CAR THE WORST. I'VE SUNK MORE $ IN2 IT THAN SHE COST TO BUY. $15,000 AT LST. HEAD GASKET X2. INTAKE MANIFOLD X2 WINDOW PARTS X2 BRAKES, PADS ROTORS ENGINE REPLACED IN 2009 BY QUACK MECHANIC ON ADVICE FROM A FRIEND CAR 3 MTHS ON LIFT! COST $1000 A YR 2 PASS NYS INSPECTION HAD CATALYTIC CONVERTER & GASKETS REPLACED AFTER I BEGGED …
Read full complaint
CAR THE WORST. I'VE SUNK MORE $ IN2 IT THAN SHE COST TO BUY. $15,000 AT LST. HEAD GASKET X2. INTAKE MANIFOLD X2 WINDOW PARTS X2 BRAKES, PADS ROTORS ENGINE REPLACED IN 2009 BY QUACK MECHANIC ON ADVICE FROM A FRIEND CAR 3 MTHS ON LIFT! COST $1000 A YR 2 PASS NYS INSPECTION HAD CATALYTIC CONVERTER & GASKETS REPLACED AFTER I BEGGED DO IT! CAT WHOLE PROB FOR 31/2 YRS. ERG VALVE SELONOID CHANGED. COILS SPRINGS, STRUT MOUNT(SENSATRAC) STRUT WAS ONLY AFTER I HAD TIRES REPLACED FOR UPTEENTH TIME REALIZING IT WAS CUTTING INTO 1 TIRE DRIVING OUT OF THE SHOP. ANTIFREEZE STILL OOZES OUT REGARDLESS HOW MANY X'S WORK DONE ON COOLING SYSTEM. THERMASTAT TWICE FUEL INJECTOR OXYGEN SENSOR ANTIFREEZE RESERVOIR, HOSES MUFFLER REARVIEW MIRROR FELL OFF TWICE TIMING BELT. HEADLIGHTS SEVERAL TIMES REAR LIGHTS. 2 OR 3 BATTERIES. THIS CAR SHOULD RUN LIKE NEW- ALMOST EVERYTHING'S BEEN REPLACED NOPE! WAS TOWED TWICE LAST 2 WEEKS DUE TO COOLANT LOSS OVERHEATING ENGINE STOPPING. INFORMED TODAY AFTER CAR AGAIN OVERHEATED & LOST POWER IT'S PROBABLY INTAKE MANIFOLD & HEAD GASKET, OIL IS DRIPPING FROM SIDES OF ENGINE. COMPUTER AMUCK NOWODOMETER FLASHES 1/2 NUMBERS INSTEAD OF TRUE MILEAGE. ABS? LIGHT MECHANIC STATED ITS A WASTE OF YOUR $ TO REPAIR.... THREE HEAD GASKETS? ANOTHER INTAKE MANIFOLD? HELLO! I'VE MAINTAINED THIS CAR IT IS A LEMON A ROTTON LEMON AT THAT. GM KNOWS THESE ISSUES & DOES NOTHING. IN MICHIGAN CONSUMERS WON A CLASS ACTION LAWSUIT BECAUSE OF THIS. GM SHOULDA RECALLED THIS CAR PERIOD. I WASN'T INFORMED OR SAVVY ENOUGH TO KNOW THIS CARS ISSUES UPON PURCHASE. WHAT MAKES THIS WORSE, I NOW UNDERSTAND MY RIGHTS WERE VIOLATED AS A CONSUMER FOR YEARS! I'M POOR & CAN'T AFFORD ANOTHER CAR DUE TO THIS CAR CONTINUED PROBLEMS COST. I NEED A VEHICLE BUT AM LEFT WITH BUS RIDES TAKING ALMOST 3 HRS ONE WAY TO WORK OR A $35 CAB FARE ONE WAY. AS OF TODAY MY CAR IS TRASH. *TR
NHTSA ODI #10473840
Mileage unknown · Oct 10, 2011
Visibility
THE OUTSIDE SIDE MIRRORS ARE COMING OFF. *KB
NHTSA ODI #10429275
110,000 miles · Jul 29, 2009
Visibility
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT THE WINDOW REGULATORS CONTINUE TO FAIL. HE HEARD A GRINDING NOISE MOMENTS BEFORE THE REGULATORS SNAPPED. THE DEALER WAS NOTIFIED AND REFERRED HIM TO THE MANUFACTURER. THE MANUFACTURER COULD NOT ASSIST BECAUSE THERE WAS NO WARRANTY OR RECALL AVAILABLE. THRO…
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT THE WINDOW REGULATORS CONTINUE TO FAIL. HE HEARD A GRINDING NOISE MOMENTS BEFORE THE REGULATORS SNAPPED. THE DEALER WAS NOTIFIED AND REFERRED HIM TO THE MANUFACTURER. THE MANUFACTURER COULD NOT ASSIST BECAUSE THERE WAS NO WARRANTY OR RECALL AVAILABLE. THROUGH ONLINE RESEARCH, THE CONTACT FOUND MANY CONSUMERS THAT WERE EXPERIENCING THIS SAME FAILURE. WITHIN ONE YEAR, FIVE REGULATORS HAVE FAILED. WITHIN THE LAST 30 DAYS, THREE REGULATORS HAVE SNAPPED. TWO OUT OF THE FIVE REGULATORS WERE REPAIRED AT THE CONTACT'S EXPENSE. THE FAILURE MILEAGE WAS 110,000 AND CURRENT MILEAGE WAS 120,000.
NHTSA ODI #10278669
76,000 miles · Jan 28, 2009
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
HAD ALL WINDOW MECHANISMS REPLACED AFTER ENDURING A WONDERFUL GARBAGE BAG COVER TREATMENT FOR WINDOW BEAUTY ENHANCEMENT LAST WINTER 2007-08. FOUND MY IGNITION REFUSES TO START W/ 1 KEY. I STARTED NOTICING THE SMELL OF ANTIFREEZE. TOOK TO MY MECHANIC OF 22 YEARS. THOUGHT IT WAS A CRACK IN THE ACTUAL CONTAINER WHICH HOUSES ANTIFRE…
Read full complaint
HAD ALL WINDOW MECHANISMS REPLACED AFTER ENDURING A WONDERFUL GARBAGE BAG COVER TREATMENT FOR WINDOW BEAUTY ENHANCEMENT LAST WINTER 2007-08. FOUND MY IGNITION REFUSES TO START W/ 1 KEY. I STARTED NOTICING THE SMELL OF ANTIFREEZE. TOOK TO MY MECHANIC OF 22 YEARS. THOUGHT IT WAS A CRACK IN THE ACTUAL CONTAINER WHICH HOUSES ANTIFREEZE. THIS WAS REPLACED. NOPE. STILL LEAKING. CAR NEVER INDICATED ON PANEL THAT IT WAS ABOVE TEMP & OVERHEATED, STAYED WITHIN THE NORMAL RANGE. THE CAR NEVER ONCE OVERHEATED. MECHANIC COULDN'T FIND THE PROBLEM. SAID IT WAS A FAULTY COMPUTER... INDICATES, TIRES NEED CHECKING, FLASHING LIGHTS, ABS OFF/ON...WHICH BY THE WAY WAS CAUSING ME TO NOT HAVE MY CAR PASS INSPECTION TO ADD INSULT TO INJURY!! FOUND I WAS ALL OF A SUDDEN REPLACING ANTIFREEZE BY THE GALLONS. WAS STILL PAYING OFF MECHANIC FROM PREVIOUS ISSUES. DON'T ASK, WHILE TRYING TO FIGURE OUT THE ANTIFREEZE PROBLEM! BROUGHT CAR IN TO HAVE RADIATOR CHECKED BY FRIENDS MECHANIC, FLUID WAS LITERALLY POURING OUT OF BOTTOM OF CAR. $1600. LATER!! HEAD GASKET SET,WATERPUMP,SERPENTINE BELT, RADIATOR HOSES, THERMOSTAT & GASKETS, CROSSOVERPIPES, AIRFILTER...NOW? 1 1/2 MONTHS LATER? WELL HEY.GUESS WHAT? RIDING MERRILY TO WORK LAST SAT. CAR STALLED ALL THE WAY...& YIPEE ANOTHER VISIT, ANOTHER MERE 900. BAG OF SHELLS CONSISTING OF CRANK SHAFT, BEARINGS. CAN YOU BELIEVE IT? I DON'T HAVE IT!!.....I THOUGHT THIS GUY WAS PUTTING ME ON...I'VE LOST WORK SINCE I'M 45 MIN. AWAY. I'VE SPOKEN TO PONTIAC SEVERAL TIMES. THEY WANT NOTHING TO DO WITH THIS. ACT DUMB- THE AMERICAN WAY...WEIRD, I'VE READ MORE COMPLAINTS ABOUT THIS ISSUE, I'M SURPRISED YOU GUYS DON'T DEMAND SOME RESOLUTION FOR CONSUMERS. WHAT GIVES? IT'S SO INCREDIBLY OBVIOUS THIS IS A REAL SOLID COMPLAINT ABOUT ENGINE DEFECT WITH ALL THE EVIDENCE TO BACK IT UP!! I THINK IT WAS MINNISOTA OR MISSOURI THAT CONSUMERS ACTUALLY WON A CLASS ACTION SUIT AGAINST PONTIAC FOR THESE SPECIFIC COMPLAINTS. NAMELY HEAD GASKET, ENGINE RELATED ISSUES.. *TR
NHTSA ODI #10256670
110,000 miles · Oct 25, 2008
Visibility
WINDOWS ON BOTH DRIVER SIDE AND PASSENGER SIDE FALL IN DOOR. *TR
NHTSA ODI #10246687
109,356 miles · Aug 31, 2008
Visibility
A MONTH AFTER I BOUGHT THE CAR THE DRIVER SIDE WINDOW JUST FELL INTO THE DOOR WITHOUT WARNING.2 WEEKS AFTER THAT MY PASSENGER SIDE FELL INTO THE DOOR. *TR
NHTSA ODI #10240482
107,000 miles · May 26, 2008
Service Brakes, HydraulicVisibility
I BOUGHT A 1999 GRAND AM GT N JANUARY 2008 FROM FEYER FORD IN WILLIAMSTON NORTH CAROLINA. WITHIN THE FIRST MONTH THE ROTORS AND BRAKES WENT OUT FOLLOWED BY THE IGNITION SWITCH FOLLOWED BY THE PASSENGER WINDOW REGULATOR GOING OUT. THEN ABOUT A WEEK LATER THE DRIVER SIDE WINDOW REGULATOR WENT OUT. I WANT TO KNOW IF THERE IS A RECA…
Read full complaint
I BOUGHT A 1999 GRAND AM GT N JANUARY 2008 FROM FEYER FORD IN WILLIAMSTON NORTH CAROLINA. WITHIN THE FIRST MONTH THE ROTORS AND BRAKES WENT OUT FOLLOWED BY THE IGNITION SWITCH FOLLOWED BY THE PASSENGER WINDOW REGULATOR GOING OUT. THEN ABOUT A WEEK LATER THE DRIVER SIDE WINDOW REGULATOR WENT OUT. I WANT TO KNOW IF THERE IS A RECALL ON THE WINDOW REGULATORS FOR MY VEHICLE IF NO THEN ONE SHOULD BE MY STEPSONS GIRLFRIENDS WINDOW REGULATOR WENT OUT ON HER PONTIAC GRAND AM ALSO. *TR
NHTSA ODI #10228913
91,900 miles · Feb 2, 2007
Visibility
THE WINDOW REGULATOR FAILS EVERY 18 MONTHS OR SO. I'VE REPLACED THE DRIVER'S SIDE THREE TIMES, AND THE PASSENGER SIDE ONCE. IT'S ABOUT $300 EACH TIME, WITH LABOR. THIS SAME COMPLAINT IS UBIQUITOUS ON EVERY WEBSITE THAT LISTS CUSTOMER COMPLAINTS. PONTIAC SHOULD HAVE DONE A RECALL ON THIS PROBLEM LONG AGO, AND SHOULD STILL DO IT N…
Read full complaint
THE WINDOW REGULATOR FAILS EVERY 18 MONTHS OR SO. I'VE REPLACED THE DRIVER'S SIDE THREE TIMES, AND THE PASSENGER SIDE ONCE. IT'S ABOUT $300 EACH TIME, WITH LABOR. THIS SAME COMPLAINT IS UBIQUITOUS ON EVERY WEBSITE THAT LISTS CUSTOMER COMPLAINTS. PONTIAC SHOULD HAVE DONE A RECALL ON THIS PROBLEM LONG AGO, AND SHOULD STILL DO IT NOW. BELOW, I'M LISTING ONLY THE MOST RECENT DATE. *NM
NHTSA ODI #10181427
Mileage unknown · May 18, 2006
Visibility
POWER WINDOW REGULATOR FAILS CAUSING WINDOW TO FALL INTO DOOR. *JB
NHTSA ODI #10157811
59,009 miles · Mar 6, 2006
Electrical SystemEngine And Engine CoolingExterior Lighting
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE ENGINE'S HIGH PERFORMANCE ADDITIVE CAUSED CORROSION TO THE ALUMINUM CYLINDER HEAD. THE CYLINDER HEAD WAS REPLACED WHICH CORRECTED THE PROBLEM. UPD…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS THE ENGINE OVERHEATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. THE MECHANIC DETERMINED THE ENGINE'S HIGH PERFORMANCE ADDITIVE CAUSED CORROSION TO THE ALUMINUM CYLINDER HEAD. THE CYLINDER HEAD WAS REPLACED WHICH CORRECTED THE PROBLEM. UPDATED 3/28/2006 - THE WATER PUMP FAILED. THE BATTERY AND BRAKES FAILED. THE COOLANT LIGHT ILLUMINATED. THE DEALER DETERMINED THAT THE ANTIFREEZE HAD CONGEALED AND NEEDED TO BE FLUSHED AND REPLACED. THE DRIVER SIDE HEADLIGHT WENT OUT. THE DRIVER SIDE WINDOW REGULATOR BROKE. *NM
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
1999 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration