Electrical SystemEngine And Engine CoolingEquipment
PURCHASED CAR NEW AT END OF 97 MODEL YEAR. WITHIN FIRST SIX MONTHS RETURNED CAR SIX TIMES DUE TO DEFECTIVE SWAY BAR BUSHINGS. PROBLEM HAS NEVER BEEN CORRECTED. CAR CLUNKS AS IT IS EITHER TURNED TO THE RIGHT OR LEFT OR TRAVELS (SLOWLY) OVER SPEED BUMPS. ALSO HAVE EXPERIENCED PAINT PEELING FROM OUTSIDE MIRRORS, RADIO VOLUME CONTRO…
Read full complaint
PURCHASED CAR NEW AT END OF 97 MODEL YEAR. WITHIN FIRST SIX MONTHS RETURNED CAR SIX TIMES DUE TO DEFECTIVE SWAY BAR BUSHINGS. PROBLEM HAS NEVER BEEN CORRECTED. CAR CLUNKS AS IT IS EITHER TURNED TO THE RIGHT OR LEFT OR TRAVELS (SLOWLY) OVER SPEED BUMPS. ALSO HAVE EXPERIENCED PAINT PEELING FROM OUTSIDE MIRRORS, RADIO VOLUME CONTROL PROBLEMS, RADIO/CLOCK DISPLAY WORKS ONLY PART OF THE TIME, RIGHT FRONT PASSENGER SEAT MOUNTING BROKE AND SLID PASSENGER INTO DASHBOARD, 2 DOOR SPORT COUPE-BOTH POWER WINDOWS MOTORS HAVE BROKEN AND BEEN REPLACED. THE DRIVER'S SIDE WINDOW JUST BROKE FOR THE SECOND TIME IN TWO YEARS. PASSENGER WINDOW HAS ALSO STARTED TO ACT SLUGGISH. DISCOVERED LEAKY INTAKE MANIFOLD GASKET. ANOTHER EXPENSIVE REPAIR. RAIN LEAKS INTO CAR AROUND WINDOW GASKETS WHICH ALSO MAKE A HISSING SOUND AT SPEEDS OVER 45 MPH. CAR HAS BEEN DRIVEN WITH CARE FOR NINE YEARS(ODOMETER=80,000 MILES) AND HAS HAD OIL CHANGES, TIRE ROTATIONS, ETC. COMPLETED ACCORDING TO SCHEDULE. OWNER CANNOT AFFORD ADDITIONAL COSTLY REPAIRS ESPECIALLY SINCE IT SEEMS TO BE GOING DOWNHILL FROM HERE. DISGUSTED WITH PROBLEMS AS WELL AS WITH LACK OF SERVICE FROM SEVERAL DIFFERENT PONTIAC DEALERS. OWNER CANNOT AFFORD TO BUY A [DECENT] NEW CAR AND WILL HAVE TO PURCHASE SOMETHING USED. MAKE NO MISTAKE- IT WON'T BE A GM PRODUCT! *NM
NHTSA ODI #10169247
Mileage unknown · Aug 28, 2006
Electrical SystemSuspensionVehicle Speed Control
NUMEROUS COMPLAINTS REGARDING A 1997 PONTIAC GRAND AM FOR REPAIRS/ REPLACEMENTS OF PARTS. DOOR WINDOWS DO NOT FUNCTION, MOTOR HAS HAD TO BE REPLACED BY FORMER OWNER, WE HAVE REPAIRED MOTORS ON DOOR WINDOWS SEVERAL TIMES ON OUR OWN, WINDOWS WOULD NOT GO UP AND DOWN AT ALL, COST TO REPAIR AT MECHANICS WAS OVER 400 AND WAS DONE BY…
Read full complaint
NUMEROUS COMPLAINTS REGARDING A 1997 PONTIAC GRAND AM FOR REPAIRS/ REPLACEMENTS OF PARTS. DOOR WINDOWS DO NOT FUNCTION, MOTOR HAS HAD TO BE REPLACED BY FORMER OWNER, WE HAVE REPAIRED MOTORS ON DOOR WINDOWS SEVERAL TIMES ON OUR OWN, WINDOWS WOULD NOT GO UP AND DOWN AT ALL, COST TO REPAIR AT MECHANICS WAS OVER 400 AND WAS DONE BY FIRST OWNER AT LEAST ONCE. CAR SERVICE ENGINE LIGHT COMES ON, HAD TO REPLACE ENTIRE COMPUTER SYSTEM AND NOW SAME PROBLEM IS HAPPENING AGAIN, CAR IDLES HORRIBLY, SOUNDS LIKE IT WILL BE BLOWING UP, AND CHECK ENGINE LIGHT COMES ON. PRIOR TO THE REPLACEMENT OF THE COMPUTER CAR FREQUENTLY STALLED OUT WHILE DRIVING IN MID TURN OR WHILE GOING FORWARD, AND CAR FREQUENTLY WAS DIFFICULT TO START, EVENTUALLY NEEDING TO BE TOWED TO A REPAIR FACILITY WHO HAD TO REPLACE ENTIRE COMPUTER. CAR HAS WHEEL BEARINGS THAT MAKE A LOT OF NOISE, SOUNDS LIKE WHEEL IS GOING TO FALL OFF. CAR HAS ACCELERATED ALL ON ITS OWN WITHOUT THE DRIVER STEPPING ON GAS PEDAL OR DOING ANYTHING AT ALL WITH ACCELERATOR, CAR RANDOMLY DECIDES BY ITSELF TO LUNGE FORWARD AND TRY TO DRIVE ITSELF. THIS STOPPED BRIEFLY AFTER THE COMPUTER WAS REPLACED AND IS NOW HAPPENING AGAIN. *JB
NHTSA ODI #10166688
50,000 miles · Apr 29, 2004
SuspensionCrashInjury
WHILE DRIVING 7 MPH FRONT DRIVER SIDE SUPPORT BRACKET SNAPPED. THIS CAUSED THE VEHICLE TO RUN OFF THE ROAD. DRIVER SUSTAINED BACK INJURIES. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10071813
113,000 miles · Sep 2, 2003
Electrical SystemEngine And Engine CoolingEquipment
WHEN A TURN WAS MADE, THE STEERING WHEEL PRODUCED A LOUD RUBBING NOISE. DEALER NOTIFIED. *AK THERE WERE HIGH IDLE PROBLEMS. THE INTERIOR LIGHTS AND THE POWER LOCKS WERE REPLACED. THE CHECK ENGINE LIGHT HAD COME ON AND THE VEHICLE HAD STARTED TO RUN ROUGH, THE ALTERNATOR LIGHT HAD COME ON AND THE ALTERNATOR WAS REPLACED. TH…
Read full complaint
WHEN A TURN WAS MADE, THE STEERING WHEEL PRODUCED A LOUD RUBBING NOISE. DEALER NOTIFIED. *AK THERE WERE HIGH IDLE PROBLEMS. THE INTERIOR LIGHTS AND THE POWER LOCKS WERE REPLACED. THE CHECK ENGINE LIGHT HAD COME ON AND THE VEHICLE HAD STARTED TO RUN ROUGH, THE ALTERNATOR LIGHT HAD COME ON AND THE ALTERNATOR WAS REPLACED. THE DRIVERS SIDE SEAT BELT DID NOT RETRACT AND WAS REPLACED, THE LOWER FRONT CONTROL ARM WAS REPLACED, THE BLOWER MOTOR WAS REPLACED, THE COMPRESSOR WAS REPLACED, WHEN STARTING THE ENGINE COLD, THERE WAS A KNOCKING SOUND ON THE RIGHT SIDE UNTIL THE VEHICLE WAS WARM ,THEN THE NOISE WOULD GO AWAY, SURGING WOULD ALSO OCCUR AND WOULD WORSEN WHEN THE ENGINE WAS WARMED, THE VOLUME ON THE RADIO WAS ERRATIC(HAD GONE UP WHEN TRYING TO TURN DOWN), THE SENSOR THROTTLE POSITION SHORTED AND WAS INTERMITTENT, THE VALVE AIR CONTROL WAS REPLACED, AND THE FUEL FILTER WAS REPLACED. *SCC *JB
NHTSA ODI #10031249
Mileage unknown · Mar 13, 2003
Suspension
THERE WAS A LOUD NOISE COMING FROM THE REAR OF THE VEHICLE.*JB
NHTSA ODI #10011688
Mileage unknown · Sep 9, 2002
Service Brakes, HydraulicSuspension
FRONT DRIVERS SIDE WHEEL AREA. WHEN BRAKES WERE APPLIED, MADE A THUMPING NOISE. REPLACED DRIVER SIDE LOWER CONTROLL ARM, WAS TOLD IT WAS BAD. 3 OR 4 DAYS AFTER I PICKED UP MY CAR, I NOW HAVE A SINGLE THUMP WHEN I BRAKE AND RELEASE THE BRAKE. THIS NOISE IS SO LOUD AND SCARY SOUNDING THAT I AM ABSOLUTELY AFRAID TO DRIVE THE CAR.…
Read full complaint
FRONT DRIVERS SIDE WHEEL AREA. WHEN BRAKES WERE APPLIED, MADE A THUMPING NOISE. REPLACED DRIVER SIDE LOWER CONTROLL ARM, WAS TOLD IT WAS BAD. 3 OR 4 DAYS AFTER I PICKED UP MY CAR, I NOW HAVE A SINGLE THUMP WHEN I BRAKE AND RELEASE THE BRAKE. THIS NOISE IS SO LOUD AND SCARY SOUNDING THAT I AM ABSOLUTELY AFRAID TO DRIVE THE CAR. IT SOUNDS LIKE MY WHEEL IS READY TO FALL OFF. TAKING THE CAR BACK TO THE SHOP AGAIN TOMORROW. I READ SEVERAL REPORTS ON YOUR WEBSITE REGARDING THIS SAME ISSUE.*AK
NHTSA ODI #766911
Mileage unknown · May 7, 2002
Suspension
STEERING WHEEL IS WHINING AND PULLING VEHICLE TO THE LEFT.AK
NHTSA ODI #8009400
Mileage unknown · Mar 28, 2002
Suspension
CUSTOMER STATES FRONT LOWER CONTROL ARM RUBBER BURSHING WENT OUT, CAUSING A LOT OF NOISE. MECHANIC REPLACED. NLM
NHTSA ODI #8006575
Mileage unknown · Mar 11, 2002
Suspension
WHILE TRAVELING NOTICE A RATTLING NOISE COMING FROM FRONT END. ALSO, STEERING VEHICLE WAS NOT NORMAL. VEHICLE WAS SERVICED, TECHNICIAN REPLACED FRONT END SUSPENSION. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #8005319
Mileage unknown · Apr 12, 2001
Suspension
WHILE DRIVING AT LOW SPEEDS BOTTOM OF FRONT SUSPENSION FAILED, CAUSING RIGHT FRONT WHEEL TO BREAK OFF, AND OTHER DAMAGE. *AK
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
THE PROTECTIVE COVER FOR THE UNDERHOOD FUSE CENTER WAS OMITTED. WITHOUT THIS COVER, THE POSITIVE TERMINAL BOLT ON THE FUSE BLOCK IS EXPOSED AND CAN CONTACT THE INSULATED NEGATIVE BATTERY CABLE. IF THE INSULATION ON THE NEGATIVE CABLE BECOMES SUFFICIENTLY WORN, AN ELECTRICAL SHORT CIRCUIT CAN OCCUR BETWEEN THE POSITIVE TERMINAL AND NEGATIVE CABLE RESULTING IN EXTREMELY HIGH CURRENT FLOW.
Consequence & remedy
Consequence: THIS HIGH CURRENT FLOW CAN CAUSE ARCING AND RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF THE PROTECTIVE COVER AND, IF NECESSARY, INSTALL A PROTECTIVE COVER TO THE UNDERHOOD FUSE CENTER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1997 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration