Electrical SystemEngine And Engine CoolingEquipment
PURCHASED CAR NEW AT END OF 97 MODEL YEAR. WITHIN FIRST SIX MONTHS RETURNED CAR SIX TIMES DUE TO DEFECTIVE SWAY BAR BUSHINGS. PROBLEM HAS NEVER BEEN CORRECTED. CAR CLUNKS AS IT IS EITHER TURNED TO THE RIGHT OR LEFT OR TRAVELS (SLOWLY) OVER SPEED BUMPS. ALSO HAVE EXPERIENCED PAINT PEELING FROM OUTSIDE MIRRORS, RADIO VOLUME CONTRO…
Read full complaint
PURCHASED CAR NEW AT END OF 97 MODEL YEAR. WITHIN FIRST SIX MONTHS RETURNED CAR SIX TIMES DUE TO DEFECTIVE SWAY BAR BUSHINGS. PROBLEM HAS NEVER BEEN CORRECTED. CAR CLUNKS AS IT IS EITHER TURNED TO THE RIGHT OR LEFT OR TRAVELS (SLOWLY) OVER SPEED BUMPS. ALSO HAVE EXPERIENCED PAINT PEELING FROM OUTSIDE MIRRORS, RADIO VOLUME CONTROL PROBLEMS, RADIO/CLOCK DISPLAY WORKS ONLY PART OF THE TIME, RIGHT FRONT PASSENGER SEAT MOUNTING BROKE AND SLID PASSENGER INTO DASHBOARD, 2 DOOR SPORT COUPE-BOTH POWER WINDOWS MOTORS HAVE BROKEN AND BEEN REPLACED. THE DRIVER'S SIDE WINDOW JUST BROKE FOR THE SECOND TIME IN TWO YEARS. PASSENGER WINDOW HAS ALSO STARTED TO ACT SLUGGISH. DISCOVERED LEAKY INTAKE MANIFOLD GASKET. ANOTHER EXPENSIVE REPAIR. RAIN LEAKS INTO CAR AROUND WINDOW GASKETS WHICH ALSO MAKE A HISSING SOUND AT SPEEDS OVER 45 MPH. CAR HAS BEEN DRIVEN WITH CARE FOR NINE YEARS(ODOMETER=80,000 MILES) AND HAS HAD OIL CHANGES, TIRE ROTATIONS, ETC. COMPLETED ACCORDING TO SCHEDULE. OWNER CANNOT AFFORD ADDITIONAL COSTLY REPAIRS ESPECIALLY SINCE IT SEEMS TO BE GOING DOWNHILL FROM HERE. DISGUSTED WITH PROBLEMS AS WELL AS WITH LACK OF SERVICE FROM SEVERAL DIFFERENT PONTIAC DEALERS. OWNER CANNOT AFFORD TO BUY A [DECENT] NEW CAR AND WILL HAVE TO PURCHASE SOMETHING USED. MAKE NO MISTAKE- IT WON'T BE A GM PRODUCT! *NM
NHTSA ODI #10169247
Mileage unknown · Oct 30, 1998
Seats
PASSENGER'S SIDE SEAT DOES NOT STAY LOCKED IN POSITION, CAUSING THE SEAT TO LUNGE FORWARD INTO WINDSHIELD. DEALER HAS LUBRICATED CATCHES, BUT DEFECT IS STILL OCCURRING. INTERMITTENT PROBLEM. *AK
NHTSA ODI #829828
Mileage unknown · Oct 20, 1998
Engine And Engine CoolingEquipmentSeats
PASSENGER SEAT TRACK/ADJUSTER ROD FAILED, AFTER REPAIR WORK COMPLETED THE UNIT FAILED AGAIN CAUSING PASSENGER TO HIT WINDSHIELD DURING EMERGENCY STOPPING.
NHTSA ODI #542184
Mileage unknown · May 4, 1998
Seat BeltsSeatsVisibilityInjury
SEAT TRACK FAILED RESULTING IN MOVEMENT IN SEAT CAUSING INJURIES, SEAT BELTS FAILED TO RESTAIN.
NHTSA ODI #534993
Mileage unknown · Mar 3, 1998
Seats
DESIGN FLAW OF THE ADJUSTMENT HANDLE FOR THE FRONT BASE CENTER OF THE DRIVERS SEAT, GETS HOOKED ON PANTS AS THE DRIVER IS EXITING.
NHTSA ODI #531615
Mileage unknown · Feb 23, 1998
Electrical SystemEngine And Engine CoolingSeats
EXHAUST MISALIGNED, CAUSING SYSTEM TO HANG LOW.
NHTSA ODI #531095
Mileage unknown · Feb 25, 1997
Seats
NO LOCKING MECHANISM ON SPLIT REAR FOLDING SEATS. OWNER WILL NOT PUT CHILD IN BACK SEAT AND IS CAUTIOUS OF PUTTING ANYTHING IN THE TRUNK FOR FEAR OF IT BEING THROWN INTO PASSENGER COMPARTMENT IN THE EVENT OF A COLLISION.
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
THE PROTECTIVE COVER FOR THE UNDERHOOD FUSE CENTER WAS OMITTED. WITHOUT THIS COVER, THE POSITIVE TERMINAL BOLT ON THE FUSE BLOCK IS EXPOSED AND CAN CONTACT THE INSULATED NEGATIVE BATTERY CABLE. IF THE INSULATION ON THE NEGATIVE CABLE BECOMES SUFFICIENTLY WORN, AN ELECTRICAL SHORT CIRCUIT CAN OCCUR BETWEEN THE POSITIVE TERMINAL AND NEGATIVE CABLE RESULTING IN EXTREMELY HIGH CURRENT FLOW.
Consequence & remedy
Consequence: THIS HIGH CURRENT FLOW CAN CAUSE ARCING AND RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES FOR THE PRESENCE OF THE PROTECTIVE COVER AND, IF NECESSARY, INSTALL A PROTECTIVE COVER TO THE UNDERHOOD FUSE CENTER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1997 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration