CAR WOULD NOT START. STEERING LOCKED AND TRANSMISSION STUCK IN PARK.KEY WOULD NOT TURN. TOWED CAR HOME. REMOVED THE IGNITION SWITCH AND FOUND THE IGNITION LOCK HAD MELTED. THE OBVIOUS FIRE HAZARD PROMPTED A RECALL SEARCH FOR THE MAKE AND MODEL FINDING AN IGNITION RECALL HAS BEEN ISSUED. I CONTACTED PONTIAC CUSTOMER SERVICE. THE …
Read full complaint
CAR WOULD NOT START. STEERING LOCKED AND TRANSMISSION STUCK IN PARK.KEY WOULD NOT TURN. TOWED CAR HOME. REMOVED THE IGNITION SWITCH AND FOUND THE IGNITION LOCK HAD MELTED. THE OBVIOUS FIRE HAZARD PROMPTED A RECALL SEARCH FOR THE MAKE AND MODEL FINDING AN IGNITION RECALL HAS BEEN ISSUED. I CONTACTED PONTIAC CUSTOMER SERVICE. THE REPRESENTATIVE ASKED ME IF MY VIN WAS COVERED. I HAVE CONFIRMED THE VIN IS ON THE RECALL LIST ALTHOUGH THE REP. FAILED TO ACKNOWLEDGE THIS. THE SERIOUSNESS OF THE RECALL, POTENTIAL FIRE HAZARD AND VALIDITY OF MY COMPLAINT WAS IGNORED AND [XXX] (PONTIAC REP.) WOULD NOT ASSIST ME FURTHER. I AM STUCK NOW WITH TRYING TO RESOLVE GETTING MY CAR REPAIRED IN A TIMELY MANNER. PLEASE ADVISE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10523832
10,700 miles · Jan 15, 2004
SteeringTiresUnknown Or OtherCrash
MY MAIN PROBLEM IS THE STEERING COLUMN. WHEN IT IS TIME TO TAKE THE KEY OUT OF THE IGNITION IT GETS STUCKS. YOUR UNABLE TO TAKE THE KEY OUT UNTIL THE CAR WANTS TO LET IT GO. SOMETIMES THIS ENDS UP TO BE A 45 MINUTE TO AN HOUR WAIT. THE PLACE I BOUGHT IT FROM SAID THEY FIXED IT. OF COURSE, AFTR THE WARRANTY WAS UP SO WASN'T THE K…
Read full complaint
MY MAIN PROBLEM IS THE STEERING COLUMN. WHEN IT IS TIME TO TAKE THE KEY OUT OF THE IGNITION IT GETS STUCKS. YOUR UNABLE TO TAKE THE KEY OUT UNTIL THE CAR WANTS TO LET IT GO. SOMETIMES THIS ENDS UP TO BE A 45 MINUTE TO AN HOUR WAIT. THE PLACE I BOUGHT IT FROM SAID THEY FIXED IT. OF COURSE, AFTR THE WARRANTY WAS UP SO WASN'T THE KEY ONCE AGAIN GETTING STUCK. HAD THE WHOLE STEERING COLUMN REPLACED FOR ABOUT $500.00 NO PROBLEMS FOR ABOUT 2 MONTHS AND NOW ONCE AGAIN KEY IS GETTING STUCK.
NHTSA ODI #10070417
69,000 miles · Jan 14, 2004
Engine And Engine CoolingService Brakes, HydraulicSteering
WHILE DRIVING AND TURNING TO THE LEFT THERE WAS NO STEERING. ALSO, BRAKE FAILED, AND VEHICLE INTERMITTENTLY STALLED. *AK
NHTSA ODI #10054049
Mileage unknown · Jul 11, 2002
Electrical SystemEngine And Engine CoolingInterior Lighting
INTERIOR LIGHTS COME ON INTERMITTENTLY WHILE DRIVING, THERE ARE RECALLS 88V927000 AND 96V257000; BUT THIS VEHICLE IS NOT AFFECTED DUE TO VIN. *AK THE INVOICE STATES THAT THEY CHECKED THE RECALL/CAMPAIGN-THEY HAD TO INSTALL ENGINE WIRING HARNESS, REPLACE THE IGNITION SWITCH AND THE STEERING COLUMN TILT LEVER. *SCC
NHTSA ODI #8013776
Mileage unknown · Jun 21, 2002
Electrical SystemSteering
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #763331
Mileage unknown · Jan 22, 2002
Electrical SystemSteeringSuspension
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #757164
Mileage unknown · May 25, 2001
SteeringSuspension
LOWER CONTROL ARM BUSHINGS ARE EXPERIENCING EXCESSIVE WEAR AND HAVE DISINTEGRATED. CONSUMER WAS INFORMED THAT THIS IS DUE TO A FACTORY RELATED DEFECT. ALSO, FRONT STRUTS ARE NOISY AND SQUEAKY, A METAL TO METAL SOUND. *AK DEALER REPLACED TIE RODS WHEN CRUSHING SOUND IN FRONT END WAS FIRST HEARD. *SLC
NHTSA ODI #889177
Mileage unknown · Aug 1, 2000
Steering
IS THIS STILL A FREE FIX? YOUR CAMPAIGN #: 96V249000. NO SAFETY DEFECT LISTED WITHIN SUMMARY. *AK
NHTSA ODI #726368
Mileage unknown · May 30, 2000
Electrical SystemSteering
THIS IS THE THIRD REPLACEMENT OF THE IGNITION LOCK CYLINDER WITHIN TWO YEARS 1998-2000. IT SEEMS TO NEED REPLACED EVERY 9-12 MONTHS. I FEEL THIS IS AN OBVIOUS PROBLEM AND SHOULD BE CORRECTED. THE SEAT ANCHOR HAS BEEN REPORTED EACH TIME I TAKE THE CAR TO THE DEALERSHIP. THE LAST TIME I WAS TOLD TO RECLINE THE SEAT TO PREVENT …
Read full complaint
THIS IS THE THIRD REPLACEMENT OF THE IGNITION LOCK CYLINDER WITHIN TWO YEARS 1998-2000. IT SEEMS TO NEED REPLACED EVERY 9-12 MONTHS. I FEEL THIS IS AN OBVIOUS PROBLEM AND SHOULD BE CORRECTED. THE SEAT ANCHOR HAS BEEN REPORTED EACH TIME I TAKE THE CAR TO THE DEALERSHIP. THE LAST TIME I WAS TOLD TO RECLINE THE SEAT TO PREVENT THE PROBLEM. I DO NOT FEEL THIS IS AN ACCEPTABLE ANSWER TO THE PROBLEM. *AK
NHTSA ODI #723334
Mileage unknown · Oct 13, 1999
Steering
WHILE TRAVELING AND MAKING A TURN STERRING WHIEEL LOCKED UP, CAUSING CONSUMER TO JERK THE STERRING WHEEL . PLEASE PROVIDE FURTHER INFORJMATON. DRL HAS BEEN CONTACTED. *AK
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
1996 Pontiac Grand Am Problems, Complaints & Recalls | Skip That Year
Illustration