALKED TO THE USED CAR DEALERSHIP THAT SOLD IT TO ME AND I AM CURRENTLY MAKING ARRANGEMENTS TO HAVE VEHICLE LOOKED AT. IN RESEARCHING I HAVE FOUND NUMEROUS COMPLAINTS ABOUT THESE SAME ISSUES ON A NUMBER OF FORUMS. *TR
NHTSA ODI #10366814
38,752 miles · Jan 12, 2009
Electrical System
1. CHIMING SOUND ALL THE TIME AS IF THE SLIDING DOORS ARE OPEN. DOOR OPENED ON ITS OWN WILLING DRIVING. THEY REPLACED THE MOTORS. 2. SAME PROBLEM AS ABOVE. REPLACED THE SENSORS 3. HAVING THE SAME PROBLEM AGAIN. *TR
NHTSA ODI #10254744
1,000 miles · Dec 6, 2006
Electrical SystemService Brakes, Hydraulic
2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUT…
Read full complaint
2005 SATURN RELAY HAS NUMEROUS DESIGN FLAWS, AND SATURN IS UNABLE TO FIX. ONSTAR DISABLES SPEEDOMETER WHEN USED, RADIO MUTES AND CAR MUST BE TURNED OFF AND BACK ON TO RESET, ABS SYSTEM MALFUNCTIONS REPEATEDLY EVEN AFTER REPLACING EBCM, ABS PUMP, BCM, LIGHTS FLICKER BOTH INTERIOR AND EXTERIOR, ALTERNATOR FOUND TO HAVE ERRATIC OUTPUT, NEW ALTERNATOR DID NOT SOLVE PROBLEM. BRAKE ROTORS WARPED WITHIN 25K MILES. SATURN WILL ONLY KEEPING TRYING TO REPAIR, BUT IS UNABLE TO SOLVE PROBLEMS. *NM
NHTSA ODI #10175424
3,000 miles · Oct 26, 2006
Electrical System
SATURN RELAY 2005: AFTER TURNING THE CAR ON, NO SOUND COMES FROM THE RADIO, OR CD. THE NO SOUND DISABLES THE ON-STAR FUNCTION AND REAR PARKING SENSOR. THUS I CAN NOT CALL ON STAR OR HEAR THE CHIMES FROM THE REAR PARKING SENSOR. THIS ISSUE IS NOT A REPEATABLE EVENT. I HAVE NOT FOUND A WAY TO DUPLICATE THE EVENT. I HAVE DETER…
Read full complaint
SATURN RELAY 2005: AFTER TURNING THE CAR ON, NO SOUND COMES FROM THE RADIO, OR CD. THE NO SOUND DISABLES THE ON-STAR FUNCTION AND REAR PARKING SENSOR. THUS I CAN NOT CALL ON STAR OR HEAR THE CHIMES FROM THE REAR PARKING SENSOR. THIS ISSUE IS NOT A REPEATABLE EVENT. I HAVE NOT FOUND A WAY TO DUPLICATE THE EVENT. I HAVE DETERMINED THAT IF I SHUT OFF THE CAR AND OPEN THE DOOR AND WAIT AT LEAST ONE MINUTE, THE SOUND WILL RESET AND WORK FINE. EVERY 3 MONTHS WHEN I TAKE THE CAR BACK FOR OIL CHANGE I IDENTIFY THE PROBLEM, BUT SINCE IT CAN NOT BE DUPLICATED THE DEALER WILL NOT INVESTIGATE OR ATTEMPT TO REPAIR. THE CONCERN IS THE NON-FUNCTIONING OF ON-STAR AND REAR PARKING SENSORS. THIS ARE SAFETY FEATURES THAT CAN NOT BE USED IF REQUIRED IN AN EMERGENCY AND THE SOUND IS NOT WORKING. *NM
NHTSA ODI #10171914
12,000 miles · Jan 27, 2006
Electrical SystemEngine And Engine Cooling
THERE IS A DEFINITE PROBLEM WITH EITHER THE ENGINE OR THE ELECTRICAL SYSTEM ON THE 2005 SATURN RELAY. WE HAVE BEEN TO DEALERSHIPS AND COMPLAINED ABOUT THESE PROBLEMS, BUT THEY HAVE BRUSHED US OFF BY SAYING THAT IT COULD BE THE WEATHER, AND THEY DID NOT SEE ANY PROBLEM. THE CAR ACTUALLY GOES DOWN IN RPMS AND THE WHOLE DASHBOAR…
Read full complaint
THERE IS A DEFINITE PROBLEM WITH EITHER THE ENGINE OR THE ELECTRICAL SYSTEM ON THE 2005 SATURN RELAY. WE HAVE BEEN TO DEALERSHIPS AND COMPLAINED ABOUT THESE PROBLEMS, BUT THEY HAVE BRUSHED US OFF BY SAYING THAT IT COULD BE THE WEATHER, AND THEY DID NOT SEE ANY PROBLEM. THE CAR ACTUALLY GOES DOWN IN RPMS AND THE WHOLE DASHBOARD AND LIGHTS DIM WHEN IN IDLE. ALSO, THE IDLE IS VERY ROUGH. THIS SHOULD BE LOOKED AT SINCE AFTER DOING SOME RESEARCH ON SOME WEB SITES THERE ARE MANY PEOPLE WITH THE SAME EXACT PROBLEM WITH THIS VEHICLE AND THEY ARE ALSO BEEN GIVEN MANY DIFFERENT ANSWERS. P PLEASE INVESTIGATE THIS SINCE WE HAVE A ONE YEAR OLD AND I DO NOT WANT ANYTHING TO HAPPEN TO HER WHILE WE ARE USING THIS MINIVAN. THANK YOU. *AK
NHTSA ODI #10148828
1,000 miles · Jan 21, 2006
Electrical System
LIGHTS ON DASH AND EXTERIOR DIM AND FADE ERRATICALLY. RADIO DECIDES TO MUTE ITSELF IF CAR IS UNLOCKED AND TAIL GATE IS OPENED FIRST. THEY DON'T KNOW THE MILEAGE FOR OIL CHANGES. HAS A HESITATION FROM ROLLING START THAT MAKES THE WHEELS BREAK FREE AS IF A TURBO. SATURN DEALER CAN NOT "SEE" ANY OF THIS EVEN WHEN SHOWN. ALSO TH…
Read full complaint
LIGHTS ON DASH AND EXTERIOR DIM AND FADE ERRATICALLY. RADIO DECIDES TO MUTE ITSELF IF CAR IS UNLOCKED AND TAIL GATE IS OPENED FIRST. THEY DON'T KNOW THE MILEAGE FOR OIL CHANGES. HAS A HESITATION FROM ROLLING START THAT MAKES THE WHEELS BREAK FREE AS IF A TURBO. SATURN DEALER CAN NOT "SEE" ANY OF THIS EVEN WHEN SHOWN. ALSO THEY SAY I MUST CONTACT SATURN TO FIND OUT HOW TO FIX. SATURN IS NOT RETURNING MY CALLS. *JB
NHTSA ODI #10148283
NHTSA investigations
3EA07019 · Power Sliding Door
Opened Dec 11, 2007 · Closed Feb 23, 2009
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
Structure:body:door:hinge And Attachments
ODI EVALUATED GENERAL MOTORS' (GM) DATA, CONDUCTED CONSUMER INTERVIEWS, INSPECTED AND TESTED MY 2005-2007 GM MINIVANS WITH REGARD TO THE ALLEGED DEFECT OF A POWER SLIDING DOOR (PSD) OPENING WHILE THE VEHICLE IS OUT OF PARK.ODI IDENTIFIED A HIGH WARRANTY CLAIM RATE.HOWEVER, THESE CLAIMS ARE RELATED TO VARIOUS PROBLEMS ASSOCIATED WITH DOORS NOT PROPERLY OPENING OR CLOSING AND NOT SPECIFICALLY TO DOORS OPENING WHILE DRIVING.THE CONDITION OF THE PSD REVERSING DIRECTION DURING THE CLOSING SEQUENCE IS CONSISTENT WITH AN OBSTRUCTION OF THE DOOR, OR WITH IMPROPER ALIGNMENT OF THE DOOR, AND THIS IS ADDRESSED IN GM TECHNICAL SERVICE BULLETIN # 07-08-64-007 AND BULLETINS # 07-08-64-007A THROUGH D.ODI'S EVALUATION OF THE PSD SYSTEM NOTES NUMEROUS SAFEGUARDS TO PRECLUDE BOTH UNINTENTIONAL AND INTENTIONAL POWER OPENING OF THE PSD WHILE THE VEHICLE IS IN MOTION.A SAFETY-DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.[SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.]
PE07044 · Power Sliding Door Opening
Opened Aug 16, 2007 · Closed Dec 11, 2007
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door ; Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Additional source detail variants (3)
Latches/locks/linkages:doors:latch
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
Structure:body:door:hinge And Attachments
ODI HAS RECEIVED REPORTS THAT THE POWER SLIDING DOORS OPENED WITHOUT COMMAND WHILE THE VEHICLE WAS IN MOTION ON MODEL YEAR 2005 AND 2006 GENERAL MOTORS MINIVANS (CHEVROLET UPLANDER/VENTURE, PONTIAC MONTANA SV6/MONTANA, BUICK TERRAZA, AND SATURN RELAY).SOME REPORTS INDICATE THAT THE DOOR MAY NOT HAVE BEEN CLOSED AND LATCHED BEFORE DRIVING AWAY CAUSING THE DOOR TO REVERSE (OPEN) AT LOW VEHICLE SPEEDS.HOWEVER, OTHER REPORTS INDICATE THAT THE DOOR WAS INITIALLY SHUT THEN OPENED AFTER DRIVING FOR SEVERAL MINUTES AND/OR MILES AT VEHICLE SPEEDS BETWEEN 20 AND 70 MPH.ODI HAS UPGRADED THIS PRELIMINARY EVALUATION TO AN ENGINEERING ANALYSIS (EA07-019) TO FURTHER ASSESS THIS ISSUE.
PE05063 · Electrical Harness Damage
Opened Nov 29, 2005 · Closed Mar 6, 2006
Status: closed (inferred from source dates) · Electrical System; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (3)
Electrical System
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:front Underhood
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Electrical System:wiring:fuses And Circuit Breakers
THE OFFICE OF DEFECTS INVESTIGATION OPENED THIS INVESTIGATION ON NOVEMBER 29, 2005, BASED ON ONE CONSUMER REPORT TO ODI AND A TECHNICAL SERVICE BULLETIN ISSUED BY GENERAL MOTORS.THE BULLETIN, NO. 1613174, ISSUED ON FEBRUARY 21, 2005, STATES IN PART, SOME CUSTOMERS MAY REPORT A STALL AND/OR NO CRANK, NO START CONDITION AFTER THE WIPERS ARE USED.ANALYSIS OF THE AVAILABLE DATA INDICATES THAT THE PROBLEM EXPERIENCE OCCURS EARLY IN THE LIFE OF THE VEHICLE.APPROXIMATELY 80% OF ALL FAILURES OCCURRED WITHIN THE FIRST 3,000 MILES.ADDITIONALLY, 88% OF THE COMPLAINT VEHICLES WERE BUILT IN THE FIRST HALF OF PRODUCTION.CHANGES TO THE PRODUCTION PROCESS, THE ISSUANCE OF THE SERVICE BULLETIN, AND COMPONENT MODIFICATIONS, APPEAR TO HAVE RESOLVED THIS ISSUE. A SAFETY RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Illustration