IllustrationTHE HAZARD SWITCH MAKES A NOISE LIKE THE HAZARD LIGHTS ARE FLASHING WHEN THEY AREN'T EVEN ON. TO GET MY BLINKERS TO WORK I HAVE TO PUSH THE HAZARD BUTTON ON AND OFF SEVERAL TIMES.
1999 Pontiac Grand Am
Owner reports · Recalls · Investigations
More warning signs than most Grand Am years
Owner complaints for the 1999 Pontiac Grand Am are substantially higher than the model-year median of 82.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Am years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
5925–50K
6650–75K
7075–100K
43100–150K
13150K+
273 reports with mileage · 576 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes, Hydraulic. Review the 203 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 132 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
73 crash reports13 fire reports48 injury reports
Exterior Lighting complaints
68 reportsWANTED TO KNOW IF YOU HAVE A RECALL FOR THIS INCIDENTS. I HAVE BEEN TO THE DEALER SINCE 2000 AND CONTINUE WITH THE SAME PROBLEMS. THE DASH IS DEFECTED HAS BEEN REPLACED TWICE BECAUSE IT LIFTS UP AND CAN'T SEE THE ROAD VERY WELL. IN PUERTO RICO THE DEALER ROYAL MOTORS DOES NOT SELL PONTIAC ANY MORE. *TR
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT THE TURN SIGNAL SWITCH FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE HAZARD SWITCH AND THE TURN SIGNAL SWITCH NEEDED TO BE REPLACED. ON ANOTHER OCCASION, THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, TH…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT THE TURN SIGNAL SWITCH FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC, WHO DIAGNOSED THAT THE HAZARD SWITCH AND THE TURN SIGNAL SWITCH NEEDED TO BE REPLACED. ON ANOTHER OCCASION, THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE OVERHEATED AND STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE INTAKE MANIFOLD GASKET NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000 AND THE CURRENT MILEAGE 205,000. *TR
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT ACTIVATED THE TURN SIGNAL SWITCH AND NOTICED THE TURN SIGNAL LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MIL…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE CONTACT ACTIVATED THE TURN SIGNAL SWITCH AND NOTICED THE TURN SIGNAL LIGHTING FAILED TO ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. UPON STARTING THE VEHICLE SHE HEARD A CLICKING NOISE COMING NEAR THE HAZARD LIGHT SWITCH. THE CLICKING NOISE SHE HEARD WAS VERY SIMILAR TO THE NOISE YOU CAN HEAR WHEN YOU ACTIVATE THE TURN SIGNALS. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS TURNED ON. THE VEHICLE WAS NOT TAKEN TO …
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. UPON STARTING THE VEHICLE SHE HEARD A CLICKING NOISE COMING NEAR THE HAZARD LIGHT SWITCH. THE CLICKING NOISE SHE HEARD WAS VERY SIMILAR TO THE NOISE YOU CAN HEAR WHEN YOU ACTIVATE THE TURN SIGNALS. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS TURNED ON. THE VEHICLE WAS NOT TAKEN TO BE EXAMINED FOR THE CAUSE OF FAILURE AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT HER VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 03V327000, EXTERIOR LIGHTING:HAZARD FLASHING WARNING LIGHTS:SWITCH. THE FAILURE AND CURRENT MILEAGES WERE 114,000.
I HAVE A 1999 PONTIAC GRAND AM AND EVERYTIME I REPLACE THE BRAKE LIGHT BULBS THEY MELT. *CN
TL* THE CONTACT OWNS 1999 PONTIAC GRAND AM. THE FOG LIGHTS REMAINED ILLUMINATED REGARDLESS IF THE FOG LIGHT SWITCH WAS TURNED ON OR OFF. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN. THE VIN WAS UNAVAILABLE.
THE TURN SIGNAL FLASHER MODULE ON MY DAUGHTERS 1999 GRAND AM GT (54,000 MILES) CONTINUES CLICKING AFTER THE SIGNAL HAS SHUT OFF. AT TIMES THE UNIT HAS CONTINUED TO MAKE THIS NOISE FOR UP TO 15 MINUTES CONSTANTLY. THIS IS EXTREMELY DISTRACTING FOR A TEEN DRIVER. I HAVE LOCATED THE NHTSA ACTION # RQ04005 ON THIS ISSUE. PONTI…
Read full complaint
THE TURN SIGNAL FLASHER MODULE ON MY DAUGHTERS 1999 GRAND AM GT (54,000 MILES) CONTINUES CLICKING AFTER THE SIGNAL HAS SHUT OFF. AT TIMES THE UNIT HAS CONTINUED TO MAKE THIS NOISE FOR UP TO 15 MINUTES CONSTANTLY. THIS IS EXTREMELY DISTRACTING FOR A TEEN DRIVER. I HAVE LOCATED THE NHTSA ACTION # RQ04005 ON THIS ISSUE. PONTIAC HAD PREVIOUSLY CONDUCTED A RECALL OF 2000 MY GRAND AMS FOR THIS ISSUE. THE NHTSA SUMMARY INDICATES PONTIAC AGREED TO REPLACE THE TURN SIGNAL HAZARD FLASHER FOR A PERIOD OF 10 YEARS OR 150,000 MILES. THIS VEHICLE WAS PLACED IN SERVICE 5-12-99 (LESS THAN 9 YEARS AGO). I CONTACTED PONTIAC AND WAS ADVISED THERE WAS A SPECIAL POLICY ON THIS ISSUE #04098 THAT COVERED THE DIAGNOSIS AND REPLACEMENT OF DEFECTIVE PARTS FOR VEH'S WITH IN VIN# RANGE XM893151 - XM 945549. I WAS ADVISED THAT DUE TO MY VEHICLE VIN I WAS NOT COVERED. IT SHOULD BE NOTED THAT I AM NOT THE ORIGINAL OWNER. HOWEVER I HAVE OBTAINED A GM VIS FOR THE VEHICLE WHICH CLEARLY SHOWS SEVERAL EARLIER PROBLEMS WITH THE FLASHER. I DID ADVISE THE PONTIAC REP OF THIS INFO WITH NO RESPONSE. I FEEL THAT IT IS CLEAR THAT MY PROBLEM IS DIRECTLY RELATED TO THE ISSUES IDENTIFIED BY NHTSA IN ACTION #RQ04005. PLEASE HELP. *TR
99 PONTIAC GRAND AM HAZARD FLASHER DEFECTIVE.*CN
I HAVE BEEN READING THE REPORTS ABOUT THE BLINKERS SWITCH AND HOW IT KEEPS CLICKING EVEN WHEN IT ISN'T BEING USED. I HAD THIS PROBLEM. FIRST IT WAS ONLY ONCE IN A WHILE THEN IT GOT TO BE MORE OFTEN. THE SOUND WOULD CLICK ONE OR TWICE AFTER I TURNED OFF THE BLINKER THEN IT WAS TO THE POINT IT WOULDN'T STOP. I CONTACTED THE DEALER…
Read full complaint
I HAVE BEEN READING THE REPORTS ABOUT THE BLINKERS SWITCH AND HOW IT KEEPS CLICKING EVEN WHEN IT ISN'T BEING USED. I HAD THIS PROBLEM. FIRST IT WAS ONLY ONCE IN A WHILE THEN IT GOT TO BE MORE OFTEN. THE SOUND WOULD CLICK ONE OR TWICE AFTER I TURNED OFF THE BLINKER THEN IT WAS TO THE POINT IT WOULDN'T STOP. I CONTACTED THE DEALER AND THEY SAID IT WASN'T PART OF ANY RECALL THAT WAS OUT, BUT TO BRING IT IN. THE MAN THAT LOOKED AT IT SAID THAT IT SOUNDED LIKE MY SWITCH WAS GOING BAD AND NEEDED TO BE REPLACED. I WAS GOING TO HAVE TO SAVE UP THE MONEY TO GET THE PART. AFTER ABOUT TWO WEEKS I WAS DRIVING HOME FROM WORK AND SMELLED SMOKE. I LOOKED DOWN AND MY STEERING WHEEL COLUMN WAS SMOKING. NOT REALLY BAD BUT I WAS FREAKING OUT. I ONLY LIVED A BLOCK AWAY SO I JUST WENT HOME. WHEN I GOT HOME I TOLD MY HUSBAND AND HE WENT OUT AND PULLED THE STEERING WHEEL COLUMN OFF. HE WAS LOOKING AT IT AND SAW THAT THERE WERE 4 POINT TYPE THINGS THAT WERE STICKING TOGETHER. THESE WENT TO THE BLINKER THEY ACTIVATE IT WHEN YOU FLIP THE SWITCH. THE SMOKE WAS FROM THESE TOUCHING. HE FILED THEM DOWN AND PUT MY STEERING COLUMN BACK TOGETHER AND I HAVEN'T HAD THE CLICKING PROBLEM SINCE. SO IT WASN'T MY BLINKER SWITCH AFTER ALL. SOME OF YOU WHO HAVE BEEN HAVING PROBLEMS SIMILAR TO THIS MAY WANT TO CHECK IT OUT. IT MAY JUST SAVE YOU TIME AND MONEY. GOOD LUCK. *JB
Official recalls
314V400000 · Electrical System:ignition
Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
00V140000 · Structure:body
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
98V320000 · Steering: Steering Wheel/handle Bar
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.