IllustrationCONSUMER STATED, WHILE DRIVING THE VEHICLE NOTICED A SMOKE UNDER THE HOOD. PLASTIC MANIFOLD WAS CAUSING THE BURNING, DAMAGED THE HEAD GASKET. DEALER HAS BEEN NOTIFIED. TS INTAKE MANIFOLD RESEALED. *TT
1997 Pontiac Trans Sport
Owner reports · Recalls · Investigations
More warning signs than most Trans Sport years
Owner complaints for the 1997 Pontiac Trans Sport are substantially higher than the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trans Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 58 of 236 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 54 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 37 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports2 fire reports5 injury reports
Engine And Engine Cooling complaints
42 reportsTHE VAN WAS INVOLVED IN ACCIDENT WHICH THE INTAKE MANIFOLD GASKET WAS DAMAGED. THE VAN WAS REPAIRED BY A PONTIAC DEALERSHIP. ANTI-FREEZE IS LEAKING BY THE INTAKE MANIFOLD AND MIXING WITH THE OIL, WHICH WASN'T FROM THE ACCIDENT. THE OWNER HAS FOUND SIMILAR REPORTS ON "NHTSAS' WEBSITE. PLEASE DESCRIBE DETAILS. TS
WHILE DRIVING IN RAINY WEATHER, THE HEAD LIGHT LEN COVERS FELL OFF DUE TO INFERIOR ADHESIVE CAUSING THE BULBS TO BURN OUT. MANUFACTURER NOTIFIED. *TT
LOSS OF COOLANT FROM THE TAIL PIPE. VEHICLE TAKEN TO A REPAIR SHOP AND INFORMED THAT INTAKE MAMIFOLD GASKET WAS CRACKED. DEALER AND MANUFACTUERER WERE NOTIFIED. *AK THE COOLANT IS GETTING INTO THE MOTOR OIL WHICH COULD CAUSE ENGINE FAILURE. CONSUMER WOULD LIKE ATTENTION TO THIS MATTER BECAUSE IF THE PROBLEM GETS WORSE, A NEW …
Read full complaint
LOSS OF COOLANT FROM THE TAIL PIPE. VEHICLE TAKEN TO A REPAIR SHOP AND INFORMED THAT INTAKE MAMIFOLD GASKET WAS CRACKED. DEALER AND MANUFACTUERER WERE NOTIFIED. *AK THE COOLANT IS GETTING INTO THE MOTOR OIL WHICH COULD CAUSE ENGINE FAILURE. CONSUMER WOULD LIKE ATTENTION TO THIS MATTER BECAUSE IF THE PROBLEM GETS WORSE, A NEW ENGINE WOULD HAVE TO BE PUT IN. *JG
SLIDING DOOR WOULD NOT CLOSE AUTOMATICALLY. DOOR WOULD NOT LATCH. BUZZER WOULD SOUND AND DOOR WOULD COME OPEN, EVEN WHILE DRIVING. VEHICLE WAS TAKEN IN TWICE UNDER RECALLS. ONCE UNDER RECALL 01 V 224 000 FOR SLIDING DOOR AND SECOND TIME UNDER RECALL 01 V 067 000. NEITHER RECALL CORRECTED THE PROBLEM. *AK. CONSUMER ALSO STATED…
Read full complaint
SLIDING DOOR WOULD NOT CLOSE AUTOMATICALLY. DOOR WOULD NOT LATCH. BUZZER WOULD SOUND AND DOOR WOULD COME OPEN, EVEN WHILE DRIVING. VEHICLE WAS TAKEN IN TWICE UNDER RECALLS. ONCE UNDER RECALL 01 V 224 000 FOR SLIDING DOOR AND SECOND TIME UNDER RECALL 01 V 067 000. NEITHER RECALL CORRECTED THE PROBLEM. *AK. CONSUMER ALSO STATED THE LEFT TURN SIGNAL WAS INOPERATIVE, THE DEALER REPLACED THE TURN SIGNAL BULB, ALSO THERE WAS A RATTLE NOISE WHEN VEHICLE WAS IN IDLE, DEALER REPLACED THE BELT TENSIONER.*JB
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
VERY LOUD ENGINE KNOCK, LEAVING THE CAR UNDRIVABLE. THIS, ACCORDING TO THE GM DEALER SERVICE DEPARTMENT IN LARAMIE, WY, HAS BEEN CAUSED BY EITHER A SPUN BEARING/BEARING FAILURE OR OTHER FAILURE CAUSING LACK OF OIL FLOW TO VITAL ENGINE PARTS. I MUST NOW EI. *AK
INTAKE MANIFOLD GASKET LEAKS OIL/ANTIFREEZE DOWN THE ENGINE. THIS PROBLEM IS KNOWN TO GM BUT IT DOES NOTHING.*AK
THE VEHICLE'S ENGINE FAILED RESULTING IN A BLOWN MOTOR. THERE WERE NO WARNINGS OR INDICATIONS OF IMPENDING FAILURE. WE PURCHASED THE VEHICLE APPROXIMATELY ONE YEAR AGO. THE VEHICLE HAS BEEN REGULARLY MAINTAINED(EVERY 3000-4000 MILES)BY US AND THE PREVIOUS OWNER AND WE HAVE THE DOCUMENTATION TO SHOW IT. OUR INDEPENDENT RESEARCH H…
Read full complaint
THE VEHICLE'S ENGINE FAILED RESULTING IN A BLOWN MOTOR. THERE WERE NO WARNINGS OR INDICATIONS OF IMPENDING FAILURE. WE PURCHASED THE VEHICLE APPROXIMATELY ONE YEAR AGO. THE VEHICLE HAS BEEN REGULARLY MAINTAINED(EVERY 3000-4000 MILES)BY US AND THE PREVIOUS OWNER AND WE HAVE THE DOCUMENTATION TO SHOW IT. OUR INDEPENDENT RESEARCH HAS FOUND THAT A SIMILAR DEFECT EXISTED IN MODEL YEARS PRIOR TO OUR VEHICLE'S. GM HAS BEEN RELUCTANT TO ASSIST US WITH THIS PROBLEM. *AK
I HAVE HAD THE SEAT BELT LATCHES REPLACED 4 TIMES ON THE MID-ROW SEATS. 2 TIMES I HAVE HAD TO TAKE IT IN TO HAVE THE WINDOW LATCH REPAIRED ON THE MID-ROW,LEFT WINDOW. IT KEPT POPPING OPEN WHEN DRIVING IN BUMPY CONDITIONS. THE WATER PUMP HAS GIVEN OUT 2X. THE POWER SLIDING DOOR KEEPS BLOWING THE FUSE AND WILL NOT OPERATE. TH…
Read full complaint
I HAVE HAD THE SEAT BELT LATCHES REPLACED 4 TIMES ON THE MID-ROW SEATS. 2 TIMES I HAVE HAD TO TAKE IT IN TO HAVE THE WINDOW LATCH REPAIRED ON THE MID-ROW,LEFT WINDOW. IT KEPT POPPING OPEN WHEN DRIVING IN BUMPY CONDITIONS. THE WATER PUMP HAS GIVEN OUT 2X. THE POWER SLIDING DOOR KEEPS BLOWING THE FUSE AND WILL NOT OPERATE. THE REAR WINDOW WIPER AND WASHER HAS BEEN INOPERABLE ON 2 OCCASIONS. DEALER HAS ATTEMPTED TO FIX ALL THESE PROBLEMS REPEATEDLY, BUT THEY ARE ONLY TEMPORARY FIXES! THESE THINGS ARE OBVIOUSLY DEFECTS BECAUSE THEY OCCUR AGAIN AND AGAIN. *AK
Official recalls
504V597000 · Latches/locks/linkages:doors:latch
Dec 22, 2004
ON CERTAIN MINIVANS EQUIPPED WITH SECOND-ROW BUCKET SEATS OR CAPTAIN'S CHAIRS AND A POWER SLIDING DOOR ON THE PASSENGER SIDE OF THE VEHICLE, A PASSENGER USING THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR COULD BE INJURED.
Consequence & remedy
Consequence: IF A PASSENGER USES THE INTERIOR HANDLE TO OPEN THE POWER SLIDING DOOR AND HOLDS ONTO THE HANDLE WHILE IT IS BEING OPENED BY THE MOTOR, THE PASSENGER'S ARM MAY BE PUSHED INTO THE SEAT BACK OR ARMREST AND A WRIST OR LOWER ARM INJURY MAY RESULT.
Remedy: DEALERS WILL REPLACE THE POWER SLIDING DOOR INTERIOR HANDLE ON THE PASSENGER-SIDE. IF THE VEHICLE IS EQUIPPED WITH A POWER OR MANUAL SLIDING DOOR ON THE DRIVER-SIDE, THE INTERIOR HANDLE WILL ALSO BE REPLACED FOR APPEARANCE REASONS. NOTE: BEFORE THE VEHICLE IS SERVICED, GM ADVISES OWNERS TO NOT USE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR. THE DRIVER CAN OPEN AND CLOSE THE DOOR FROM SWITCHES AT THE DRIVER'S POSITION OR BY USING THE REMOTE KEY FOB. THE DRIVER SHOULD TELL PASSENGERS TO USE THE SWITCH LOCATED IN FRONT OF THE DOOR TO OPEN OR CLOSE IT. THE DRIVER SHOULD USE THE OVERRIDE SWITCH TO PREVENT OPERATION OF THE POWER DOOR BY CHILDREN OR BY OTHERS WHO ARE NOT FAMILIAR WITH ITS USE. THE OWNER NOTIFICATION LETTER MAILING WILL BE CONDUCTED IN PHASES WITH THE FIRST PHASE BEGINNING ON MAY 31, 2005. THE SECOND PHASE MAILING BEGAN ON JULY 18, 2005. THE RECALL BEGAN ON MAY 31, 2005. PHASE 2 BEGAN ON JULY 18, 2005. PHASE 3 (FINAL PHASE) BEGAN ON AUGUST 24, 2005, TO ALL REMAINING CUSTOMERS. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438; PONTIAC AT 1-800-620-7668; OR OLDSMOBILE AT 1-800-630-6537.
02V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V264000 · Latches/locks/linkages:doors:latch
Aug 21, 2001
VEHICLE DESCRIPTION: 1997-2001 CHEVROLET VENTURE, PONTIAC MONTANA/TRANSPORT, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS THAT WERE SERVICED IN CAMPAIGN 01013 (01V-067) FROM APRIL TO AUGUST 2001. ALSO 2001 CHEVROLET VENTURE, PONTIAC MONTANA, AND OLDSMOBILE SILHOUETTE MINI VANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS ASSEMBLED IN JANUARY THROUGH APRIL 2001. THESE VEHICLES HAVE INADEQUATE FRONT WELDS. IF A FRONT WELD FAILS, THE ACTUATOR CAN JAM IN THE UNLATCHED POSITION AND, WHEN THE SLIDING DOOR CLOSES, IT WILL NOT BE LATCHED.
Consequence & remedy
Consequence: IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE. AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSPECT AND, IF REQUIRED, INSTALL A NEW POWER SLIDING DOOR UNLATCH ACTUATOR ASSEMBLY. OWNER NOTIFICATION BEGAN ON OCTOBER 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
01V067000 · Latches/locks/linkages:doors:latch
Mar 8, 2001
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH PASSENGER SIDE POWER SLIDING DOORS. THE DOOR CLOSES BUT MAY NOT BE LATCHED. IF THIS HAPPENS, THE POWER SLIDING DOOR CAN OPEN WHILE THE VEHICLE IS IN MOTION, PARTICULARLY WHEN THE VEHICLE ASCENDS A HILL, MAKES A TURN, OR TRAVELS OVER A ROUGH ROAD SURFACE.
Consequence & remedy
Consequence: AN UNRESTRAINED OCCUPANT COULD FALL OUT OF THE VAN AND BE INJURED.
Remedy: DEALERS WILL INSTALL A NEW UN-LATCH ACTUATOR ASSEMBLY TO THE POWER SLIDING DOOR. THIS RECALL HAS BEEN CONTINUED UNDER SAFETY RECALL 01V-264. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
98V072000 · Visibility:windshield Wiper/washer:linkages
Apr 7, 1998
VEHICLE DESCRIPTION: PASSENGER MINI VANS EQUIPPED WITH TRACTION CONTROL SYSTEMS. THE WINDSHIELD WIPER LINKAGE ARM CAN CONTACT A BRAKE LINE WHICH IS CONNECTED TO THE TRACTION CONTROL SYSTEM MODULATOR VALVE. THIS CONTACT CAN CHAFE THE BRAKE LINE RESULTING IN A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: BRAKE FLUID LEAKAGE CAN CAUSE REDUCED BRAKE EFFECTIVENESS AND INCREASED STOPPING DISTANCES.
Remedy: DEALERS WILL INSTALL A BRAKE LINE CLIP TO ENSURE PROPER CLEARANCE. ALSO THE BRAKE LINES WILL BE INSPECTED TO ANY DAMAGE CAUSED BY THIS CONDITION AND WILL REPLACE ANY DAMAGED LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
6EA03005 · Rear Axle Trailing Arm Failure
Opened Apr 23, 2003 · Closed Jan 12, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Additional source detail variants (2)
Suspension
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
Suspension:rear
ON NOVEMBER 18, 2002, ODI OPENED A PRELIMINARY EVALUATION (PE02-086) TO EVALUATE ALLEGATIONS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES (U-VAN) WHICH INCLUDED TWO REPORTING CRASHES.ON APRIL 9, 2003, ODI UPGRADED PE02-086 TO AN ENGINEERING ANALYSIS (EA03-005) TO CONTINUE ITS EXAMINATION OF THE ISSUE. THE TRAILING ARM DESIGN IN THESE VEHICLES HAS BEEN USED IN THE U-VAN FROM MY 1997 THROUGH THE PRESENT.THE GM ANALYSIS CONCLUDED THAT THE SUBJECT TRAILING ARMS COULD CRACK OR BUCKLE IF THEY WERE DAMAGED DURING ASSEMBLY, PRE-DELIVERY HANDLING, OR SUBJECTED TO CERTAIN SERVICE RELATED ABUSE CONDITIONS SUCH AS IMPROPER TOWING OR JACKING.ANALYSIS OF ODI AND GM DATA HAS IDENTIFIED 19 INCIDENTS OF REAR AXLE TRAILING ARM FAILURES IN THE SUBJECT VEHICLES.THERE HAVE BEEN NO NEW REPORTS TO ODI OR GM IN THE LAST 12 MONTHS AND ONLY ONE NEW COMPLAINT IN THE LAST 21 MONTHS. DUE TO THE LOW COMPLAINT RATE AND THE ABSENCE OF A CONTINUING TREND IN REPORTED FAILURES, A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
EA02032 · Safety Belt Assembly Failure
Opened Nov 18, 2002 · Closed Nov 21, 2003
Status: closed (inferred from source dates) · Seat Belts
ODI IDENTIFIED 59 REPORTS WITH THE ALLEGED DEFECT.ODI WAS ABLE TO CONTACT 44 OF THE 59 CONSUMERS IN ORDER TO DETERMINE THE SPECIFIC CAUSE OF THE LATCH PROBLEMS.OF THE 44 OWNERS CONTACTED, ODI DETERMINED THAT FOUR FAILURES WERE DUE TO AN OUT-OF-TOLERANCE LATCH PLATE, AND THAT 23 FAILURES WERE DUE TO A DISPLACED BUCKLE HOUSING COVER.THE REMAINING 17 FAILURES HAD INDETERMINABLE CAUSES.OF THE 59 REPORTS, THERE WERE THREE ALLEGED MINOR INJURIES.NO LEGAL CLAIMS OR LAWSUITS HAVE BEEN FILED WITH REGARD TO THIS ALLEGED DEFECT.BASED ON THE LIMITED NUMBER OF REPORTS, AND A DECLINING REPORT TREND, THIS INVESTIGATION IS CLOSED.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEARED TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE ADDITIONAL SUMMARY REPORT.
EA02003 · Power Rack And Pinion Steering Failure
Opened Apr 4, 2002 · Closed Dec 10, 2002
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Additional source detail variants (2)
Steering
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
Steering:rack And Pinion
THE LOWER PINION BEARING IN THE RACK AND PINION STEERING ASSEMBLY MAY FAIL.GM WILL RECALL 1997-98 GRAND PRIX BUILT BETWEEN 1-MAR-96 AND 31-OCT-97; AND 1996-98 U-VANS/J-CARS BUILT BETWEEN 1-JAN-96 AND 31-OCT-97.SEE ATTACHED SUMMARY.
PE02017 · Shoulder Harness Clip
Opened Feb 11, 2002 · Closed Aug 2, 2002
Status: closed (inferred from source dates) · Seat Belts
No summary supplied.
PE01038 · Steering Rack And Pinion
Opened Nov 14, 2001 · Closed Apr 4, 2002
Status: closed (inferred from source dates) · Steering
ODI HAS RECEIVED 200 COMPLAINTS FROMT CONSUMERS AND 1,238 FROM GM ALLEGING FAILURE OR LOCKUP OF THE STEERING RACK AND PINION UNIT (R&P).THIS ALLEGED CONDITION CAN RESULT IN THE LOSS OF STEERING CONTROL OF THE VEHICLE AND A CRASH CAN RESULT.GM HAS REPORTED SIX CRASHES IN WHICH EIGHT PEOPLE HAVE SUSTAINED INJURIES RANGING FROM BRUISES, AIRBAG BURN, SEAT BELT ABRASION, FACIAL INJURY, NECK AND BACK PAIN.ALL CRASHES WERE SINGLE VEHICLE CRASHES.GM STATES THAT ONE POSSIBLE FAILURE MODE IS FAILURE OF THE LOWER PINION BEARING IN THE R&P.AN ENGINEERING ANALYSIS HAS BEEN OPENED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS.
SQ00014 · Unexpected Opening Of Sliding Door
Opened Jul 25, 2000 · Closed Oct 22, 2001
Status: closed (inferred from source dates) · Structure
There is no summary currently available