NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
33 reportsClear category filterMileage unknown · Apr 19, 2001
Engine And Engine CoolingFuel System, Gasoline
LOW COOLANT LIGHT ON DASHBOARD CAME ON. CONSUMER ADDED DEX SPECIAL COOLANT TWICE, APPROXIMATELY A HALF GALLON OF 50% WATER/50% COOLANT. PREVIOUSLY, EVERY TIME 3,000 MILE OIL CHANGE INDICATOR LIGHT CAME ON, CONSUMER NOTICED THAT COOLANT LEVEL WAS LOW. THIS TIME, CONSUMER TOOK VEHICLE TO DEALERSHIP , AND FOUND OUT THAT COOLANT…
Read full complaint
LOW COOLANT LIGHT ON DASHBOARD CAME ON. CONSUMER ADDED DEX SPECIAL COOLANT TWICE, APPROXIMATELY A HALF GALLON OF 50% WATER/50% COOLANT. PREVIOUSLY, EVERY TIME 3,000 MILE OIL CHANGE INDICATOR LIGHT CAME ON, CONSUMER NOTICED THAT COOLANT LEVEL WAS LOW. THIS TIME, CONSUMER TOOK VEHICLE TO DEALERSHIP , AND FOUND OUT THAT COOLANT WAS GETTING INTO OIL, CAUSING OIL TO BE A MILKY COLOR. *NOTE: CONSUMER WAS TOLD IT COULD POSSIBLY BE CAUSED BY A DEFECTIVE HEAD GASKET OR MANIFOLD INTAKE. DEALERSHIP IS IN POSSESSION OF VEHICLE.*AK CONSUMER STATES SO FAR THE NEWLY INSTALLED UPPER AND LOWER GASKETS ARE HOLDING, CONSUMER STATES HE HAS SPOKEN TO 3 INDEPENDENT MECHANICS WHO STATE THAT THE PROBLEM IS PROBABLY WITH THE MANIFOLD INTAKE GASKETS AND NOT THE HEAD GASKET, THESE THREE PEOPLE INDICATED THAT THE FAILURE WAS DUE TO IMPROPER TORQUE OF DEFECTIVE GASKETS. *SLC
NHTSA ODI #886306
Mileage unknown · Feb 20, 2001
Fuel System, Gasoline
CONSUMER STATES EVERY SO OFTEN, WHEN STARTING VEHICLE, THERE IS A STRONG FUEL ODOR, ONCE CONSUMER SMELLED FUEL AFTER DRIVING 2 MILES, DEALER STATES THERE IS NO PROBLEMS AND THAT THE SMELL IS NORMAL, CONSUMER ASKED FOR THAT STATEMENT IN WRITING, HOWEVER PONTIAC WOULD NOT PUT IT IN WRITING. *SLC
NHTSA ODI #785295
Mileage unknown · Jan 1, 2001
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
ENGINE SLUGGISH, CAR MISFIRES, ROUGH IDLE. INITIALLY (10/20/99) DEALER SAID IT WAS GAS CAP-REPLACED, 2ND TIME (07/10/00) REPLACED #2 SPARK PLUG & BOOT - CK ENGINE LIGHT ON CODE STORED WAS PO300 CARBON TRACKING ON SIDE OF PLUG; THIRD TIME LAST WK (HAVE NOT DROVE) TAKING TO DEALER THIS WK.
NHTSA ODI #738604
Mileage unknown · Dec 3, 2000
Fuel System, Gasoline
FUEL PRESSURE REGULATOR LEAKS FUEL INTERMITTENTLY (DURING COLD STARTS). *AK
NHTSA ODI #737221
Mileage unknown · Oct 26, 2000
Electrical SystemExterior LightingFuel System, Gasoline
THE REAR BRAKES NEEDED AN ADJUSTMENT, THE BRAKES WERE MAKING A THUMPING NOISE, LATER THERE WAS A NOISE IN THE FRONT END AND THE DEALER FOUND IT TO BE THE FRONT BRAKE PADS. *SLC
NHTSA ODI #556436
Mileage unknown · Sep 22, 2000
Electrical SystemFuel System, GasolineSuspension
FRONT END VIBRATES WHEN GOING OVER SPEED BUMPS.GAS PEDAL GOES DOWN TO THE FLOOR FOR A WHILE BEFORE GRADUALLY GAINING ANY SPEED. DEALER REPLACED COMPUTER & FUEL PUMP TO CORRECT THE PROBLEM, BUT NOTHING HAS HELP.*AK
NHTSA ODI #871264
Mileage unknown · Aug 18, 2000
Fuel System, Gasoline
IN APPROXIMATELY MARCH OF 2000 THE VEHICLE FIRST STALLED WHILE DRIVING IN CITY TRAFFIC GOING APPROXIMATELY 35 MPH. WAS ABLE TO RESTART CAR AND PROCEEDED TO DEALER SERVICE DEPT. TO HAVE CAR CHECKED OUT. THEY PROCEEDED TO INSTALL A BREATHER VALVE THEY FELT WAS FAULTY. APPROXIMATELY 3-4 DAYS LATER, THE VEHICLE STALLED AGAIN. ON THE…
Read full complaint
IN APPROXIMATELY MARCH OF 2000 THE VEHICLE FIRST STALLED WHILE DRIVING IN CITY TRAFFIC GOING APPROXIMATELY 35 MPH. WAS ABLE TO RESTART CAR AND PROCEEDED TO DEALER SERVICE DEPT. TO HAVE CAR CHECKED OUT. THEY PROCEEDED TO INSTALL A BREATHER VALVE THEY FELT WAS FAULTY. APPROXIMATELY 3-4 DAYS LATER, THE VEHICLE STALLED AGAIN. ON THE WAY TO THE DEALER IT STALLED 3 MORE TIMES IN A MATTER OF 2 MILES. THEY DIAGNOSED THE PROBLEM AS BEING A FAULTY FUEL PUMP. TODAY, AUGUST 17, 2000 THE VEHICLE STALLED AGAIN AS I PULLED INTO OUR DRIVEWAY AFTER HAVING DRIVEN 300 MILES. EXPERIENCED EXACT SAME SYMPTOMS AS THE FIRST TIME THE PUMP FAILED. WILL BE CONTACTING DEALER FIRST THING FRIDAY A.M. TO CONFIRM PROBLEM. OF COURSE, VEHICLE IS NO LONGER UNDER WARRANTY BUT WILL DEMAND TO BE REPAIRED AT NO CHARGE.
NHTSA ODI #728319
Mileage unknown · Aug 7, 2000
Fuel System, Gasoline
FUEL PRESSURE REGULATOR WAS LEAKING FUMES INSIDE VEHICLE. DEALER HAS REPAIRED VEHICLE. *AK
NHTSA ODI #866914
Mileage unknown · Jul 11, 2000
Engine And Engine CoolingFuel System, Gasoline
POSSIBLE FUEL INJECTION SYSTEM LEAKING CAUSED SMELL OF GASOLINE IN THE VEHICLE. YH
NHTSA ODI #552966
Mileage unknown · Mar 15, 2000
EquipmentFuel System, GasolineService Brakes, Hydraulic
INTERNAL RADIO FAILURE CAUSING RADIO CLOCK DISPLAY AND LIGHT NOT TO WORK INTERMITTENTLY. NLM
NHTSA ODI #551406
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration