Illustration1996 PONTIAC TRANS SPORT, MOTOR SEIZED UP AND BEGAN TO SMOKE, MOTOR CAUGHT FIRE. *BF PRIOR TO THE FIRE, THE DRIVER NOTICED THE VEHICLE WAS LEAVING SOME TYPE OF FLUID BEHIND. ACCORDING TO THE POLICE REPORT, THE ENGINE WAS LEAKING OIL. (OHIO TRAFFIC CRASH REPORT # 10-0409-90)*JB UPDATED 08/05/10 *BF
1996 Pontiac Trans Sport
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Pontiac Trans Sport do not stand out strongly from the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all Trans Sport years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 16 of 61 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports2 fire reports4 injury reports
Engine And Engine Cooling complaints
13 reports1996 PONTIAC TRANSPORT VAN WITH LEAKING INTAKE MANIFOLD GASKETS. CONSUMER STATES THAT THE INTERNAL MANIFOLD LEAKED FILLING THE OIL PAN UP WITH WATER WHICH IN TURN FROZE THE MAIN BEARINGS TO THE CRANKSHAFT, CAUSING THE VEHICLE TO LOCK UP AT 50 MPH. HE SENT IN PREVIOUS LETTER ABOUT THE SAME PROBLEM ON ANOTHER VEHICLE. *KB THE CO…
Read full complaint
1996 PONTIAC TRANSPORT VAN WITH LEAKING INTAKE MANIFOLD GASKETS. CONSUMER STATES THAT THE INTERNAL MANIFOLD LEAKED FILLING THE OIL PAN UP WITH WATER WHICH IN TURN FROZE THE MAIN BEARINGS TO THE CRANKSHAFT, CAUSING THE VEHICLE TO LOCK UP AT 50 MPH. HE SENT IN PREVIOUS LETTER ABOUT THE SAME PROBLEM ON ANOTHER VEHICLE. *KB THE CONSUMER NOTICED A SMELL OF ANTI-FREEZE, BUT COULD NOT LOCATE THE PROBLEM, BECAUSE IT WAS INTERNAL NOT EXTERNAL. *JB
COOLANT MIXING INTO ENGINE OIL DUE TO DEFECTIVE INTAKE MANIFOLD GASKET,WHY IS THERE NO RECALL ON THIS PROBLEM?*JB
VEHICLE STARTED EATING COOLANT, WITHIN 4 DAYS OF COOLANT LEAK HEAD GASKET HAD COMPLETE FAILURE DUMPING CONTENTS OF RADIATOR INTO OIL PAN. UPON EXAM FOUND THAT DEXTROL COOLANT HAD TURNED CORROSIVE AND EATEN THREW GASKET CAUSING FAILURE. REPLACE ALL TOP END GASKETS AND REBUILD TOP END. PRAY THAT LOWER END WILL BE OK ONCE FLUSHED …
Read full complaint
VEHICLE STARTED EATING COOLANT, WITHIN 4 DAYS OF COOLANT LEAK HEAD GASKET HAD COMPLETE FAILURE DUMPING CONTENTS OF RADIATOR INTO OIL PAN. UPON EXAM FOUND THAT DEXTROL COOLANT HAD TURNED CORROSIVE AND EATEN THREW GASKET CAUSING FAILURE. REPLACE ALL TOP END GASKETS AND REBUILD TOP END. PRAY THAT LOWER END WILL BE OK ONCE FLUSHED COMPLETELY. HAVE KEPT OLD PARTS FOR FURTHER EXAM. *NM
INTAKE MANIFOLD & GASKET FAILURE - OIL & COOLANT MIXING IN ENGINE COMPARTMENT - IMMINENT ENGINE FAILURE FRONT WIPER MOTOR/TRANSMISSION INTERMITENT FAILURE WHILE DRIVING - DIFFICULTY DIAGNOSING PROBLEM - MAJOR SAFETY ISSUE WHEN THE WIPERS SUDDENLY STOP/START WORKING WHILE DRIVING IN RAIN & SNOW OR SLOPPY HIGHWAY CONDITIONS COMP…
Read full complaint
INTAKE MANIFOLD & GASKET FAILURE - OIL & COOLANT MIXING IN ENGINE COMPARTMENT - IMMINENT ENGINE FAILURE FRONT WIPER MOTOR/TRANSMISSION INTERMITENT FAILURE WHILE DRIVING - DIFFICULTY DIAGNOSING PROBLEM - MAJOR SAFETY ISSUE WHEN THE WIPERS SUDDENLY STOP/START WORKING WHILE DRIVING IN RAIN & SNOW OR SLOPPY HIGHWAY CONDITIONS COMPRESSOR CLUTCH HUB & PULLEY FAILURE
FAILURE OF THE INTAKE MANIFOLD GASKET.
AFTER THE 2ND VALVE SPRING BROKE, I WAS TOLD THAT THE VALVES WERE SEIZING UP AND A NEW ENGINE WOULD BE REQUIRED. ALL OF THIS WAS CAUSED BY THE BAD DESIGNED MANIFOLD GASKET THAT CAUSED COOLANT TO GO INTO THE OIL. AFTER SPENDING OVER $1,000 SINCE 4-29-03, I FINALLY HAD TO TRADE IN FOR ANOTHER VEHICLE. I DIDN'T HAVE BETWEEN $4,00…
Read full complaint
AFTER THE 2ND VALVE SPRING BROKE, I WAS TOLD THAT THE VALVES WERE SEIZING UP AND A NEW ENGINE WOULD BE REQUIRED. ALL OF THIS WAS CAUSED BY THE BAD DESIGNED MANIFOLD GASKET THAT CAUSED COOLANT TO GO INTO THE OIL. AFTER SPENDING OVER $1,000 SINCE 4-29-03, I FINALLY HAD TO TRADE IN FOR ANOTHER VEHICLE. I DIDN'T HAVE BETWEEN $4,000 AND $5,000 FOR A NEW ENGINE, WHICH ON A '96 MODEL WOULD NOT HAVE BEEN WORTH IT. I COULD HAVE GOTTEN A USED ENGINE, BUT ALL OF THEM HAVE THE SAME MANIFOLD GASKET AND THIS WOULD HAVE COST APROXIMATELY $2,000. I'VE HAD NOTHING BUT PROBLEMS WITH THIS VAN. GENERAL MOTORS SHOULD HAVE TAKEN CARE OF THIS AS A RECALL, BUT I GUESS IT WAS TOO EXPENSIVE FOR THEM TOO.
EXCESSIVE CONSUMPTION OF COOLANT. REPAIR SHOP TOLD US COOLANT WAS BEING SUCKED INTO INTAKE MANIFOLD. REPLACED GASKET AND CONVERTED FROM ORANGE TO GREEN COOLANT. *NLM
COOLANT IN OIL DUE TO MANIFOLD INTAKE GASKET..HAD GASKET REPLACED AND IS BACK IN THE SHOP AGAIN FOR SAME PROBLEM. IN BETWEEN THESE TWO TOWINGS, I HAD TO HAVE THE VALVE SPRING REPLACED BECAUSE IT BROKE. *NLM
FAULTY INTAKE MANIFOLD GASKET ON 1996 PONTIAC TRANSPORT. *JB
Official recalls
102V286000 · Steering:rack And Pinion
Nov 4, 2002
CERTAIN PASSENGER VEHICLES AND MINI VANS HAVE LOWER PINION BEARINGS IN THE POWER RACK AND PINION ASSEMBLY IN WHICH THE RETAINER TABS WERE NOT CRIMPED PROPERLY. THESE AND SOME OTHER RETAINERS USED IN VEHICLES ASSEMBLED BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997, COULD FAIL AND PERMIT THE BALL BEARINGS TO ESCAPE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE PINION SHAFT CAN BE FORCED UPWARD DURING LEFT TURNS AND BACK DOWN AS THE STEERING WHEEL IS MOVED BACK AND TO THE RIGHT. IF THE PINION SHAFT MOVES FURTHER, THE DRIVER WILL NEED TO EXERT MORE EFFORT TO TURN THE STEERING WHEEL, SIMILAR TO A VEHICLE WITHOUT POWER ASSISTED STEERING. IF THE PINION SHAFT MOVES EVEN FURTHER, THE DRIVER WILL REQUIRE MUCH HIGHER EFFORT TO TURN LEFT AND MAY NOT BE ABLE TO TURN THE WHEEL AS MUCH AS INTENDED. WITH THE MAXIMUM PINION SHAFT MOVEMENT, WHICH REQUIRES INTERNAL GEAR COMPONENT DAMAGE, THE DRIVER CAN ENCOUNTER HIGH RESISTANCE TO TURNING LEFT, FOLLOWED BY UNINTENDED POWER ASSIST TO THE RIGHT. IN ANY OF THESE CONDITIONS, A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW LOWER PINION BEARING UNLESS INSPECT OF THE EXISTING BEARING INDICATES THAT REPLACEMENT OF THE GEAR ASSEMBLY IS NECESSARY. OWNER NOTIFICATION BEGAN JANUARY 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, OR OLDSMOBILE AT 1-800-442-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.