Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 5 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
5 reports
28,084 miles · Jul 25, 2012
Electrical System
BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO COAST TO A STOP AS THERE WAS NOT…
Read full complaint
BATTERY DISCONNECT FAILED WHILE DRIVING OUR 20,200 POUND RV AT HIGHWAY SPEED. THE FAILURE RESULTED IN TOTAL LOSS OF CHASSIS POWER (ENGINE STOPPED, POWER STEERING CEASED, POWER STEERING CEASED, ALL DASH INDICATORS NON-OPERATIONAL, EMERGENCY FLASHER NON-OPERATIONAL, ETC.). THE FAILURE CAUSED US TO COAST TO A STOP AS THERE WAS NOTHING ELSE WE COULD DO. THE FAILED PART WAS LATER IDENTIFIED AS: BATTERY DISCONNECT SOLENOID (INTELLITEC 01-00055-002 04098 BCC RELAY (PRINTED ON STICKER PLACED ON TOP PORTION OF UNIT), 612-12V 797 (PRINTED ON BOTTOM OF UNIT). THE BATTERY DISCONNECT SERVICE MANUAL, P/N 53-00066-100, REV B, 030905 FAILS TO LIST TOTAL LOSS OF POWER WHILE IN MOTION AS A POTENTIAL PROBLEM. *TR
NHTSA ODI #10467600
Mileage unknown · Sep 19, 2000
Service Brakes, Hydraulic
ANTI-LOCK BRAKING SYSTEM HAS CAUGHT OVERHEATED AND LOCKED UP A COUPLE OF TIMES. MASTER CYLINDER WAS REPLACED, BUT DID NOT STOP THE PROBLEMS. DEALER HAS BEEN CONTACTED. *AK
NHTSA ODI #870845
Mileage unknown · Jun 7, 2000
Power Train
DRIVESHAFT FAILED. *SLC
NHTSA ODI #784127
Mileage unknown · Feb 8, 2000
Power Train
ON FORD CHASSIS, BOLT THAT HOLD THE DRIVELINE WHICH GOES INTO THE TRANSMISSION, SHEARED OFF WHICH MAY CAUSE A CRASH. *AK
NHTSA ODI #854877
Mileage unknown · Jan 31, 2000
Power Train
FORD ENGINEER INSPECTION CONCLUDED THAT MANUFACTURER DID NOT FOLLOW FORD SPECIFICATIONS FOR EXTENDING CHASIS/ DRIVESHAFT WAS 3 INCHES TOO LONG AND NOT AT THE PROPER ANGLE. ALSO PARTS THAT SHOULD HAVE BEEN BOLTED WERE WELDED. I HAVE PROOF OF ALL THESE ALL. THE DRIVESHAFT FELL OFF ON THREE SEPARATE OCCASIONS DUE TO THIS DEFECT.
ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE REFRIGERATOR BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: REXHALL WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE JULY 4, 2008. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR REXHALL AT 1-661-726-0565.
VEHICLE DESCRIPTION: MOTOR HOMES. THE DRIVE SHAFT BOLTS CAN COME LOOSE AT THE TRANSMISSION AND FALL OFF. WHEN THE DRIVE SHAFT SEPARATES FROM THE TRANSMISSION, THE FORWARD END OF THE SHAFT CAN DROP TO THE GROUND, OR COME THROUGH THE FLOORBOARDS OF THE MOTOR HOME.
Consequence & remedy
Consequence: THIS COULD LEAD TO LOSS OF VEHICLE CONTROL AND/OR THE DRIVE SHAFT CONTACTING A FOLLOWING VEHICLE.
Remedy: DEALERS WILL REPLACE THE BOLTS. OWNER NOTIFICATION BEGAN NOVEMBER 3, 2000. ALL VEHICLES HAVE BEEN REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1999 Rexhall Aerbus Problems, Complaints & Recalls | Skip That Year
Illustration