NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
14 reportsClear category filter90,000 miles · Aug 18, 2008
Latches/locks/linkagesPower TrainVisibility
I HAVE OWNED BOTH A '92 AND A '97 TRANSPORT AND BOTH HAD THE SAME PROBLEMS. THE POWER WINDOW CONTROLS POP LOOSE OF THE DRIVER'S DOOR AND THE WINDOWS FAIL TO OPERATE. THE REAR DOOR LOCK FAILS. THE BLINKER AND CRUISE CONTROL LEVER SNAPPED OFF THE STEERING COLUMN SO THE BLINKER DOESN'T WORK. THE WINDOW WIPER CONTROL MODULE FAI…
Read full complaint
I HAVE OWNED BOTH A '92 AND A '97 TRANSPORT AND BOTH HAD THE SAME PROBLEMS. THE POWER WINDOW CONTROLS POP LOOSE OF THE DRIVER'S DOOR AND THE WINDOWS FAIL TO OPERATE. THE REAR DOOR LOCK FAILS. THE BLINKER AND CRUISE CONTROL LEVER SNAPPED OFF THE STEERING COLUMN SO THE BLINKER DOESN'T WORK. THE WINDOW WIPER CONTROL MODULE FAILED. THE TRANSAXLE HOSES SPRUNG A LEAK AT THE METAL CONNECTIONS CAUSING THE TRANSAXLE TO LOOSE FLUID AND THE VEHICLE TO BE STRANDED. *TR
NHTSA ODI #10238776
Mileage unknown · May 1, 2006
Exterior LightingPower TrainVisibility
MY TRANSMISSION HAS BEEN REPLACED ONCE AND I AM ALREADY HAVING PROBLEMS WITH IT AGAIN, IT'S ONLY BEEN A YEAR SINCE IT WAS REPLACED. BOTH OF MY FRONT WINDOWS ARE POWER WINDOWS AND I HAVE HAD TO REPLACE THE LITTLE MOTOR FOR THEM TO GO UP AND DOWN TWICE AND THE PASSENGER IS NOT WORKING AGAIN. MY LEFT FRONT SIGNAL LIGHT NEVER WORKS,…
Read full complaint
MY TRANSMISSION HAS BEEN REPLACED ONCE AND I AM ALREADY HAVING PROBLEMS WITH IT AGAIN, IT'S ONLY BEEN A YEAR SINCE IT WAS REPLACED. BOTH OF MY FRONT WINDOWS ARE POWER WINDOWS AND I HAVE HAD TO REPLACE THE LITTLE MOTOR FOR THEM TO GO UP AND DOWN TWICE AND THE PASSENGER IS NOT WORKING AGAIN. MY LEFT FRONT SIGNAL LIGHT NEVER WORKS, IT GETS REPLACED AND A DAY LATER IS NOT WORKING AGAIN. I HAVE PROBLEMS WITH MY STEERING WHEEL, IT IS VERY HARD TO TURN RIGHT, THIS WAS ALREADY FIXED AND I'M HAVING PROBLEMS AGAIN. I NEED TO KNOW IF THERE ARE OR THERE WHERE ANY RECALLS RELATED TO MY PROBLEMS. I HAVE READ ABOUT OTHER PEOPLE HAVING TRANSMISSION PROBLEMS. THANK YOU. *JB
NHTSA ODI #10156528
124,504 miles · Jul 27, 2005
Power TrainSteering
I WAS TURNING THE STEERING WHEEL TO THE LEFT TO PARALLEL PARK NEXT TO THE CURB, THEN I HEARD A LOUD POP NOISE. WHEN I WENT TO TURN THE STEERING WHEEL TO THE RIGHT IT BEGAN VERY HARD TO TURN THE WHEEL. AFTER LEAVING THE STORE AND FROM THAT POINT ON EVERY ATTEMPT I MADE TO MAKE A RIGHT TURN, IT WAS EXTREMELY DIFFICULT. AFTER ARRIV…
Read full complaint
I WAS TURNING THE STEERING WHEEL TO THE LEFT TO PARALLEL PARK NEXT TO THE CURB, THEN I HEARD A LOUD POP NOISE. WHEN I WENT TO TURN THE STEERING WHEEL TO THE RIGHT IT BEGAN VERY HARD TO TURN THE WHEEL. AFTER LEAVING THE STORE AND FROM THAT POINT ON EVERY ATTEMPT I MADE TO MAKE A RIGHT TURN, IT WAS EXTREMELY DIFFICULT. AFTER ARRIVING HOME I NOTICED LEAKING COMING FROM UNDER MY VAN. I CALLED THE LOCATION PONTIAC DEALERSHIP ABOUT THE MY STEERING PROBLEM AND THEY INDICATED THAT THE VAN HAD BEEN SERVICED FOR A RECALL IN FEBRUARY OF 2003 FOR THE RACK AND PINION RECALL SOMETHING RELATED TO THE STEERING. SO I CHECKED THE INTERNET FOR THE RECALL AND IT MENTIONED THE SAME EXACTLY PROBLEMS THAT I WAS HAVING NOW. I CALLED THE DEALERSHIP BACK AND THEY SAID THAT THE RECALL WAS ALREADY DONE ONCE. I TOLD THEM IT IS DOING THE SAME EXACTLY THING, AND WHEN I WENT TO CHECK THE STEERING ONE MORE TIME I NOTICED A HUGE PUDDLE UNDER MY VAN OF REDDISH BROWN FLUID. COME TO FIND OUT IT WAS TRANSMISSION LEAKING AND WHEN I TURN THE ENGINE ON THE FLUID CAME POURING OUT LIKE A FAUCET. I CONTACTED A TRANSMISSION SHOP TO TAKE A LOOK AT MY VAN AND THE MECHANIC TOLD ME THAT THE AXLE WAS PULLED OUT OF THE TRANSMISSION BY THE STEERING SYSTEM. THE MECHANIC ALSO MENTIONED THAT HE HAS DONE QUITE A FEW OF THESE SAME EXACTLY KIND OF MINI-VAN WITH THE SAME EXACTLY PROBLEM. HE SAID THAT HE KNEW EXACTLY HOW THE FIX THIS PROBLEM BECAUSE HE DOES IT QUITE OFTEN. THE REPAIR COSTED $1,800.00 DOLLARS AND THE MECHANIC TOLD ME NOW I NEED TO TAKE BACK TO THE DEALER TO HAVE THEM REPAIR THAT RACK AND PINION AGAIN. NOW THIS HAS ME VERY UPSET, I'M SO MAD ABOUT THIS BECAUSE THIS DEFINITELY SOUNDS LIKE A MANUFACTURE PROBLEM AND I SHOULD NOT HAVE TO PAY FOR THIS. I SENT THE VAN TO KARCO TRANMISSIONS IN LANCASTER, CALIFORNIA WHERE I LIVE AND THE PHONE NUMBER IS 661-723-1164. THIS DOES NOT MAKE ANY SENSE TO ME, SO THIS IS WHY I AM FILING THIS COMPLAINT.
NHTSA ODI #10130353
Mileage unknown · Jan 19, 2005
Engine And Engine CoolingPower Train
THE VEHICLE'S TRANSMISSION HAD TO BE REPLACED AND THE ENGINE HAD TO BE REPLACED DUE TO A FAULTY HEAD GASKET. *NM THE TRANSMISSION FAILED TWICE. *JB THE CONSUMER STATED THAT HE HAS HAD THE VEHICLE TOWED ON FOUR SEPARATED OCCASIONS. *TC
NHTSA ODI #10109730
123,000 miles · Nov 5, 2004
Power Train
WHILE COMING TO A STOP TRANSMISSION SLIPPED GEARS. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10099484
Mileage unknown · Aug 2, 2004
Fuel System, GasolinePower TrainSteering
CONSUMER COMPLAINED ABOUT HAVING ALL KINDS OF PROBLEMS WITH VEHICLE. FIRSTLY, TRANSMISSION MALFUNCTIONED, AND IT WAS REPAIRED. SECONDLY, POWER STEERING FLUID WAS LEAKING, AND CONSUMER KEPT REPLACING IT. THIRDLY, THERE WAS A GASOLINE LEAK, WHICH WAS REPAIRED.*AK
NHTSA ODI #10084041
63,830 miles · Jul 30, 2004
Power Train
TRANSMISSION IS SLIPPING OUT OF GEAR WHILE DRIVING, CAUSING THE VEHICLE TO SLOW. VEHICLE IS ALSO SLOW TO ENGAGE GEAR WHEN ACCELERATING. ENGINE RPM WILL BE VERY HIGH UNTIL THE TRANSMISSION DOES ENGAGE THE NEXT GEAR. THIS IS THE SECOND INCIDENT FOR THIS VEHICLE, THE FIRST TIME (25,000 MILES) THE TRANSMISSION WAS REBUILT BY MANUFA…
Read full complaint
TRANSMISSION IS SLIPPING OUT OF GEAR WHILE DRIVING, CAUSING THE VEHICLE TO SLOW. VEHICLE IS ALSO SLOW TO ENGAGE GEAR WHEN ACCELERATING. ENGINE RPM WILL BE VERY HIGH UNTIL THE TRANSMISSION DOES ENGAGE THE NEXT GEAR. THIS IS THE SECOND INCIDENT FOR THIS VEHICLE, THE FIRST TIME (25,000 MILES) THE TRANSMISSION WAS REBUILT BY MANUFACTURE. THE SECOND TIME (63,000 MILES) THE TRANSMISSION IS BEING REPLACED. *AK
NHTSA ODI #10083007
143,987 miles · Jan 15, 2004
Engine And Engine CoolingPower TrainSuspension
THIS VEHICLE WAS VERY WELL MAINTAINED OILCHANGE EVERY 3K MILES, TRANSMISSION SERVICED EVERY 30,000 MILES. THE RACK&PINION WENT OUT IN OCTOBER 2003. THE TRANSMISSION WENT OUT IN MAY OF THIS YEAR AND NOW THE ENGINE. VAN WAS RUNNING HOT, WE REPLACED THE THERMOSTAT, WATER PUMP, OXYGEN SENSOR, MAIN RADIATOR HOSE AND FLUSHED RADIATO…
Read full complaint
THIS VEHICLE WAS VERY WELL MAINTAINED OILCHANGE EVERY 3K MILES, TRANSMISSION SERVICED EVERY 30,000 MILES. THE RACK&PINION WENT OUT IN OCTOBER 2003. THE TRANSMISSION WENT OUT IN MAY OF THIS YEAR AND NOW THE ENGINE. VAN WAS RUNNING HOT, WE REPLACED THE THERMOSTAT, WATER PUMP, OXYGEN SENSOR, MAIN RADIATOR HOSE AND FLUSHED RADIATOR, AND PURCHASED A NEW RADIATOR CAP. IT IS STILL RUNNING HOT. IT HAS A BLOWN HEAD GASKET, AND A WARPED HEAD, NO TELLING WHAT THIS WILL COST.
NHTSA ODI #10070607
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingPower Train
OUR 97 PONTIAC TRANSPORT WAS FINE UNTIL LAST YEAR. NEW TRANSMISSION (70,000 MILES, O.K.) THEN A FEW MONTHS LATER IT BEGAN OVERHEATING--NEW THERMOSTAT, WHICH WORKED FOR A FEW WEEKS, THEN NEW RADIATOR, WHICH WORKED FOR A FEW WEEKS, THEN, WHEN THE MECHANIC SAID IT PROBABLY NEEDED A HEAD GASKET ($2000 OR MORE) WE DECIDED TO GET RID …
Read full complaint
OUR 97 PONTIAC TRANSPORT WAS FINE UNTIL LAST YEAR. NEW TRANSMISSION (70,000 MILES, O.K.) THEN A FEW MONTHS LATER IT BEGAN OVERHEATING--NEW THERMOSTAT, WHICH WORKED FOR A FEW WEEKS, THEN NEW RADIATOR, WHICH WORKED FOR A FEW WEEKS, THEN, WHEN THE MECHANIC SAID IT PROBABLY NEEDED A HEAD GASKET ($2000 OR MORE) WE DECIDED TO GET RID OF IT. BUT WE WERE NOT EVEN ABLE TO USE IT AS A TRADE IN, BECAUSE IT OVERHEATED SO BADLY. THE ELECTRICAL SYSTEM HAD ALWAYS BEEN QUIRKY, BUT LIVABLE (I.E. THE GAS GAUGE HAD NEVER WORKED, THE WINDOWS WERE VERY SLOW AND THE CELL PHONE PLUGS NEVER WORKED) I CALLED THE DEALER (PERUZZI, IN LANGHORNE, PA) BUT, OF COURSE, IT WAS NOT THEIR PROBLEM. THE MECHANIC TOLD US THAT GM WAS USING A NEW COOLANT IN THEIR 97'S WHICH BECAME PROBLEMATIC AS IT AGED--HE THOUGHT THAT MIGHT HAVE BEEN THE ORIGINAL SOURCE OF THE PROBLEM, BUT ACKNOWLEDGED THAT GM HAS NOT ADMITTED TO ANY ERROR. WE WERE THE ORIGINAL OWNERS AND ALWAYS MAINTAINED THE CAR PROPERLY, FROM DAY ONE. THE MECHANIC IS A PERSONAL FRIEND, AND HAS AN EXCELLENT REPUTATION. THE CAR WAS SOLD FOR JUNK. IT'S VALUE, ACCORDING TO EDMUNDS.COM, WAS ABOUT $6000/7000 .
NHTSA ODI #10070158
65,000 miles · Apr 14, 2003
Power Train
1997 PONTIAC TRANSPORT TRANSMISSION FAILURE UNDER 70,000 MILES $2,500.00 REPAIR FAULTY INTAKE VALVE GASKET UNDER 70,000 $650.00 REPAIR. *NLM
NHTSA ODI #10014389
Official recalls
5Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Apr 7, 1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Illustration