THE WALMART DOUGLAS BRAND PASSENGER CAR TIRES HAVE NUMEROUS COMPLAINTS FOUND ALL OVER THE INTERNET. THE DOUGLAS TIRE I PURCHASED IN 10/13 HAS NOW DEVELOPED A NOTICEABLE BULGE ON THE SIDE WALL UNDERNEATH THE TIRE VALVE STEM AREA. HOWEVER, WALMART REFUSES TO REPLACE THE DEFECTIVELY MANUFACTURED TIRE EVENTHOUGH I EXPLAINED TH…
Read full complaint
THE WALMART DOUGLAS BRAND PASSENGER CAR TIRES HAVE NUMEROUS COMPLAINTS FOUND ALL OVER THE INTERNET. THE DOUGLAS TIRE I PURCHASED IN 10/13 HAS NOW DEVELOPED A NOTICEABLE BULGE ON THE SIDE WALL UNDERNEATH THE TIRE VALVE STEM AREA. HOWEVER, WALMART REFUSES TO REPLACE THE DEFECTIVELY MANUFACTURED TIRE EVENTHOUGH I EXPLAINED THAT IF I HAD NOT NOTICED THE BULGE, THE TIRE COULD OF BLOWN ON THE FWY AND COST ME MY LIFE. BUT THE EMPLOYEE SAID, SORRY.. I ASKED THE EMPLOYEE HOW OLD WAS THE TIRE AT THE TIME I PURCHASED IT. BUT HE COULD SAY. AT THE TIME OF INSTALLATION, THE WALMART MECHANIC / EXPERT WOULD OF NOTICED THE BULGE WHICH WAS MINOR AT THE TIME, AS I HAD NOTICED BUT THOUGHT NOTHING OF IT SINCE I AM NOT AN EXPERT. AS THIS WAS THE ONLY TIRE SIZE MY WALMART STORE HAD IN STOCK FOR MY CAR, I PURCHASED IT WITHOUT CONSIDERATION OF BRAND. IN OTHER WORDS, I WOULD OF BOUGHT A DIFFERENT BRAND TIRE IF THE SHELVES HAD IN MY SIZE. FURTHER, I BELIEVE WALMART IS AWARE OF ITS DEFECTIVE TIRE'S WHICH I DISCOVERED TODAY THAT THEY ARE MADE IN CHINA. SUPPOSEDLY, DOUGLAS TIRE IS A SUBSIDIARY OF GOODYEAR. SO I HAVE EMAILED THEM WITH MY CONCERN AND REQUEST FOR ASSISTANCE. HOWEVER, I BELIEVE WALMART SHOULD BE HELD ACCOUNTABLE FOR KNOWINGLY SELLING A POORLY MANUFACTURED PRODUCT FOR AUTOMOBILES. EVIDENCE OF THE UNSAFE TIRES ARE POSTED ALL OVER THE INTERNET. *TR
NHTSA ODI #10662547
125,000 miles · Nov 4, 2013
StructureSuspensionWheels
I WAS BACKING UP SLOWLY OUT OF A PARKING SPOT. AS I TURNED ME WHEEL TO THE RIGHT, I HEARD A VERY LOUD NOISE. IT SOUNDED LIKE A POP OR A CRACK. IT WAS MIDNIGHT SO I COULDN'T SEE ANYTHING WRONG WHEN I INSPECTED MY VEHICLE. AS I WAS DRIVING HOME I HEARD A LOUD SCRAPING SOUND. AS I WOULD BREAK IT GOT LOUDER AND LOUDER. IT WAS SCRAPI…
Read full complaint
I WAS BACKING UP SLOWLY OUT OF A PARKING SPOT. AS I TURNED ME WHEEL TO THE RIGHT, I HEARD A VERY LOUD NOISE. IT SOUNDED LIKE A POP OR A CRACK. IT WAS MIDNIGHT SO I COULDN'T SEE ANYTHING WRONG WHEN I INSPECTED MY VEHICLE. AS I WAS DRIVING HOME I HEARD A LOUD SCRAPING SOUND. AS I WOULD BREAK IT GOT LOUDER AND LOUDER. IT WAS SCRAPING AND TEARING. I GOT HOME AND STILL COULDN'T SEE ANYTHING. I CHECKED THE NEXT DAY AND I NOTICED THAT THE FRONT DRIVERS SIDE COIL WAS COMPLETELY CRACKED. BECAUSE OF THIS CRACKED COIL, THE PROTRUDING PIECE OF METAL FROM THE COIL WAS JAMMED AND RESTING ON THE TIRE WALL. BECAUSE OF HAVING TO DRIVE THE VEHICLE HOME, THE COIL HAS TORN AND RIPPED UP MY TIRE WALL AND I AM AFRAID TO DRIVE IT. THIS HAS HAPPENED TO ME BEFORE WITH A CRACKED COIL ON THE OPPOSITE SIDE OF MY VEHICLE ON THE PASSENGER SIDE. THIS IS CRAZINESS AND COMPLETELY UNSAFE! I FEAR FOR MY LIFE DRIVING THIS VEHICLE AS IT CLEARLY HAS A MANUFACTURING DEFECT. I AM BAFFLED AS TO WHY THERE IS NO POSTED RECALL FOR THIS HAZARDOUS PRODUCT. PONTIAC SHOULD BE ASHAMED FOR LETTING THIS GO AND NOT ADMITTING THEIR FAILURE AS A CAR MANUFACTURER. *TR
NHTSA ODI #10550850
58,000 miles · Feb 22, 2006
SuspensionWheels
DT*: THE CONTACT STATED A LOUD POP FROM THE GARAGE WAS HEARD WHILE IN THE HOUSE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP. THE PASSENGER SIDE FRONT COIL SPRING HAD BROKEN. THE FRONT COIL SPRING AND BOTH FRONT STRUTS WERE REPLACED. ALSO, THE TIRES ON THE VEHICLE WERE REPLACED A YEAR AND A HALF AGO. THE AIR MUST B…
Read full complaint
DT*: THE CONTACT STATED A LOUD POP FROM THE GARAGE WAS HEARD WHILE IN THE HOUSE. THE VEHICLE WAS TOWED TO AN INDEPENDENT REPAIR SHOP. THE PASSENGER SIDE FRONT COIL SPRING HAD BROKEN. THE FRONT COIL SPRING AND BOTH FRONT STRUTS WERE REPLACED. ALSO, THE TIRES ON THE VEHICLE WERE REPLACED A YEAR AND A HALF AGO. THE AIR MUST BE REFILLED IN THE TIRES EVERY 4-6 WEEKS. THE TIRE DEALERSHIP STATED IN ORDER TO REMEDY THE PROBLEM THE ENTIRE WHEEL ASSEMBLY WOULD HAVE TO BE REPLACED. UPDATED 3/20/2006 - *NM
NHTSA ODI #10150946
Mileage unknown · May 11, 2004
Wheels
THE VEHICLE HAD LIMITED EDITION ALLOY RIMS THAT CRACKED ALL FOUR HUB CAPS AND CAUSED A TIRE TO SEPARATE WHILE DRIVING. *JB *SC *JB
NHTSA ODI #10064771
11,000 miles · Jun 25, 2003
Electrical SystemEngine And Engine CoolingEquipment
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE …
Read full complaint
1999 PONTIAC GRAND AM 2.4 L AUTO SEVERE BRAKE FAILURE---REPLACEMENT OF PADS 8 TIMES, ROTORS 3 TIMES AND CALIPERS 2 TIMES IN 80,000 MILES. BRAKES OCCASIONALLY LOCK UP AND MAKE LOUD GRINDING AND SQUEALING NOISES STEERING SHUDDERS AND VEHICLE PULLS TO LEFT.. PARTICIPATING PONTIAC DEALER FAILED TO FIX THIS PROBLEM SINCE PURCHASE AT 11,000 MILES. UNDER WARRANTY REPLACEMENT IT HAS HAD 6 DOOR PANELS DUE TO PEELING LEATHER ON TOP OF PANEL, 5 GEAR SHIFTERS DUE TO DEALERS IMPROPER INSTALLATION, 2 FACTORY CD/RADIO FAILURES, 1 RACK AND PINION UNIT, 2 FRONT STRUT ASSEMBLIES DUE TO KNOCKING NOISE FROM FRONT OF CAR (WENT BAD AFTER 10,000 MILES USE), PROBLEM WITH HESITATION AT IDLE-COLD START(UNSUCCESSFULLY DIAGNOSED BY DEALER) CARPET LOOSE IN TRUNK AROUND LATCH ASSEMBLY(TOO SHORT FOR TRUNK AND WAS HOT GLUED TO BACK WALL OF CAR BY DEALER INSTEAD OF REPLACEMENT). TURN SIGNALS STILL OCCASIONALLY FAIL TO WORK(DEALER SAID THEY WORKED JUST FINE) BATTERY CONNECTION IN FACTORY BATTERY BROKE LOOSE SPILLING CORROSIVE BATTERY ACID ALL OVER AROUND BATTERY TRAY AREA. ALL FOUR WHEEL COVERS HAVE BEEN REPLACED BECAUSE OF "PIE PAN" NOISE WHEN YOU HIT A BUMP (NEW ONES DID NOT FIX PROBLEM). AFTER WARRANTY WAS UP PONTIAC' CARE HOTLINE OR THE DEALER COULD "CARE " LESS THAT AFTER DOZENS OF TRIPS FOR REPAIRS THE DEALER STILL DIDN'T FIX THE CAR WHILE IT WAS STILL UNDER WARRANTY. SINCE THEN,BESIDES THE UNREPAIRED ITEMS ON MY CAR, THE ALTERNATOR WENT BAD AT 60,000 MILES ($120), GLASS IN INTERIOR REAR VIEW MIRROR BROKE WHILE ADJUSTING, BOTH OUTSIDE REAR VIEW MIRRORS HAVE BROKE OFF IN TWO DIFFERENT AUTOMATIC CAR WASHES (HELD INTO DOOR BY A STUD MOUNTED INTO 1/4 INCH OF PLASTIC IN THE MIRROR). AND THE IGNITION SWITCH FAILED AT 75,000 MILES($300). FOG LIGHTS AND BACKUP LIGHTS HAVE WATER CONDENSATION IN THEM SHORTING OUT BULBS. SURPRISINGLY ,THIS CAR IS "BABIED" ,BUT BY IN MY DESCRIPTION YOU SURE COULDN'T TELL IT. *NLM
NHTSA ODI #10023794
Mileage unknown · May 16, 2002
Wheels
CONSUMER STATES THERE IS A SQUEAKING NOISE COME FROM THE FRONT WHEELS WHILE DRIVING. MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*JB
NHTSA ODI #8009987
Mileage unknown · Nov 1, 2001
Wheels
THE WHEELS MAKE A RUBBING SOUND WHEN THE CAR IS TURNING OR COMING TO A STOP. THE DEALER SAID THAT THE TIRE CASING WAS RUBBING THE EDGE OF THE WHEEL RIM. SIMILAR TO THE CONSUMER COMPLAINT #ODI ID 885314. THE WAY IT WAS PRESENTED TO ME WAS THAT THE TIRE CASING WAS PHYSICALLY RIDING ON THE WHEEL RIM. THIS SEEMS LIKE A SAFETY CO…
Read full complaint
THE WHEELS MAKE A RUBBING SOUND WHEN THE CAR IS TURNING OR COMING TO A STOP. THE DEALER SAID THAT THE TIRE CASING WAS RUBBING THE EDGE OF THE WHEEL RIM. SIMILAR TO THE CONSUMER COMPLAINT #ODI ID 885314. THE WAY IT WAS PRESENTED TO ME WAS THAT THE TIRE CASING WAS PHYSICALLY RIDING ON THE WHEEL RIM. THIS SEEMS LIKE A SAFETY CONCERN. THE DEALER AND GM HAVE SAID THERE IS NO FIX FOR THIS PROBLEM. MY CONCERN IS THAT IF THE TIRES ARE RUBBING ON THE WHEEL RIM IN CERTAIN EXTREME CONDITIONS THIS COULD CAUSE THE TIRE BEAD TO BREAK AND THE TIRE LOSE ALL IT'S AIR, AND CAUSE A SERIOUS ACCIDENT. I HAVE TRIED TO GET GM TO FIX THIS, BUT THEY HAVE STATED THERE IS NO FIX FOR THE PROBLEM. *AK
NHTSA ODI #754001
Mileage unknown · Apr 6, 2001
TiresWheels
TURNING RIGHT OR LEFT VEHICLE MAKES NOISE. IT FEELS LIKE RIM IS OVER LAPPING OR TIRES IN FRONT SEEM TOO BIG. VEHICLE HAS BEEN AT DEALER 6-7 TIMES. DEALER DIDN'T THINK IT WAS AN ISSUE. THEY HAVE SCRAPED AND PAINTED RIMS, THINKING IT WILL CORRECT IT. *AK THE DEALER WAS UNABLE TO FIX THE PROBELM AND THE CONSUMER WAS SCARE…
Read full complaint
TURNING RIGHT OR LEFT VEHICLE MAKES NOISE. IT FEELS LIKE RIM IS OVER LAPPING OR TIRES IN FRONT SEEM TOO BIG. VEHICLE HAS BEEN AT DEALER 6-7 TIMES. DEALER DIDN'T THINK IT WAS AN ISSUE. THEY HAVE SCRAPED AND PAINTED RIMS, THINKING IT WILL CORRECT IT. *AK THE DEALER WAS UNABLE TO FIX THE PROBELM AND THE CONSUMER WAS SCARED DRIVING THE VEHICLE. *YH
NHTSA ODI #885314
Mileage unknown · Nov 20, 2000
Wheels
THE HUB CAPS HAVE RATTLED SINCE THE DAY WE BOUGHT IT. WE WERE TOLD IT WAS NOT COVERED BY THE WARRANTY BECAUSE IT WAS CAUSED BY TAKING THEM OFF TOO MUCH AND THAT THERE WAS NOTHING THAT COULD BE DONE TO FIX IT OUTSIDE OF BUYING NEW ONES.*AK
NHTSA ODI #736599
Mileage unknown · Jul 7, 2000
SteeringWheelsCrashInjury
WHILE DRIVING VEHICLE STEERS TO THE RIGHT UNEXPECTEDLY, CAUSING A CRASH. *AK REAR LATERAL LINK BOLT SEPARATED CAUSEING LEFT OUT WARD MOVEMENT OF LEFT REAR WHEEL. THE DRIVER LOST CONTROL AND THE VEHICLE WENT AIRBORNE AND FLIPPED OVER. *YH
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
1999 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration