TL* THE CONTACT OWNS A 1995 SAAB 900S. THE CONTACT HEARD AN ABNORMAL NOISE FROM THE SEAT BELT AND IMMEDIATELY, THE SEAT BELT FAILED TO RESTRAIN THE CONTACT. THE DEALER ADVISED THAT THE SEAT BELT RETRACTOR ASSEMBLY HAD FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAIL…
Read full complaint
TL* THE CONTACT OWNS A 1995 SAAB 900S. THE CONTACT HEARD AN ABNORMAL NOISE FROM THE SEAT BELT AND IMMEDIATELY, THE SEAT BELT FAILED TO RESTRAIN THE CONTACT. THE DEALER ADVISED THAT THE SEAT BELT RETRACTOR ASSEMBLY HAD FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 160,785 AND THE CURRENT MILEAGE WAS 161,292. UPDATED 11/03/10 *BF UPDATED 11/04/10*JB
NHTSA ODI #10347824
92,128 miles · Sep 2, 2003
Air BagsSeat Belts
WHILE DRIVING 10 MPH THE VEHICLES PASSENGERS AIR BAG DEPLOYED INADVERTENTLY. THE DRIVER EXITED THE VEHICLE TO LET THE SMOKE CLEAR. WHEN THE CONSUMER GOT BACK INTO THE VEHICLE AND DROVE ABOUT 40 YARDS THE DRIVERS AIR BAG DEPLOYED. THE SEAT BELTS ALSO LOCKED . *AK *NLM
NHTSA ODI #10031240
Mileage unknown · Mar 9, 2001
Seat Belts
WHILE TRYING TO PUT SEAT BELT ON, SEAT BELT WOULD NOT EXTEND. BELTS NEEDED TO BE REPLACED. *AK DEALER REPLACED BELT AND RETRACTOR. *SLC
NHTSA ODI #882601
Mileage unknown · Aug 6, 1997
Seat Belts
THE DEFECTIVE DRIVER'S SEATBELT ANCHORAGE FELL APART, CAUSING THE SEATBELT TO BE INOPERATIVE AND WON'T PROTECT THE OCCUPANT IN EVENT OF AN ACCIDENT. NO PRIOR PROBLEM WITH THE SEATBELTS. DEALER CANNOT DETERMINE THE PROBLEM. CAUSE UNKNOWN. *AK
NHTSA ODI #826346
Mileage unknown · Dec 4, 1996
Seat Belts
SEAT BELTS PINS DRIVER TO THE SEAT AT VERY SLIGHT BRAKING OR MILD INCLINES, CAUSING POOR VISIBILITY AND MOVEMENT SKILLS.
NHTSA ODI #512153
Mileage unknown · Oct 4, 1996
Seat Belts
SEAT BELT FASTENS TOO TIGHT, PREVENTING FREE MOVEMENT OF DRIVER.
NHTSA ODI #509492
Mileage unknown · Oct 18, 1995
Seat Belts
LAP/SHOULDER BELT WILL NOT RETRACT ON THE FRONT PASSENGER SIDE. TT
NHTSA ODI #973563
Mileage unknown · Feb 7, 1995
Seat Belts
DRIVER'S SEAT BELT LOCKS UP/CATCHES WHEN TRYING TO TURN OR MOVE, PREVENTING EASY MOVEMENT WHEN DRIVING. *SKD
ON CERTAIN PASSENGER VEHICLES, THE AIR BAG ELECTRONIC CONTROL UNIT (ECU) IS DESIGNED TO SENSE AND DISCRIMINATE FRONTAL IMPACT EVENTS, COMMAND AIR BAG AND SEAT BELT PRETENSIONER DEPLOYMENTS IN A TIMELY MANNER, AND PERFORM CONTINUOUS DIAGNOSTICS OF THE AIR BAG SYSTEM IN THE VEHICLE. DUE TO THE POSSIBLE INSUFFICIENT SEALING OF THE BOTTOM OF AN ELECTROLYTE CAPACITOR, IT IS POSSIBLE FOR IT TO LEAK ELECTROLYTE WITHIN THE AIR BAG ECU. ALSO, IN HIGH HUMIDITY ENVIRONMENTS, THE OPERATION OF THE VEHICLE AIR CONDITIONER CAN CAUSE RAPID COOLING OF THE ECU, WHICH IN TURN MAY CAUSE THE FORMATION OF CONDENSATION WITH THE UNIT.
Consequence & remedy
Consequence: IF THIS MOISTURE COMES INTO CONTACT WITH THE ELECTROLYTE FROM THE CAPACITOR, IT FORMS A HIGHLY CONDUCTIVE MATERIAL THAT COULD CREATE AN ELECTRICAL SHORT CIRCUIT. THIS ELECTRICAL SHORT COULD TRIGGER THE AIR BAGS AND SEAT BELT PRETENSIONERS.
Remedy: DEALERS WILL INSTALL A NEW AIR BAG ECU. OWNER NOTIFICATION BEGAN APRIL 4, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAAB AT 1-800-955-9007.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE INSTRUCTIONS FOR PROPERLY AIMING THE HEADLIGHTING SYSTEM WERE OMITTED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.
Remedy: OWNERS WILL BE SENT AIMING INSTRUCTIONS, AND DIRECTIONS FOR AFFIXING THESE INSERTS TO THE OWNER GUIDES. IF AN OWNER SO DESIRES, A DEALER CAN AFFIX THE INSERTS IN THEIR OWNER GUIDE FOR THEM.
CORROSION AROUND THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING CAN CAUSE THE THROTTLE LEVER TO BIND.
Consequence & remedy
Consequence: THIS BINDING CAN RESULT IN THE THROTTLE PLATE NOT RETURNING TO THE CLOSED POSITION WHEN THE THROTTLE PEDAL IS RELEASED AND A SUBSEQUENT LOSS OF THROTTLE CONTROL.
Remedy: DEALERS WILL REPLACE THE ZINC-COATED THROTTLE CONTROL LEVER BUSHING WITH A NICKEL-COATED BUSHING AND BOLT.
THE STEERING COLUMN SHAFT WAS INCORRECTLY INSTALLED IN THE VEHICLE CAUSING THE COLUMN TO BE OUT OF ALIGNMENT.
Consequence & remedy
Consequence: IF MISALIGNED, AN ALUMINUM CONNECTING PIECE CAN FAIL DUE TO FATIGUE, RESULTING IN A LOSS OF STEERING CONTROL AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN ALIGNMENT TO ENSURE THAT NO MISALIGNMENT EXISTS. IF A MISALIGNMENT IS FOUND, THE DEALER WILL REPLACE THE STEERING COLUMN ASSEMBLY AS A UNIT.
UPON STARTUP, A VOLTAGE DROP TO THE ENGINE CONTROL MODULE CAN CAUSE A MALFUNCTION WHERE ENGINE SPEED FLUCTUATES FROM 600 TO 3,000 RPM FOR UP TO 30 SECONDS BEFORE NORMAL ENGINE IDLE OF 900 RPM.
Consequence & remedy
Consequence: UNEXPECTED MOVEMENT OF THE VEHICLE MAY CAUSE THE DRIVER TO LOSE CONTROL AND INCREASE THE POTENTIAL OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL INSTALL A NEW REVISED ELECTRONIC CONTROL MODULE.
IT IS POSSIBLE TO MOVE THE SHIFT LEVER INTO THE REVERSE GEAR POSITION, REMOVE THE IGNITION KEY, AND STILL HAVE THE TRANSMISSION IN NEUTRAL, OR, TO ACCIDENTLY DISENGAGE REVERSE BY STRIKING THE GEAR LEVER.
Consequence & remedy
Consequence: IF THE PARKING BRAKE IS NOT APPLIED, THE CAR CAN ROLL FROM ITS ORIGINAL PARKED POSITION INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE TRANSMISSION LINKAGE COMPONENTS AND COMPLETE A SPECIALLY DEVELOPED SERVICE ADJUSTMENT PROCEDURE THAT WILL ENSURE THAT WHEN THE SHIFT IS MOVED TO THE REVERSE POSITION, THE REVERSE GEAR IS ACTUALLY ENGAGED.
ONE OR MORE OF THE ARC WELDS CAN BE MISSING ON THE SEAT BACK FRAME RECLINER.
Consequence & remedy
Consequence: THIS CAN RESULT IN A SEAT BACK FALLING BACKWARDS UNDER A LOAD.
Remedy: BOTH FRONT SEAT BACKS WILL BE INSPECTED WITH THE USE OF A HOOK TO PULL BACK THE SEAT BACK UPHOLSTERY. FOR ANY SEAT WITH MISSING WELDS, THE SEAT BACK FRAME/RECLINER WILL BE REPLACED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
DP00008 · Defective Water Pump Pulley
Opened Sep 25, 2000 · Closed Nov 19, 2001
Status: closed (inferred from source dates) · Engine And Engine Cooling
a
SQ98018 · New Wheel Bolts
Opened Oct 9, 1998 · Closed Oct 27, 1998
Status: closed (inferred from source dates) · Wheels
saab issued a tsb informing dealers about a new wheel mounting bolt.If the issue is loosening of the lug nut, this could lead to bolt fatigue and the potential for a wheel separation.
1995 Saab 900 Problems, Complaints & Recalls | Skip That Year
Illustration