Component/System: Structure – Cowl / Air Intake / Engine Issue: Water intrusion through cowl leading to intake flooding and engine hydrolock Summary of the Defect The vehicle experienced a catastrophic engine failure caused by water intrusion through the two piece cowl assembly. The seal between the two cowl sections failed, a…
Read full complaint
Component/System: Structure – Cowl / Air Intake / Engine Issue: Water intrusion through cowl leading to intake flooding and engine hydrolock Summary of the Defect The vehicle experienced a catastrophic engine failure caused by water intrusion through the two piece cowl assembly. The seal between the two cowl sections failed, allowing rainwater to pour directly into the engine compartment. The intake manifold sits directly beneath this leak point and contains a recessed area where water can pool. After heavy rainfall, water entered the intake system and subsequently reached cylinders 2 and 4, causing the engine to hydrolock upon startup. The engine was rendered inoperable at only 29,139 miles. Detailed Description of the Incident The vehicle was parked outside an auto repair facility for a routine battery replacement. It was not driven during this period. Over the course of two heavy rain events, water entered the engine compartment through the failed seam in the two piece cowl. When the repair facility attempted to start the vehicle, the engine immediately hydrolocked. Upon disassembly: •The air intake tract was found full of water. •The intake manifold contained pooled water. •Cylinders 2 and 4 contained water. •The engine suffered internal damage consistent with hydrolock and was declared a total loss. All findings were documented by the mechanic, including photographs and diagnostic notes. Safety Concern This failure represents a serious safety defect. Water intrusion through a structural component should not be able to reach the intake manifold or engine cylinders under any circumstances — especially while the vehicle is stationary. A sudden hydrolock event can cause: •Immediate engine shutdown •Loss of motive power •Loss of power steering and braking assist •Potential loss of control if occurring while driving •Extremely costly engine destruction Inspected by mechanic. Nobody else. No warnings.
NHTSA ODI #11757003
Mileage unknown · Nov 15, 2024
Structure
The sliding side door cannot be manually unlocked. It can only be unlocked by the remote key FOB or by pressing an electrical switch in the cab. In the event of an emergency, such as a crash or fire, this may delay or prevent evacuation from the vehicle.
NHTSA ODI #11625557
Mileage unknown · Jun 27, 2024
EquipmentStructure
The contact owns a 2022 Winnebago Travato RV built on a 2022 Ram Promaster 3500. The contact had received notification of NHTSA Campaign Number: 23V627000 (Structure, Equipment) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceed…
Read full complaint
The contact owns a 2022 Winnebago Travato RV built on a 2022 Ram Promaster 3500. The contact had received notification of NHTSA Campaign Number: 23V627000 (Structure, Equipment) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and the contact was denied reimbursement for replacing the Firmware. The contact had not experienced a failure related to the recall. Parts distribution disconnect.
NHTSA ODI #11597174
Mileage unknown · Jun 3, 2024
Structure
The engine cowl between the windshield and the hood has been failing since day 1. This is a 2023/2022 Promaster 2500/Winnebago Solis. Winnebago says RAM is responsible and RAM says it is a non issue. The engine bay floods every time it rains. I have to cover it in and out to hopefully prevent engine and computer damage. There ar…
Read full complaint
The engine cowl between the windshield and the hood has been failing since day 1. This is a 2023/2022 Promaster 2500/Winnebago Solis. Winnebago says RAM is responsible and RAM says it is a non issue. The engine bay floods every time it rains. I have to cover it in and out to hopefully prevent engine and computer damage. There are many hundreds of events of flooding and damage with no admission of cowl and windshield damage. With fires becoming more prevalant, I am concerned with a fire, a life threat to me and my family. We need some kind of help. Please check this all over the web. It is a problem for all Promaster. I only get a Non Issue from RAM AND NOTHING FROM Winnebago. I have sent pictures and videos to both. NOTHING BACK. Maybe there are people are knowable in fixing. I believe this is an extremely serious, life threating issue. Water and electricity never mixes. Please HELP.10
NHTSA ODI #11592093
Mileage unknown · Nov 17, 2023
StructureVisibility/wiper
This is to report a safety report for a potentially serious, even fatal windshield, body, engine and transmission defect. Rain water pours down the windshield and floods the engine overcoming al engine parts especially electrical, transmission and engine parts that should remain dry and safe. Windshield to cowl to engine compart…
Read full complaint
This is to report a safety report for a potentially serious, even fatal windshield, body, engine and transmission defect. Rain water pours down the windshield and floods the engine overcoming al engine parts especially electrical, transmission and engine parts that should remain dry and safe. Windshield to cowl to engine compartment will flood and overcome safety equipment. When driving in rain I received electronic messages of failure. Headlights flood which could lead to a disaster. Ram will not admit part failures, but the constant flooding is well documented. Please help the many thousands of Ram Promasters get a recall which can save lives and their vehicles. Research will give you hours and hours of similar series problems. Please help us get Stealantis/Ram to own up to this manufacturing mishap. Thanks
NHTSA ODI #11555711
Mileage unknown · Oct 13, 2022
Structure
I'd like to report a safety issue with the RAM PROMASTER 3500 chassis. Ours is a Winnebago Solis PX Campervan. The sliding van side door is often impossible to open from the inside. There is a plastic lever that doesn't catch and is ineffective. I've been locked in many times after pulling and pulling on it and when the fro…
Read full complaint
I'd like to report a safety issue with the RAM PROMASTER 3500 chassis. Ours is a Winnebago Solis PX Campervan. The sliding van side door is often impossible to open from the inside. There is a plastic lever that doesn't catch and is ineffective. I've been locked in many times after pulling and pulling on it and when the front seats are turned around for camping it's difficult to use the front doors to exit. Obviously, in case of an emergent need to get out of the van, this is dangerous. I've seen many other owners of this model complain of the same issue. I believe its serious enough to require a recall but in any event, it should be redesigned immediately. There has not to my knowledge by inspected by any of the entities you've listed though I don't know if others have complained to them. It is available for inspection. Thank you.
Rollx Vans (Rollx) is recalling certain GMC Yukon, Sierra, Chevrolet Express 2500, Ford Transit, E-250, Toyota Sienna, Sienna Hybrid, Honda Odyssey, Chrysler Town and Country, Voyager, Pacifica, Dodge Grand Caravan, and Ram Promaster vehicles equipped with QRT-Deluxe and QRT-Max wheelchair restraints. Please refer to Rollx's recall report for specific model year information. The retractors may not lock, preventing the wheelchair from being properly secured.
Consequence & remedy
Consequence: An unsecured wheelchair can move during transit, increasing the risk of injury.
Remedy: Rollx will work with Q'Straint to inspect and replace the retractors as necessary, free of charge. Owner notification letters were mailed February 5, 2026. Owners may contact Rollx's customer service at 1-800-956-6668.
Chrysler (FCA US, LLC) is recalling certain 2018-2026 Ram ProMaster vehicles. The electrical circuit for the radiator fan may overheat.
Consequence & remedy
Consequence: Electrical circuits that overheat increase the risk of a fire.
Remedy: Dealers will replace the cooling fan module and fuse. In addition dealers will provide an addendum for the manual and label for the power distribution center. Some interim notification letters, notifying owners of the safety risk, were mailed December 11, 2025. Some owner notification letters were mailed beginning December 11, 2025. Additional owner notification letters were mailed in January, March, and June 2026. Remaining owner notification letters are expected to be mailed July 2026. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's numbers for this recall are 67C, B3C, and C9C. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov beginning October 30, 2025.
Chrysler (FCA US, LLC) is recalling certain 2022-2025 Ram ProMaster vehicles. A software error in the security gateway module may cause the rearview camera image not to display. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview image that does not display reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will update the security gateway module software, free of charge. Owner notification letters were mailed June 12, 2025. Owners may contact Chrysler customer service at 800-853-1403. Chrysler's number for this recall is 40C.
Chrysler (FCA US, LLC) is recalling certain 2021-2022 Dodge Durango, 2021-2023 Chrysler Pacifica, Jeep Grand Cherokee L, 2022 Ram 1500, 2500, 3500, Chrysler Voyager, 2022-2023 Jeep Compass, Grand Cherokee, Wagoneer, Grand Wagoneer, and Ram Promaster vehicles. The radio software may prevent the rearview image from displaying. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: A rearview camera image that does not display decreases the driver's visibility, increasing the risk of a crash.
Remedy: Dealers will update the radio software or the software will be OTA, "Over-The-Air," free of charge. Owner notification letters were mailed beginning July 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's numbers for this recall are 66B and 79B.
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Additional source detail variants (3)
Structure:body:door
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Seats:mid/rear Assembly
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Equipment:other:labels
Chrysler (FCA US, LLC) is recalling certain 2021-2024 Ram Promaster vehicles. The vehicles are missing a side door beam, and the tire placard contains incorrect seating capacity information. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 214, "Side Impact Protection" and 110, "Tire Selection and Rims."
Consequence: A missing side door beam may not provide adequate occupant protection in a crash, increasing the risk of injury. Incorrect seating capacity information can result in an improperly loaded vehicle, increasing the risk of injury in a crash.
Remedy: Dealers will install a door beam and apply an overlay label, free of charge. Owner notification letters were mailed August 1, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 53B.
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Additional source detail variants (2)
Exterior Lighting
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Electrical System:wiring
Chrysler (FCA US, LLC) (Stellantis) is recalling certain 2021-2022 Ram ProMaster vehicles. The wiring harness may have a poor connection, which can cause the left taillight and left turn signal to become inoperative. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: An inoperative left turn signal may not notify other drivers of a turning vehicle, and an inoperative left taillight can reduce the vehicle's visibility to other drivers. Both scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and replace the harness, as necessary free of charge. Owner notification letters were mailed February 20, 2025. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 21B.
Chrysler (FCA US, LLC) is recalling certain 2022-2023 Ram Promaster vehicles. The driver seat belt warning light and audible chime may not activate as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: A malfunctioning seat belt warning system can result in improper seat belt use, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the driver seat belt buckle as necessary, free of charge. Owner notification letters were mailed April 9, 2024. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is 02B.
Chrysler (FCA US, LLC) is recalling certain 2022 Ram Promaster Chassis Cab and incomplete vehicles equipped with an analog rearview camera. The analog rearview camera is the incorrect type of camera and cannot be installed. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperative rearview camera can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: Dealers will supply a digital rearview camera, free of charge. Owner notification letters were mailed February 7, 2023. Owners may contact FCA US, LLC customer service at 1-800-853-1403. FCA US, LLC's number for this recall is ZC5
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE26002 · Loss Of Power Steering Assist
Opened Mar 2, 2026 · No close date supplied
Status: open (inferred from source dates) · Electrical System:wiring:connectors/plugs/receptacles; Steering; Steering:electric Power Assist System; Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:electric Power Assist System
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering:rack And Pinion:rack
The Office of Defects Investigation (ODI) has received 19 Vehicle Owner Questionnaires (VOQs) alleging an intermittent or complete failure of the power steering assist system in certain Model Year (MY) 2022-2023 RAM ProMaster 1500, 2500, and 3500 vehicles. Failure of the power steering assist system can result in increased steering effort required to control the vehicle. An increase in steering effort can potentially lead to a loss of directional control of the vehicle. Several received reports allege failures of the steering rack with specific reports citing water intrusion into the electrical connectors of the electric power steering control module. ODI is opening this Preliminary Evaluation (PE) to assess the scope and root cause of potential defects in 2022-2023 RAM ProMaster steering systems. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
2022 RAM Promaster Problems, Complaints & Recalls | Skip That Year
Illustration