2022 RAM 2500

Lifter failure occurred on dangerous interstate interchange complete loss of power while towing a 14k pound mobile restroom bumper pull trailer in 6 lanes merging traffic from center lane 45 mph exit onto 60 mph interstate speeds XXX going onto XXX/[XXX] my scanner said dpf plugged stellantis mechanic claims lifter failure problem is complete loss of power happened in a dangerous area and waiting for a tow while hooked to a trailer was also dangerous due to high traffic area INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The vehicle has experienced repeated failures related to the diesel emissions system despite multiple repair attempts. The primary symptom is an illuminated check engine light accompanied by diagnostic trouble code P2459 (Diesel Particulate Filter Regeneration Frequency). The vehicle frequently enters regeneration cycles and continues to exhibit the same symptoms after major emissions system repairs. The emissions system components, including the Diesel Particulate Filter (DPF) and related DEF system components, were previously replaced by an authorized dealer. Following those repairs, the same warning light and fault code returned. The vehicle was subsequently inspected by another authorized dealer, which was unable to identify a definitive cause of the recurring condition. The check engine light was cleared, but it returned less than a week later with the same symptoms. The failure creates a safety concern because the vehicle may enter reduced-power or limp-home operating modes without warning, potentially limiting acceleration and the ability to maintain traffic speed. This is especially concerning when merging onto highways, crossing intersections, towing loads, or operating in heavy traffic. The recurring nature of the failure has reduced confidence in the reliability and safe operation of the vehicle. The condition has been reproduced multiple times and has been documented by authorized service facilities. Warning lamps and fault codes have repeatedly reappeared following repairs. The vehicle and emissions system components remain available for inspection upon request.

My truck was started in the morning and as it sat idle in the driveway I started attaching my trailer. By the time I got the trailer attached(20 seconds) there was smoke pouring out from under the hood. I immediately turned off the truck popped the hood and it was engulfed in flames. I was able to put out the fire with the garden hose. No check engine lights, no warning lights on dash, and I had just got it back from the dealership 2 days earlier and it passed a safety inspection before I picked it up. Im not sure what component failed but whatever did caused a fire

I am reporting a recurring safety defect involving hydraulic lifter failure in Ram trucks equipped with the Cummins diesel engine (model years 2019–2024). This issue is widely acknowledged by Stellantis and multiple dealers. It typically begins with a knocking sound and has been documented in many cases to progress to complete engine failure. My vehicle has fewer than 20,000 miles. The lifters were already replaced once, which required the cab to be removed. Within less than 400 miles of that repair, the knocking sound has returned. I brought the truck to a second dealer, who confirmed the problem and informed me that Stellantis has an active STAR case acknowledging the defect. They stated there is currently no known permanent fix. This defect presents a serious safety concern. Sudden engine failure while driving, especially under load or at highway speeds, could lead to loss of power, loss of steering/braking assist, and potential accidents. In my situation, I frequently travel with family members who have medical conditions, and being stranded in hazardous or remote conditions poses significant risk. At this point, my vehicle is not reliable or safe to operate. I am requesting NHTSA investigate the hydraulic lifter defect in 2019–2024 Ram Cummins trucks due to the safety implications and the lack of an available permanent repair.

Truck has had lifters replaced due to tick, sluggish performance and engine vibration. Truck was driven less then 500 miles and problem re-occurred. With research I have learned this is a widespread problem, and ram techs have reported complained there is no fix, and they are just reinstalling parts that will fail again. I feel the engine has had metal ran through it which in my opinion could cause this engine to seize up at. T tow a larch travel trailer with my family an and small pets in this vehicle.i live in the Desert where temperatures reach in the 120s. I can’t have a vehicle that could stop running leave myself and my family in a situation where the truck stops running, to be either hit by another vehicle or on the road side broken down. Problem was documented at 17000 miles and still under the 3 year 36 warranty.

Engine had a tick, dealer said it was lifters. Dealer replaced lifters after having the truck for three weeks. Noise is back 2022 ram 6.7 with 17000 miles. This issue could cause engine failure at any speed and I use this truck to pull a large travel trailer. I’m concerned the noise is back and putting metal shavings into the engine will cause catastrophic engine failure at some point.

Hydraulic roller lifter failure. Very common these pickups . Mine went in for a ticking noise hydraulic roller lifter failed got stuck in the bore. They replaced all 16 they test drove it stuck exhaust lifter #2 they replaced that lifter and the camshaft. Engine still has a very loud clatter and ticking noise. Did not do this when it was brand new

The Mass Air Flow (MAF) sensor on my 2022 Ram 2500 failed, causing multiple system malfunctions. It triggered inaccurate Diesel Particulate Filter (DPF) codes and showed abnormally high idle hours that do not reflect actual vehicle use. This defect is tied to a known issue identified by Stellantis in Technical Service Bulletin #18-002-24, which acknowledges improper MAF sensor calibration or compatibility on vehicles like mine. The bulletin was verbally confirmed by the dealership as applying to my truck. This faulty sensor caused emissions system errors, degraded engine performance, and may impact emissions compliance. There was a persistent check engine light, reduced fuel economy, and the risk of engine derating. The problem was reproduced and confirmed by Encore Chrysler (Mobile, AL), an authorized Ram dealership. Stellantis has agreed to cover the repair under Goodwill, but the issue appears systemic. Safety was potentially compromised by inaccurate sensor data that may cause sudden engine derate or failure during operation. Additionally, the incorrect idle hour readings could affect warranty determinations and long-term diagnostics if not corrected. The check engine light first appeared on May 21, 2024. The vehicle has been out of service since May 22, 2024, and repairs are still pending. The MAF sensor and affected systems are available for inspection upon request. This issue may affect a broader set of Ram 2500 trucks, and given the manufacturer’s internal bulletin, it may merit a recall review.