THE THIRD-ROW SEATS WERE KNOCKED OUT OF THEIR ANCHORS WHEN A FORD ESCORT HIT MY VAN IN THE REAR. I WAS STOPPED TO TURN WHEN I WAS HIT. THE ESCORT WAS TRAVELING AT APPROXIMATELY 40 TO 45 MPH, AND MY REAR BUMPER TOOK THE FULL FORCE OF THE IMPACT; AFTERWARDS, I NOTICED THAT BOTH THIRD ROW SEATS WERE OUT OF THEIR ACHORS AND LAYING…
Read full complaint
THE THIRD-ROW SEATS WERE KNOCKED OUT OF THEIR ANCHORS WHEN A FORD ESCORT HIT MY VAN IN THE REAR. I WAS STOPPED TO TURN WHEN I WAS HIT. THE ESCORT WAS TRAVELING AT APPROXIMATELY 40 TO 45 MPH, AND MY REAR BUMPER TOOK THE FULL FORCE OF THE IMPACT; AFTERWARDS, I NOTICED THAT BOTH THIRD ROW SEATS WERE OUT OF THEIR ACHORS AND LAYING BACK TOWARDS THE REAR GLASS. THE REPAIR SHOP WAS ONLY ABLE TO RE-SEAT ONE OF THE SEATS; THEY HAD TO ORDER A FRAME FOR THE OTHER ONE. THE COST OF THE NEW SEAT FRAME WAS $650.00. THE TOTAL AMOUNT OF DAMAGE TO MY VAN EXCEEDED $3,400.00. THE SEAT FRAME WAS THE SECOND MOST EXPENSIVE ITEM. MY WORRY IS THAT IF MY CHILDREN HAD BEEN WITH ME, SERIOUS INJURY COULD HAVE OCCURRED AS A RESULT OF THE SEATS COMING OUT OF THEIR ANCHORS. SECONDLY, THE SEAT BELTS ARE ATTACHED TO THE SEATS INSTEAD OF THE FLOOR, SO THESE ARE USELESS IN A REAR COLLISION. IF THE SEATS COME OUT THE SEATBELTS GO WITH THEM. I AM VERY DISAPPOINTED WITH THE PERFORMANCE OF BOTH THE SEATS AND THE SEATBELTS, I AM VERY UNCOMFORTABLE WITH PUTTING ANYONE IN THE THIRD ROW. THE BOTTOM LINE HERE IS THAT THE 1998 PONTIAC TRANS SPORT IS VERY UNSAFE WHEN IT COMES TO COLLISIONS.
NHTSA ODI #10070965
Mileage unknown · Jan 15, 2004
Unknown Or Other
THE POWER LOCKS ON THE PASSENGER AND DRIVER'S SIDE DOORS DO NOT WORK CORRECTLY. THE DRIVER SIDE DOOR WILL ONLY UNLOCK AND THAT WAS THAT WAY WHEN WE BOUGHT IT IN SEPTEMBR OF 2001. THE PASSENGER SIDE DOOR USE TO LOCK AND UNLOCK BUT THIS YEAR IT STARTED GIVING US PROBLEMS AND NOW WILL ONLY LOCK. WE ALSO HAVE PROBLEMS WITH THE ENGIN…
Read full complaint
THE POWER LOCKS ON THE PASSENGER AND DRIVER'S SIDE DOORS DO NOT WORK CORRECTLY. THE DRIVER SIDE DOOR WILL ONLY UNLOCK AND THAT WAS THAT WAY WHEN WE BOUGHT IT IN SEPTEMBR OF 2001. THE PASSENGER SIDE DOOR USE TO LOCK AND UNLOCK BUT THIS YEAR IT STARTED GIVING US PROBLEMS AND NOW WILL ONLY LOCK. WE ALSO HAVE PROBLEMS WITH THE ENGINE RATTLEING WHEN IT IS FIRST STARTS UP.
NHTSA ODI #10069571
71,000 miles · Feb 16, 2003
Unknown Or Other
AT 71,000 MILES, THE POWER WINDOW CONTROL MODULE ON MY 1998 PONTIAC TRANSPORT WAS FAILED. INITIALLY, THE DRIVERS SIDE POWER WINDOW MOVED VERY SLOWLY, AND THEN WOULDN'T CLOSE ALL THE WAY. FINALLY, IT OPERATED WITH THE WINDOW ASKEW, AND NOT CLOSING AT ALL.
NHTSA ODI #10007587
Mileage unknown · May 17, 2001
Air BagsEngine And Engine CoolingPower Train
THE POWER SLIDING DOOR OPENS ON IT'S OWN AND AT TIMES IT WON'T CLOSE, THE DOOR ALSO RATTLES AND THE MOLDING IS LOOSE. NLM
NHTSA ODI #561253
Mileage unknown · Dec 21, 2000
Engine And Engine CoolingUnknown Or Other
EXTREMELY UNHAPPY WITH SERVICE FROM DEALERS, THEY CAN NOT FIND THE PROBLEMS
NHTSA ODI #738130
Mileage unknown · Oct 27, 2000
Unknown Or Other
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #735291
Mileage unknown · Nov 6, 1998
Fuel System, GasolineUnknown Or Other
WHEN VEHICLE IS DRIVEN,ENGINE CHECK LIGHT COMES ON. BEEN IN SHOP 6 TIMES FOR PROBLEM. FUEL PUMP HAD TO BE REPLACED. BEEN ON DIAGNOSTIC MACHINE & PROBLEM NOT SOLVED. *AK
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES MAY HAVE (1) A BROKEN SHIFT CABLE FITTING OR (2) LOOSE SHIFT LINKAGE. CONSEQUENTLY, MOVING THE SHIFT LEVER TO A 'PARK' POSITION MAY NOT SHIFT THE TRANSMISSION TO 'PARK'.
Consequence & remedy
Consequence: THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE AUTOMATIC TRANSAXLE RANGE SELECTOR CABLE.
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7
PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1998 Pontiac Trans Sport Problems, Complaints & Recalls | Skip That Year
Illustration