NHTSA owner reports · September 18, 2026 snapshot.
Air Bags complaints
76 reportsClear category filter268,500 miles · Jul 26, 2019
Air BagsCrashInjury
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO A CONCRETE BARRIER THAT WAS PUSHED OVER TO THE CONTACT'S LANE, FOLLOWING AN ACCIDENT THAT INVOLVED TWO TRUCKS. THE PASSENGER'S AIR BAG DEPLOYED. NO OTHER AIR BAG DEPLOYED, INCLUDING THE DRIVER'S. THERE WAS …
Read full complaint
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING ABOUT 60 MPH, THE VEHICLE CRASHED INTO A CONCRETE BARRIER THAT WAS PUSHED OVER TO THE CONTACT'S LANE, FOLLOWING AN ACCIDENT THAT INVOLVED TWO TRUCKS. THE PASSENGER'S AIR BAG DEPLOYED. NO OTHER AIR BAG DEPLOYED, INCLUDING THE DRIVER'S. THERE WAS NO WARNING. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED MINOR ABRASIONS ON THE UPPER LEFT SHOULDER AND A BIG BUMP ON THE BACK. THE CONTACT WOULD BE GOING TO THE DOCTORS ATA A LATER POINT IN TIME. THE VEHICLE WAS TOTALED AND WAS TOWED TO A TOW YARD. THE DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS APPROXIMATELY 268,500.
NHTSA ODI #11235024
149,000 miles · May 12, 2016
Air BagsSteeringUnknown Or Other
IGNITION FROZEN, UNABLE TO MOVE VEHICLE WITHOUT TOW. NO SHIFT REALEASE, AND UNSAFE IN THE EVENT OF ENGINE STALL ON OPEN ROADWAYS. VEHICLE IS DEAD ONCE YOU SHIFT INTO PARK TO RESTART.
NHTSA ODI #10864610
115,000 miles · Dec 15, 2014
Air BagsCrash
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE SPUN OUT OF CONTROL AND CRASHED INTO A SIDEWALL. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 11…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE SPUN OUT OF CONTROL AND CRASHED INTO A SIDEWALL. THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10664303
141,000 miles · Nov 5, 2014
Air BagsService BrakesCrash
TL-THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH ATTEMPTING TO AVOID A CRASH, THE POWER BRAKES FAILED CAUSING THE CONTACT TO CRASH INTO A VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS NOT AARE OF ANY INJURIES SUSTAINED OR IF A POLICE REPORT WAS FILED. THE VEHIC…
Read full complaint
TL-THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH ATTEMPTING TO AVOID A CRASH, THE POWER BRAKES FAILED CAUSING THE CONTACT TO CRASH INTO A VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS NOT AARE OF ANY INJURIES SUSTAINED OR IF A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 141,000.
NHTSA ODI #10652809
98,000 miles · Nov 5, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED AND CRASHED INTO A MEDIAN. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED MINOR INJ…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE HYDROPLANED AND CRASHED INTO A MEDIAN. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V400000 (ELECTRICAL SYSTEM). A POLICE REPORT WAS FILED AND THE CONTACT SUSTAINED MINOR INJURIES FROM THE SEAT BELT. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.
NHTSA ODI #10652748
177,000 miles · Oct 28, 2014
Air BagsCrashInjury
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. WHILE DRIVING 25 MPH, THE CONTACT LOST CONTROL ON A SHARP TURN AND CAUSED THE VEHICLE TO FLIP AND CRASH INTO A DITCH. THE FRONT AIR BAGS FAILED TO DEPLOY. THE CONTACT AND THE FRONT PASSENGER WERE INJURED, BUT DID NOT NEED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS…
Read full complaint
TL* THE CONTACT OWNED A 1999 PONTIAC GRAND AM. WHILE DRIVING 25 MPH, THE CONTACT LOST CONTROL ON A SHARP TURN AND CAUSED THE VEHICLE TO FLIP AND CRASH INTO A DITCH. THE FRONT AIR BAGS FAILED TO DEPLOY. THE CONTACT AND THE FRONT PASSENGER WERE INJURED, BUT DID NOT NEED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO A REPAIR FACILITY. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 177,000.
NHTSA ODI #10650737
Mileage unknown · Aug 17, 2014
Air BagsElectrical System
DRIVING DOWN THE ROAD ABS, BATTERY AND AIR BAG LIGHTS COME ON 99-2005 PONTIAC GRAND AMS HAVE A COMMON PROBLEM WITH WATER GOING THROUGH BLOWER MOTOR GOING ON TO THE FLOOR THE AIR BAG MODULE LOCATED UNDER THE CARPET ON THE PASSENGER SIDE GETS WET CAUSING AIR BAG FAILURE THIS IS A SAFETY ISSUE THAT NEEDS ADDRESSED AGAIN A COMMON PR…
Read full complaint
DRIVING DOWN THE ROAD ABS, BATTERY AND AIR BAG LIGHTS COME ON 99-2005 PONTIAC GRAND AMS HAVE A COMMON PROBLEM WITH WATER GOING THROUGH BLOWER MOTOR GOING ON TO THE FLOOR THE AIR BAG MODULE LOCATED UNDER THE CARPET ON THE PASSENGER SIDE GETS WET CAUSING AIR BAG FAILURE THIS IS A SAFETY ISSUE THAT NEEDS ADDRESSED AGAIN A COMMON PROBLEM GENERAL MOTORS HAS KNOWN ABOUT BUT ALL THEY DID WAS CREATE A SERVICE BULLETIN TO FIX WATER LEAK WHICH STILL DOESN'T SAVE AIR BAG IF YOU DON'T CATCH THE LEAK. *TR
NHTSA ODI #10625849
Mileage unknown · Jan 3, 2012
Air BagsCrashInjury
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE FRONT DRIVER'S AIR BAG UNEXPECTEDLY DEPLOYED. THE CONTACT WAS INVOLVED IN A CRASH AS A RESULT. THE CONTACT SUFFERED INJURIES AS A RESULT OF THE AIR BAG DEPLOYMENT AND WAS TAKEN TO THE HOSPITAL FOR TREATMENT. THE VEHICLE WAS DRIVEN HOM…
Read full complaint
TL* THE CONTACT OWNS A 1999 PONTIAC GRAND AM. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE FRONT DRIVER'S AIR BAG UNEXPECTEDLY DEPLOYED. THE CONTACT WAS INVOLVED IN A CRASH AS A RESULT. THE CONTACT SUFFERED INJURIES AS A RESULT OF THE AIR BAG DEPLOYMENT AND WAS TAKEN TO THE HOSPITAL FOR TREATMENT. THE VEHICLE WAS DRIVEN HOME AND THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS UNAVAILABLE.
NHTSA ODI #10442264
16,000 miles · Jun 1, 2011
Air BagsInjury
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 5 MPH, THE FRONT DRIVER SIDE AIR BAG INADVERTENTLY DEPLOYED WITHOUT IMPACT TO THE VEHICLE. THE CONTACT SUSTAINED INJURY TO THE UPPER AND MIDDLE BACK AREA. THE CONTACT WAS ABLE TO RESUME DRIVING. THE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTUR…
Read full complaint
TL*THE CONTACT OWNS A 1999 PONTIAC GRAND AM. WHILE DRIVING APPROXIMATELY 5 MPH, THE FRONT DRIVER SIDE AIR BAG INADVERTENTLY DEPLOYED WITHOUT IMPACT TO THE VEHICLE. THE CONTACT SUSTAINED INJURY TO THE UPPER AND MIDDLE BACK AREA. THE CONTACT WAS ABLE TO RESUME DRIVING. THE FAILURE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000.
NHTSA ODI #10404064
123,000 miles · Sep 7, 2009
Air BagsCrash
CAR ACCIDENT...NO DAMAGE TO BE FOUND ON EITHER CAR, AND MY AIR BAGS DEPLOYED. THERE IS NO SIGN OF AN IMPACT. *TR
NHTSA ODI #10283069
Official recalls
3Jul 3, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2003 Chevrolet Malibu, 2004-2005 Malibu Classic, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.
May 18, 2000
VEHICLE DESCRIPTION: THESE VEHICLES DO NOT COMPLY WITH THE OCCUPANT PROTECTION REQUIREMENTS OF FMVSS NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." THE CONSOLE COVER ON THESE VEHICLES DOES NOT STAY CLOSED WHEN A SPECIFIED VERTICAL LOAD IS APPLIED.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CONSOLE COVER COULD OPEN AND THE COVER OR ITEMS STORED UNDER IT COULD INJURE AN OCCUPANT.
Remedy: DEALERS WILL REPLACE THE CONSOLE LATCH MECHANISM.
Dec 15, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE STEERING WHEEL CAN COME LOOSE FROM THE STEERING SHAFT BECAUSE THE STEERING WHEEL RETAINING NUT COULD HAVE BEEN IMPROPERLY TIGHTENED.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE STEERING WHEEL RETAINING NUT FOR CORRECT TIGHTNESS AND TIGHTEN IF NECESSARY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3RQ04005 · Turn Signal Failures
Opened Jun 18, 2004 · Closed Nov 30, 2004
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Exterior Lighting:turn Signal:switch
GM CONDUCTED A RECALL (NHTSA RECALL NUMBER 03V327) ON MODEL YEAR (MY) 2000-2001 ALERO, GRAND AM AND MALIBU VEHICLES TO REPLACE DEFECTIVE HAZARD SWITCHES THAT CAUSE THE TURN SIGNALS AND HAZARD LIGHTS TO FAIL.THE RECALL COVERED VEHICLES BUILT FROM FEBRUARY 2000 THROUGH MAY 2001 (DEPENDING ON MODEL).ODI OPENED THIS INVESTIGATION BASED ON 64 REPORTS ALLEGING TURN SIGNAL FAILURE ON MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER THE RECALL AND BUILT PRIOR TO FEBRUARY 2000.IN DECEMBER 2004, GM WILL ISSUE A SPECIAL POLICY FOR MY 1999-2000 ALERO, GRAND AM AND MALIBU VEHICLES NOT COVERED UNDER RECALL 03V327.THE POLICY COVERS TURN SIGNAL/HAZARD FLASHER FAILURE FOR A PERIOD OF 10 YEARS OR 150,000 MILES (WHICHEVER OCCURS FIRST) TO PROVIDE A NO COST REPLACEMENT OF THE HAZARD SWITCH.GM WILL SEND LETTERS TO OWNERS STARTING DECEMBER 30, 2004.THE ACTIONS TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FUTURE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA03021 · Front Suspension Coil Spring Fracture
Opened Nov 4, 2003 · Closed Oct 19, 2004
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Suspension:front
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension:front:springs:coil Springs
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
Suspension
THE FAILURE RATE OF THE SUBJECT VEHICLES IS LOW RELATIVE TO PAST ODI INVESTIGATIONS.THE ENGINEERING ANALYSIS IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.PLEASE SEE THE ATTACHED REPORT FOR ADDITIONAL DETAILS.
PE03031 · Front Suspension Coil Spring Fracture
Opened Jul 14, 2003 · Closed Nov 4, 2003
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Additional source detail variants (2)
Suspension:front
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Suspension:front:springs:coil Springs
THE SUBJECT VEHICLES ARE EQUIPPED WITH A COIL SPRING-OVER-STRUT FRONT SUSPENSION WITH THE SPRING ITSELF RESTING IN COMPRESSION BETWEEN TWO POLYMER ISOLATORS.PE03-031 WAS OPENED TO INVESTIGATE REPORTS OF FRACTURE OF THIS SPRING.THE FRACTURES OCCUR IN THE FIRST ACTIVE COIL ABOVE THE LOWER ISOLATOR AND APPARENTLY ORIGINATE IN CORROSION PITS FOUND BENEATH REGIONS OF DAMAGED EPOXY COATING.CONSUMER COMPLAINTS AND WARRANTY DATA SHOW THAT THE FAILURES OCCUR PREDOMINANTLY IN THE ?CORROSION STATES? AND TEND TO APPEAR OUTSIDE OF THE STANDARD 36,000 MILE WARRANTY TERM.THESE DATA ALSO SUGGEST THAT THESE FAILURES WILL CONTINUE TO HAPPEN.SLIGHTLY MORE THAN ONE THIRD OF THE CONSUMER COMPLAINTS HAVE INVOLVED THE BROKEN SPRING COIL CONTACTING THE ADJACENT TIRE.ODI IS UPGRADING PE03-031 TO AN ENGINEERING ANALYSIS TO GATHER FURTHER INFORMATION CONCERNING THE SCOPE AND CONSEQUENCES OF THESE FAILURES.
Illustration