NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
32 reportsClear category filter30,000 miles · Jan 6, 2003
Electrical SystemEngine And Engine CoolingEquipment
I HAVE HAD TO HAVE THE FOLLOWING REPAIRED: THE FAN REPLACED 2 TIMES, THE BRAKES REPAIRED 4 TIMES, THE RADIO REPLACED ONCE, THE WATER PUMP REPLACED ONCE AND THE BATTERY REPLACED TWICE. I AM ALSO HAVING PROBLEMS WITH THE TRANSMISSION IT HAS BEEN SLIPPING. THE INTAKE GASKET NEEDS TO REPLACED BECAUSE ANTIFREEZE IS LEAKING OUT AND…
Read full complaint
I HAVE HAD TO HAVE THE FOLLOWING REPAIRED: THE FAN REPLACED 2 TIMES, THE BRAKES REPAIRED 4 TIMES, THE RADIO REPLACED ONCE, THE WATER PUMP REPLACED ONCE AND THE BATTERY REPLACED TWICE. I AM ALSO HAVING PROBLEMS WITH THE TRANSMISSION IT HAS BEEN SLIPPING. THE INTAKE GASKET NEEDS TO REPLACED BECAUSE ANTIFREEZE IS LEAKING OUT AND ONE OF THE LIFTERS IS KNOCKING. MOST OF THESE PROBLEMS STARTED AT ABOUT 30,000 MILES AND GRADUALLY THERE WAS JUST ONE PROBLEM AFTER ANOTHER. I TOOK IT IN TO THE DEALERSHIP FOR THE TRANMISSION AT ABOUT 32,000 MILES AND SINCE THE DEALERSHIP COULDN'T GET IT TO SLIP THEY WOULDN'T DO ANYTHING ABOUT IT. THE BRAKES STARTED HAVING PROBLEMS AT 40,000 MILES. I CALLED GM TO COMPLAIN ABOUT THE CAR AND GM TOLD ME THERE WAS NOTHING THEY COULD DO BECAUSE IT WAS OUT OF WARRANTY. IF IT WAS STILL UNDER WARRANTY THEY WOULD REPLACED THE ROTORS BECAUSE THE ROTORS WERE TO THIN WHEN THE CAR WAS MANUFACTURED. I WONDER WHY NO RECALL WAS SENT OUT ON THIS. THE BRAKES ARE AN IMPORTANT PART OF A CAR. THE BATTERY, RADIO AND FAN WERE REPLACED AT ABOUT 30,000 ALSO. THEN THE FAN WAS REPLACED AGAIN AT ABOUT 70,000. THE INTAKE STARTED GIVING ME PROBLEMS THAT ABOUT 90,000. THE SECOND BATTERY WAS INSTALLED AT ABOUT 95,000. THE LIFTER STARTED HAVING PROBLEMS AT ABOUT 110,000. THE TRANSMISSION HAS SLIPPED EVER SINCE I GOT THE CAR.
NHTSA ODI #10000556
Mileage unknown · Aug 27, 2002
Power Train
MEDAL SHAVINGS IN TRANSMISSIONS HAD PROBLEM UNDER WARRETEY AND WAS FIX, WE THINK,SHOULD NOT HAVE TO PAY FOR THIS PROBLEM WHEN WE BELIEVE THE PROBLEM WAS NEVER FIX RIGHT THE FIRST TIME. WE'LL NEVER EVER WILL OWN A PONTIC AGAIN AND WILL BE GETTING RID OF IT IF WE CAN AND WILL NOT TALK VERY WELL OF ANY PONTIAC .*AK
NHTSA ODI #766292
Mileage unknown · Jun 12, 2002
Power Train
TRANSMISSION HAS BEEN SLIPPING SINCE I BOUGHT CAR. A SERVICE DEPT. WORKER TAKING ME BACK TO WORK POINTED IT OUT. WHEN YOU PUT IT IN REVERSE IT TAKES A FEW SECONDS FOR IT TO GO INTO GEAR. IN THE WINTER IT IS VERY HARD TO GET OUT OF PARK. THE DEALERSHIP TOLD ME THIS WAS NORMAL, BUT I HAD NEVER HAD THIS HAPPEN IN ANY OTHER CAR …
Read full complaint
TRANSMISSION HAS BEEN SLIPPING SINCE I BOUGHT CAR. A SERVICE DEPT. WORKER TAKING ME BACK TO WORK POINTED IT OUT. WHEN YOU PUT IT IN REVERSE IT TAKES A FEW SECONDS FOR IT TO GO INTO GEAR. IN THE WINTER IT IS VERY HARD TO GET OUT OF PARK. THE DEALERSHIP TOLD ME THIS WAS NORMAL, BUT I HAD NEVER HAD THIS HAPPEN IN ANY OTHER CAR I OWNED. WHEN DRIVING IT SOMETIMES DOES NOT ALWAYS SHIFT WHEN IT IS SUPPOSE TO AND THEN WHEN IT DOES IT SLAMS INTO THE NEXT GEAR. WHEN BACKING OUT OF MY DRIVE AND THEN PUTTING IT INTO DRIVE TO GO DOWN THE DRIVE IT WON'T GO INTO TO GEAR (DRIVE) FOR QUITE AWHILE. I HAVE REPORTED THIS TO DEALERSHIP THEY TOLD ME IT WAS A COMPUTER PROBLEM AND THEY REPROGRAMED IT. WHEN I CALLED PONTIAC THE DEALERSHIP TOLD THEM THAT THEY COULD NOT DUPLICATE THE PROBLEM. BUT TOLD ME IT WAS THE COMPUTER. SO IF I KEEP THIS CAR WHAT HAPPENS NOW THAT THERE IS NOT WARRANTY WHEN THE TRANSMISSION FALLS OUT.*AK
NHTSA ODI #762981
Mileage unknown · May 31, 2002
Power TrainSuspension
VEHICLE SHAKES WHEN DRIVING. ALSO, WHEN ACCELERATING AT LOW SPEEDS TRACTION LIGHT COMES ON, AND WHEN GOING OVER A BUMP THERE'S A CLUNKING NOISE. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #8010845
Mileage unknown · Jan 7, 2002
Power Train
INTERMITENTLY VEHICLE WILL JUMP OUT OF PARK. TWICE IT HAS HAPPENED TO VEHICLE, ONCE WITH MOTOR CUT OFF, AND ONCE WHILE MOTOR WAS RUNNING. CONSUMER NOTIFIED DEALER.*AK
NHTSA ODI #8001672
Mileage unknown · Dec 10, 2001
Electrical SystemPower Train
VEHICLE WOULD NOT GO OVER 10 MPH. SPEEDOMETER STOPPED, VEHICLE LOST POWER, AND WAS NOT ABLE TO ACCELERATE. CONSUMER TOOK VEHICLE TO DEALER, AND THEY REPLACED A COMPUTER. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK
NHTSA ODI #6900631
Mileage unknown · Aug 16, 2001
Electrical SystemEngine And Engine CoolingEquipment
CONSUMER HAS EXPERIENCED PROBLEMS WITH RADIO SEVERL TIMES.TD
NHTSA ODI #562550
Mileage unknown · Apr 19, 2001
Electrical SystemPower TrainSteering
WHEN TURNING STEERING WHEEL BACK AND FORTH, NOISE WAS HEARD, MORE NOTICEABLE WHEN TURNING TO THE RIGHT. CONSUMER RETURNED TO DEALERSHIP IN JULY 2000 BECAUSE NOISE WAS STILL PRESENT WHEN DEALERSHIP ORIGINALLY SAID THERE WAS NOTHING WRONG WITH STEERING. A PRIVATE MECHANIC STATED THAT "THUMP" COULD BE EMITTED FROM RACK A…
Read full complaint
WHEN TURNING STEERING WHEEL BACK AND FORTH, NOISE WAS HEARD, MORE NOTICEABLE WHEN TURNING TO THE RIGHT. CONSUMER RETURNED TO DEALERSHIP IN JULY 2000 BECAUSE NOISE WAS STILL PRESENT WHEN DEALERSHIP ORIGINALLY SAID THERE WAS NOTHING WRONG WITH STEERING. A PRIVATE MECHANIC STATED THAT "THUMP" COULD BE EMITTED FROM RACK AND PINION STEERING SYSTEM. PLEASE PROVIDE ANY ADDITIONAL INFORMATION/ATTACHMENTS.*AK THERE IS A 3 TO 6 SECOND DEOAY IN THE TRANSMISSION WHEN ENGAGING FROM REVERSE TO DRIVE, SOMETIMES SLIPPAGE OCCURS MOMENTARILY AFTER THE CAR ENGAGES INTO DRIVE,BATTERY LEAKS CONSOLE LATCH FAILED. NLM
NHTSA ODI #886309
Mileage unknown · Apr 11, 2001
Power TrainSteeringSuspension
ON SERVERAL OCCASIONS I AM HAVING MAJOR FRONT END PROBLEMS, FROM THE INTERMEDIATE SHAFT POPING, TO THE WHOLE FRONT END POPING, THE DEALER REPLACED THE RACK THE CV BOOTS 3 TIMES, THEY KEPT BUSTING, LOWER BALL JOINTS, "A" ARMS, THIS CORRECTED THE PROBLEM FOR A BIT, THEN THE CV BOOT FRACTURED AGAIN THEY WOULDNT REPLACE, NOW THE FRO…
Read full complaint
ON SERVERAL OCCASIONS I AM HAVING MAJOR FRONT END PROBLEMS, FROM THE INTERMEDIATE SHAFT POPING, TO THE WHOLE FRONT END POPING, THE DEALER REPLACED THE RACK THE CV BOOTS 3 TIMES, THEY KEPT BUSTING, LOWER BALL JOINTS, "A" ARMS, THIS CORRECTED THE PROBLEM FOR A BIT, THEN THE CV BOOT FRACTURED AGAIN THEY WOULDNT REPLACE, NOW THE FRONT IN POPS HORRIABLY WHEN YOU MAKE A TURN TO THE RIGHT AND ADD A LITTLE TORQUE, TOOK TO DEALER, NO DIAGONSIS, TOOK TO AN INDEPENDENT AGENT, EVERYTHING SEEMS FINE, ONLY THING HE CAN THINK OF IS A BREAK IN A SPOT WELD ON THE FRONT END, IE THE TUBING THAT SUPPORTS THE ENGINE AND FRONT SUSPENSION, I HAVE EVENT CONTACTED PONTIAC CUSTOMER CARE CENTER AND THEY SAY THE PROBLEM IS NO LONGER THERES, I WOULD BE HAPPY TO LET YOU TEST THE CAR AND HEAR THE NOISE, AND SEE IF IT WOULDNT MAKE YOU A TAD BIT UNEASY ABOUT DRIVING IT
NHTSA ODI #743910
Mileage unknown · Mar 29, 2001
Engine And Engine CoolingPower Train
WHILE IN OWNERSHIP OF MY GRAND AM I HAVE EXPERIENCED PROBLEMS WITH THE TRANSMISSION, WHICH HAS ALREADY BEEN REPLACED ONCE AND I AM STILL HAVING THE SAME PROBLEM PLUS NOW EXPERIENCING SMOKE FROM EXHAUST WHILE DRIVING, BOTTOM LINE TOO MANY PROBLEMS FOR A CAR THATS NOT EVEN TWO YEARS OLD YET.*AK
NHTSA ODI #743278
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration