IllustrationMileage unknown · May 23, 2014
Engine And Engine Cooling
AIR. *TR
NHTSA ODI #10593566
1998 Pontiac Trans Sport
Owner reports · Recalls · Investigations
More warning signs than most Trans Sport years
Owner complaints for the 1998 Pontiac Trans Sport are substantially higher than the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trans Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
30–25K
325–50K
2550–75K
1175–100K
20100–150K
5150K+
67 reports with mileage · 160 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 52 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 26 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
17 crash reports4 fire reports13 injury reports
What owners actually said
227 reportsAIR. *TR
TL* THE CONTACT OWNS A 1998 PONTIAC TRANS SPORT. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE ABS, AIR BAG AND CHECK ENGINE WARNING LAMPS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE…
Read full complaint
TL* THE CONTACT OWNS A 1998 PONTIAC TRANS SPORT. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED. THE CONTACT MENTIONED THAT THE ABS, AIR BAG AND CHECK ENGINE WARNING LAMPS ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,000. THE CURRENT MILEAGE WAS 119,317.
TL* THE CONTACT OWNS A 1998 PONTIAC TRANS SPORT. THE CONTACT STATED THAT WHEN ACCELERATING FROM A COMPLETE STOP, THE FRONT PASSENGER'S SIDE AIR BAG DEPLOYED INADVERTENTLY AND WITHOUT ANY IMPACT TO THE VEHICLE. THE DRIVER SUSTAINED MINOR BRUISES AND SWELLING TO THE RIGHT ARM. THE VEHICLE WAS IN THE PROCESS OF BEING TOWED TO AN AU…
Read full complaint
TL* THE CONTACT OWNS A 1998 PONTIAC TRANS SPORT. THE CONTACT STATED THAT WHEN ACCELERATING FROM A COMPLETE STOP, THE FRONT PASSENGER'S SIDE AIR BAG DEPLOYED INADVERTENTLY AND WITHOUT ANY IMPACT TO THE VEHICLE. THE DRIVER SUSTAINED MINOR BRUISES AND SWELLING TO THE RIGHT ARM. THE VEHICLE WAS IN THE PROCESS OF BEING TOWED TO AN AUTHORIZED DEALER. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 117,000.
ABS-ANTI LOCKING BRAKES ARE FAULTY AND LIGHT COMES ON FOR NO REASON. ALSO THE AIRBAG LIGHT COMES ON INTERMITTENTLY. *TR
TL* THE CONTACT OWNS A 1998 PONTIAC TRANSPORT. THE CONTACT EXITED THE VEHICLE AND WHEN HE RETURNED, THE VEHICLE WAS ENGULFED WITH WHITE SMOKE. THE CONTACT ROLLED DOWN THE WINDOWS TO RELEASE THE SMOKE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FAILURE WAS THE RESULT OF FAULTY WIRING. THE VEHICLE W…
Read full complaint
TL* THE CONTACT OWNS A 1998 PONTIAC TRANSPORT. THE CONTACT EXITED THE VEHICLE AND WHEN HE RETURNED, THE VEHICLE WAS ENGULFED WITH WHITE SMOKE. THE CONTACT ROLLED DOWN THE WINDOWS TO RELEASE THE SMOKE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FAILURE WAS THE RESULT OF FAULTY WIRING. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 149,000.
AFTER I HAD THE RADIATOR REPLACED $350 JOB THE INTAKE GASKET SPRUNG A LEAK. THEREFORE I HAD TO HAVE NOT ONLY THIS REPLACED BUT THE VALVE COVER GASKET AS WELL WHICH COST A TOTAL OF $867. I ALSO HAD TO RENT A CAR FOR 3 DAY WHICH COST AN ADDITIONAL $30 PER DAY. MY MECHANIC SAID THAT THE RECOMMENDED DEXCOL COOLANT USED IN THIS MODEL…
Read full complaint
AFTER I HAD THE RADIATOR REPLACED $350 JOB THE INTAKE GASKET SPRUNG A LEAK. THEREFORE I HAD TO HAVE NOT ONLY THIS REPLACED BUT THE VALVE COVER GASKET AS WELL WHICH COST A TOTAL OF $867. I ALSO HAD TO RENT A CAR FOR 3 DAY WHICH COST AN ADDITIONAL $30 PER DAY. MY MECHANIC SAID THAT THE RECOMMENDED DEXCOL COOLANT USED IN THIS MODEL CAR, OVER A PERIOD OF TIME, WILL EAT THRU THE GASKET THUS THE LEAK. I NEED TO KNOW IF THERE WAS A RE-CALL REGARDING THIS PROBLEM AND IF I CAN BE COMPENSATED. I AM A HARD WORKING INDIVIDUAL WITH LIMITED RESOURCES. I HAVE ALWAYS MAINTAINED REGULAR MAINTENANCE ON MY VEHICLES NOT FORESEEING THIS ISSUE THAT AROSE. PLEASE GET BACK IN TOUCH WITH ME AS SOON AS POSSIBLE REGARDING HIS MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
TL* THE CONTACT OWNS A 1998 PONTIAC TRANS SPORT. WHILE ATTEMPTING TO SHIFT INTO DRIVE, THE CONTACT NOTICED THAT THE GEAR SHIFTER WOULD NOT RESPOND AND HE WAS UNABLE TO REMOVE IT FROM THE PARK POSITION. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO REPAIRS. THE CURRENT AND FAILURE MILEAGES WAS 110,000.
I HAVE GOODYEAR ASSURANCE CMFTRD 97T 80,000 MILE TIRES ON MY 98 PONTIAC MONTANA VAN. THEY HAVE LESS THAN 30,000 MILES ON THEM AND TWO OF THEM STARTED LEAKING AIR OUT OF THE SIDEWALLS WHICH ARE FULL OF DRYROT TYPE CRACKS. TWO TIRE STORES TOLD ME THEY LOOK LIKE DEFECTS. I TOOK THEM BACK TO THE STORE WHERE I BOUGHT THEM AND THE DE…
Read full complaint
I HAVE GOODYEAR ASSURANCE CMFTRD 97T 80,000 MILE TIRES ON MY 98 PONTIAC MONTANA VAN. THEY HAVE LESS THAN 30,000 MILES ON THEM AND TWO OF THEM STARTED LEAKING AIR OUT OF THE SIDEWALLS WHICH ARE FULL OF DRYROT TYPE CRACKS. TWO TIRE STORES TOLD ME THEY LOOK LIKE DEFECTS. I TOOK THEM BACK TO THE STORE WHERE I BOUGHT THEM AND THE DEPTH WAS GREATER THAN 3/32 OF AN INCH. I AT THE TIME OF PURCHASE, BOUGHT A FREE REPLACEMENT/ROAD HAZARD CERTIFICATE THAT IS GOOD FOR ONLY THREE YEARS AND THE TIRES ARE NOW FOUR YEARS OLD. BECAUSE OF THE TIRE AGE THEY WANT TO PRORATE THESE UNSAFE TIRES AND CHARGE ME $65.00 @ FOR NEW ONES. WHY IS IT THAT THESE 80,000 MILE TIRES ARE NOT ANY GOOD AFTER 30,000 MILES AND MUST BE REPLACED. THIS VAN IS OUR SECOND CAR AND DOES NOT GET DRIVEN ENOUGH TO GET 80,000 MILES IN THE THREE YEARS THAT THE REPLACEMENT CERTIFICATE IS GOOD FOR.WHEN I BOUGHT THEM I WAS TOLD THESE WERE ONE OF THE BEST AT THAT TIME AND I WAS SURE TO GET A LOT OF MILES ON THEM. I AM VERY VERY UPSET THAT THESE TIRES HAVE PROVEN TO ME THAT THEY ARE VERY UNSAFE BECAUSE SIDEWALL LEAKS CANNOT BE REPAIRED AND I AM NOT NOW DRIVING THIS VAN BECAUSE I CANNOT TRUST THESE TIRES OR THEIR SAFETY. YEARS AGO, WHILE TRAVELING 700 MILES FROM HOME I HAD A BLOWOUT WITH, A TIRE THAT WAS ONE OF THEM FIRESTONE 500 TIRES. AT 70 MPH MY WHOLE FAMILY COULD HAVE BEEN KILLED AS A RESULT OF THIS AND TO THIS DAY I TAKE TIRE SAFETY VERY SERIOUSLY. WHAT CAN I DO ABOUT THIS POTENTIALLY LIFE THREATENING SITUATION? I CANNOT JUST GO OUT AND BUY NEW TIRES BECAUSE THESE ARE JUNK. AN 80,000 MILE TIRE SHOT AT 30,000 MILES DOES NOT COMPUTE. THEY REPLACED ONE TIRE AND CHARGED ME ONLY FOR A NEW REPLACEMENT/ROAD HAZARD CERTIFICATE.THEN I TOOK ANOTHER TIRE BACK TO THEM AND THEY CHARGED ME $93.00 FOR THE TIRE. MOUNTING ,BALANCE AND REPLACE CERTIFICATE. ONE FREE ONE AND ONE FOR A FEE AND I STILL HAVE TWO MORE OF THESE BAD TIRES. I COULD PARTIALLY UNDERSTAND THE PRO RATION IF THEY WERE NOT DEFECTIVE TIRES BUT THEY ARE. WHAT NEXT? *TR
PONTIAC TRANS SPORT 1998 --EXTERIOR LIGHTING:HEADLIGHTS VISIBILITY EXTREMELY POOR. OWN VEHICLE SINCE 2005. *TR
PAINT ON HOOD OF VAN IS PEELING AND COMING OFF RIGHT DOWN TO THE METAL. I'VE SEEN THE VERY SAME ISSUE ON MANY OTHER VANS LIKE MINE THE SAME YEAR, MAKE AND MODEL. THIS IS A FACTORY PAINT PROBLEM AND PONTIAC SHOULD FIX THIS. *TR
Official recalls
504V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
98V131000 · Power Train:automatic Transmission
Jun 11, 1998
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES MAY HAVE (1) A BROKEN SHIFT CABLE FITTING OR (2) LOOSE SHIFT LINKAGE. CONSEQUENTLY, MOVING THE SHIFT LEVER TO A 'PARK' POSITION MAY NOT SHIFT THE TRANSMISSION TO 'PARK'.
Consequence & remedy
Consequence: THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT, AND REPLACE IF NECESSARY, THE AUTOMATIC TRANSAXLE RANGE SELECTOR CABLE.
98V072000 · Visibility:windshield Wiper/washer:linkages
Apr 7, 1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
7PE04064 · POWER-SLIDING Door
Opened Sep 17, 2004 · Closed Dec 22, 2004
Status: closed (inferred from source dates) · Structure:body:door
SUBJECT VEHICLES ARE AVAILABLE WITH AN OPTIONAL POWER SLIDING DOOR.THE INTERIOR HANDLE IS ORIENTED IN THE VERTICAL POSITION IN THE DOOR PANEL AND LINES UP AT THE ELBOW LEVEL WHEN THE OCCUPANT IS SEATED IN THE 2ND-ROW OUTBOARD POSITION.IF THE OCCUPANT HOLDS THE INTERIOR HANDLE IN THE THUMB UP POSITION DURING POWER-ASSISTED OPENING, THE ARM/WRIST CAN BE PUSH BACK WITH FORCE AGAINST THE 2ND-ROW BUCKET SEAT OR CAPTAIN'S CHAIR SEAT BACK CREATING A RISK OF INJURY (OTHER SEATING CONFIGURATIONS HAVE AMPLE SEAT TO DOOR CLEARANCE TO AVOID ENTRAPMENT OF THE LOWER ARM).AMONG THE 103 TOTAL REPORTS, THERE WERE 102 ALLEGED INJURIES INCLUDING ARM/WRIST, THUMB AND SHOULDER INJURIES.A COUNT OF INJURIES REVEALS THAT 76 INJURIES WERE A FRACTURED OR A BROKEN ARM/WRIST REQUIRING AN IMMOBILIZING CAST FOR FOUR-TO-SIX WEEKS.ALL INJURIES INVOLVE THE RIGHT SIDE POWER SLIDING DOOR.THE LEFT SIDE POWER SLIDING DOOR IS ON FAR FEWER VEHICLES, BUT MORE IMPORTANTLY, IT PRODUCES LESS FORCE.GM NOTIFIED THE AGENCY BY LETTER DATED DECEMBER 21, 2004, THAT IT WILL RECALL MODEL YEAR 1997 THOUGH EARLY 2005 GM U-VAN VEHICLES EQUIPPED WITH A RIGHT SIDE POWER SLIDING DOOR AND WITH 2ND-ROW BUCKET SEATS OR CAPTAIN CHAIRS (NHTSA RECALL #04V597).AS PART OF THE RECALL REMEDY, GM WILL REPLACE THE DOOR HANDLE WITH A FLUSH MOUNTED HANDLE THAT WILL PREVENT AN OCCUPANT FROM GRASPING THE HANDLE WITH THE PALM BETWEEN THE HANDLE AND DOOR PANEL (THUMB UP ORIENTATION) AND THUS ELIMINATE THE POTENTIAL FOR ARM/WRIST ENTRAPMENT.THIS INVESTIGATION IS CLOSED.
EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
PE02086 · Rear Axle Trailing Arm Failure
Opened Nov 18, 2002 · Closed Apr 9, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Additional source detail variants (2)
Suspension
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
Suspension:rear
ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 14 INCIDENTS OF REAR TRAILING ARM FAILURES IN MODEL YEAR (MY) 1997 THROUGH 1999 GM U-VANS, INCLUDING TWO THAT ALLEGEDLY RESULTED IN CRASHES. THE TRAILING ARM DESIGN IN THESE VEHICLES IS USED IN THE U-VANS FROM MY 1997 THROUGH 2003.ACCORDING TO GM, THE SUBJECT TRAILING ARMS CAN CRACK OR BUCKLE IF THEY HAVE BEEN DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR CERTAIN SERVICE RELATED ABUSE CONDITIONS (E.G., IMPROPER TOWING OR JACKING).GM IDENTIFIED A PARTS HANDLING CONCERN THAT WAS CAUSING SOME TRAILING ARMS TO BE DAMAGED PRIOR TO INSTALLATION.TO ADDRESS THIS CONCERN, GM IMPLEMENTED CHANGES TO THE SHIPPING CONTAINERS FROM JANUARY 1999 THROUGH SEPTEMBER 1999. EIGHT (8) OF THE REPORTED INCIDENTS IN MY 1997-99 U-VANS, INCLUDING THE TWO CRASHES, OCCURRED IN THE LAST 2 YEARS.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO ASSESS THE TREND AND SAFETY RISK ASSOCIATED WITH THE ALLEGED DEFECT.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE00045 · Air Bag Tear During Deployment
Opened Nov 3, 2000 · Closed Jan 11, 2001
Status: closed (inferred from source dates) · Air Bags
No summary supplied.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available