NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
74 reportsClear category filterMileage unknown · Sep 24, 1999
Engine And Engine Cooling
HAD TO HAVE THE ENGINE REPLACED AFTER ONLY 69,000 MILES DUE TO A PISTON GONE BAD! GM WOULD GIVE NO ASSISTANCE, EVEN THOUGH I HAVE HAD THE CAR WORKED ON AT 15 DIFFERENT TIMES, SO I HAD TO PAY ALMOST $4,000! DEALERSHIP, WHERE TAKEN, WAS NO HELP EITHER, THEY SAID THAT IT WAS DUE TO HAVING THE OIL CHANGED AT "JIFFYLUBE" OR "Q-LUBE" …
Read full complaint
HAD TO HAVE THE ENGINE REPLACED AFTER ONLY 69,000 MILES DUE TO A PISTON GONE BAD! GM WOULD GIVE NO ASSISTANCE, EVEN THOUGH I HAVE HAD THE CAR WORKED ON AT 15 DIFFERENT TIMES, SO I HAD TO PAY ALMOST $4,000! DEALERSHIP, WHERE TAKEN, WAS NO HELP EITHER, THEY SAID THAT IT WAS DUE TO HAVING THE OIL CHANGED AT "JIFFYLUBE" OR "Q-LUBE" OR "WAL-MART". THEY SAID THOSE PLACES USE "REFINED OIL" AND NOT NEW OIL LIKE THE DEALERSHIP DOES. THIS SOUNDS LIKE AN EXCUSE AND NOT A CONTRIBUTING FACTOR TO ME! LIKE I MENTIONED, SINCE BUYING THE CAR I HAVE TAKEN IT TO THE "SHOP" ON 15 DIFFERENT OCCASIONS FOR WARRANTY & NON-WARRANTY WORK. INDIANA DOES NOT HAVE A LEMON LAW SO I AM NOT SURE WHAT ELSE TO DO TO GET SOME HELP IN THIS MATTER! THE DEALERSHIP EVEN MENTIONED THEY HAVE HAD SIMILAR PROBLEMS WITH THESE ENGINES! LOOKING FOR SOME HELP! I NOW HAVE TO KEEP THE CAR FOR ATLEAST 3 MORE YEARS TO GET MY MONEY BACK FROM THE NEW ENGINE!
NHTSA ODI #711986
Mileage unknown · Jul 20, 1999
Engine And Engine Cooling
I WAS TOLD THAT THAT ENGINE HAD BEEN DISCONTIUED BECAUSE OF ALL THE PROBLEMS THAT HAD ACCURRED, AND I WANT PONTIAC TO FIX OR REPLACE THIS ENGINE AT NO COST TO ME. THE ENGINE WAS DISCONTINUED, SO SHOULDN'T THEY HAVE RECALLED THAT ENGINE. *AK
NHTSA ODI #708852
Mileage unknown · Jun 17, 1999
Engine And Engine Cooling
WHEN DRIVING AT ANY SPEED THEIR IS A TAPPING NOISE COMING FROM THE SERPENTINE BELT WHICH IS LOOSE. DEALER IS AWARE OF THE PROBLEM. *AK
NHTSA ODI #840380
Mileage unknown · May 18, 1999
Engine And Engine CoolingService Brakes, Hydraulic
WHILE DRIVING ABS LIGHT CAME ON, AND THEN VEHICLE SHUT DOWN. MANUFACTURER HAS BEEN NOTIFIED. *AK
NHTSA ODI #838091
Mileage unknown · May 12, 1999
Electrical SystemEngine And Engine Cooling
WHILE DRIVING 20 MPH OR ABOVE THE VEHICLE COMPLETELY SHUTS DOWN WITHOUT WARNING. DEALER HAS REPLACED THE COMPUTER COMMAND MODULE WHICH DID NOT CORRECT THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #837826
Mileage unknown · May 10, 1999
Engine And Engine CoolingEquipmentExterior Lighting
TRANSMISSION FAILED. NLM
NHTSA ODI #545487
Mileage unknown · Apr 29, 1999
Electrical SystemEngine And Engine Cooling
INTERMITTENTLY WHILE DRIVING VEHICLE STALLED UNEXPECTEDLY WITHOUT WARNING WHICH MAY HAV E RESULTED IN A CRASH. BEEN TO DEALER SEVERAL TIMES, AND REPLACE A LOOSE WIRE, BUT PROBLEM IS STILL OCCURRING. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #837270
Mileage unknown · Apr 19, 1999
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
MY MOST RECENT PROBLEM INCLUDED TRANSMISSION FAILURE, AND ACCORDING TO THE MECHANIC THIS HAD BEEN HAPPENING FOR A VERY LONG TIME. THE FOURTH GEAR OF THE TRANSMISSION AND THE CLUTCH WERE BURNED OUT. I'VE ALSO HAD TO REPLACE A WATER PUMP ON THE VEHICLE. IMMEDIATELY AFTER PURCHASE, I NOTICED ANTI-FREEZE LEAKING FROM THE VEHICLE …
Read full complaint
MY MOST RECENT PROBLEM INCLUDED TRANSMISSION FAILURE, AND ACCORDING TO THE MECHANIC THIS HAD BEEN HAPPENING FOR A VERY LONG TIME. THE FOURTH GEAR OF THE TRANSMISSION AND THE CLUTCH WERE BURNED OUT. I'VE ALSO HAD TO REPLACE A WATER PUMP ON THE VEHICLE. IMMEDIATELY AFTER PURCHASE, I NOTICED ANTI-FREEZE LEAKING FROM THE VEHICLE AND THE VEHICLE WOULD JUST DIE WHILE DRIVING ALONG. I ATTEMPTED TO GET THE DEALER TO REPAIR THE VEHICLE AND DID GET HIS VERBAL AGREEMENT HOWEVER, HE LIED AND WOULDN'T FOLLOW THROUGH. I SUPPOSE BECAUSE HE KNEW HE'D SOLD ME A LEMON AND WAS MORE THAN EAGER TO STATE HIS CASE, THAT HAD NO LEMON LAW. THERE ARE VARIOUS ELECTRICAL PROBLEMS ESPECIALLY WITH THE INSTRUMENT PANEL AND I SUPPOSE IT MAY BE SOMETHING ELECTRICAL THAT CAUSES MY VEHICLE TO DIE WHILE DRIVING ALONG. THERE IS NO WARNING, THE VEHICLE JUST GOES DEAD. DURING STOPS IT SEEMS THAT AT TIMES THE REAR END JUST HAS A MIND OF ITS OWN; ALMOST AS IF IT WANTS TO KEEP GOING WHILE THE FRONT END HAS STOPPED - IT'S SORT OF LIKE A SKIPPING EFFECT. OTHER ELECTRICAL PROBLEMS INCLUDE THE PASSENGER DOOR LOCK NOT OPERATING WITH THE POWER DOOR LOCK, THE RADIO DISPLAY IS LIT AT TIMES AND SOMETIMES IT'S NOT, SINCE I'VE HAD THE TRANSMISSION REPAIRED THE CHECK ENGINE LIGHT AND ETS LIGHTS WHICH HAVE BEEN ON SINCE I PURCHASED THE VEHICLE, ARE NO LONGER LIT. DURING THE WATER PUMP FAILURE THE DEALERSHIPS REMEDY FOR IT WAS TO DISCONNECT THE ELECTRICAL WIRING WHICH PROMPTED ME THAT SOMETHING WAS WRONG WITH THIS SYSTEM. THE ELECTRICAL PROBLEMS ARE NUMEROUS. MY CAR IS A LEMON!
NHTSA ODI #705779
Mileage unknown · Jan 14, 1999
Engine And Engine CoolingEquipment
THE TEMPERATURE GAUGE AND THE AIR CONDITIONER DON'T WORK AND THE VEHICLE IS OVERHEATING, CAUSING THE CONSUMER TO HAVE PROBLEMS SEEING OUT THE WINDOW. DEALER HAS WORKED ON THE VEHICLE FOUR TIMES, AND STILL CAN'T DETERMINE THE PROBLEM. ALSO, WATER PUMP HAD TO BE REPLACED. *AK
NHTSA ODI #833599
Mileage unknown · Jan 12, 1999
Engine And Engine Cooling
WHILE DRIVING 60 MPH ON THE HIGHWAY WITHOUT WARNING THE VEHICLE COMPLETELY SHUTS DOWN OR STALLS, CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #833381
Official recalls
4Mar 6, 2002
ON CERTAIN PASSENGER VEHICLES. IF THE ENGINE FAILS TO START AND THE DRIVER HOLDS THE KEY IN THE "START" POSITION FOR AN EXTENDED PERIOD, HIGH CURRENT FLOWS THROUGH THE IGNITION SWITCH, AND SOMETIMES PRODUCES ENOUGH HEAT TO MELT INTERNAL SWITCH PARTS.
Consequence & remedy
Consequence: IF THE SWITCH IS DAMAGED, A FIRE COULD OCCUR IN THE STEERING COLUMN, EVEN WITH THE ENGINE OFF AND THE KEY REMOVED.
Remedy: DEALERS WILL INSTALL A RELAY KIT IN THESE VEHICLES TO PREVENT HIGH CURRENT FROM FLOWING THROUGH THE IGNITION SWITCH. OWNER NOTIFICATION BEGAN MARCH 27, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, PONTIAC AT 1-800-762-2737, BUICK AT 1-800-521-7300, OR OLDSMOBILE AT 1-800-442-6537.
Feb 17, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THESE VEHICLES WERE BUILT WITH THE POTENTIAL FOR THE INTERIOR LAMPS TO COME ON UNEXPECTEDLY WHILE THE VEHICLES ARE BEING DRIVEN. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 101, "CONTROLS AND DISPLAYS."
Consequence & remedy
Consequence: THE INTERIOR LAMPS COMING ON UNEXPECTEDLY COULD STARTLE A DRIVER CAUSING A MOMENTARY LOSS OF CONTROL INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL RUN A DIAGNOSTIC TEST ON THE LAMP CONTROL MODULE AND, IF NECESSARY, REPLACE IT.
Dec 17, 1996
THE STEERING COLUMN LOWER PINCH BOLT WAS NOT PROPERLY TIGHTENED DURING ASSEMBLY.
Consequence & remedy
Consequence: AN UNDERTORQUED PINCH BOLT CAN RATTLE AND CAUSE LOOSENESS IN THE STEERING SYSTEM. IF THE PINCH BOLT BACKED OUT OF THE JOINT COMPLETELY, ROTATION OF THE STEERING SHAFT AGAINST THE CONNECTOR COULD CAUSE INCREASING LOOSENESS IN THE STEERING SYSTEM AND RESULT IN LOSS OF STEERING AND AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE STEERING COLUMN PINCH BOLT FOR CORRECT TORQUE AND, IF NECESSARY, TIGHTEN THE BOLT TO THE SPECIFIED TORQUE.
Dec 17, 1996
THE FRONT AND/OR REAR HAZARD WARNING LAMPS (FOUR-WAY FLASHERS) DO NOT FLASH WHEN THE HAZARD SWITCH IS ACTIVATED. THIS FAILS TO COMPLY WITH FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."
Consequence & remedy
Consequence: IF THESE LAMPS WERE NOT FLASHING, OTHER VEHICLES WOULD NOT BE AWARE THAT THIS VEHICLE WAS STOPPED INCREASING THE RISK OF AN ACCIDENT.
Remedy: DEALERS OR VEHICLE OWNERS WILL INSPECT FOR PROPER FUNCTION OF THE HAZARD WARNING LAMPS. IF NECESSARY, DEALERS WILL REPLACE THE HAZARD LAMP SWITCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ03001 · Power Rack And Pinion Steering Failure
Opened Jan 2, 2003 · Closed Sep 15, 2003
Status: closed (inferred from source dates) · Steering; Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Additional source detail variants (2)
Steering
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
Steering:rack And Pinion
GM CONDUCTED A SAFETY RECALL (NHTSA # 02V286) TO ADDRESS A STEERING DEFECT PERTAINING TO A LOWER PINION BEARING (LPB) WITHIN THE RACK AND PINION STEERING GEAR (R&P). THE RECALL COVERED 1,159,156 MODEL YEAR 1997-1998 PONTIAC GRAND PRIX VEHICLES BUILT BETWEEN MARCH 1, 1996 AND OCTOBER 31, 1997, 1996-1998 PONTIAC TRANS SPORT, CHEVROLET LUMINA APV, CHEVROLET VENTURE, OLDSMOBILE SILHOUETTE MINIVANS, AND CHEVROLET CAVALIER AND PONTIAC SUNFIRE SEDANS BUILT BETWEEN JANUARY 1, 1996 AND OCTOBER 31, 1997.ODI OPENED THIS RQ AFTER RECEIVING REPORTS THAT OTHER VEHICLES WERE EXHIBITING THE SAME SYMPTOMS AS THE RECALLED VEHICLES.BASED ON ODI'S REVIEW OF TECHNICAL AND COMPLAINT DATA COLLECTED DURING THE RQ, THE W-CARS ARE ASSOCIATED WITH EITHER A HIGHER STEERING COMPLAINT RATE OR A HIGHER LPB FAILURE RATE THAN THE OTHER VEHICLES INVESTIGATED UNDER THE RQ AND ARE ABOVE OR NEAR THE RATES FOR THE RECALLED VEHICLES.THUS, ODI WILL FURTHER EXAMINE THE W-CARS (1996-1997 OLDSMOBILE CUTLASS SUPREME, 1996-1998 BUICK REGAL, CHEVROLET LUMINA, CHEVROLET MONTE CARLO, 1997-1998 BUICK CENTURY, AND 1998 OLDSMOBILE INTRIGUE) UNDER A NEW INVESTIGATION, ENGINEERING ANALYSIS (EA)03-019.
RQ98013 · Oversensitive Air Bag Deployments
Opened Aug 26, 1998 · No close date supplied
Status: open (inferred from source dates) · Air Bags
ON JUNE 26, 1998, GENERAL MOTORS BEGAIN A SAFETY RECALL, 98V-146, TO RECALIBRATE THE AIR BAG SENSING AND DIAGNOSTIC MODULE (SDM) IN THE 1996 AND SOME 1997 J BODY CARS, CAVALIER AND SUNFIRE.DUE TO CERTAIN CALIBRATIONS IN THE AIR BAG SDM, THERE IS AN INCREASED RISK OF INADVERTENT AIR BAG DEPLOYMENT IN A LOW SPEED CRASH OR WHEN AN OBJECT STRIKES THE FLOOR PAN.THE RECALL POPULATION CONSISTS OF 675,302 VEHICLES BUILT FROM APRIL 1995 THROUGH MAY 1997.ODI HAS RECEIVED 8 OWNER REPORTS ALLEGING INADVERTENT AIR BAG DEPLOYMENT WITHOUT A CRASH.THE PURPOSER OF THE RQ IS TO DETERMINE WHETHER GM SHOULD EXPAND THE RECALL TO INCLUDE THESE VEHICLES.CLOSING RESUME NOTE:AS OF AUGUST 5, 1999, ODI RECEIVED ONE ADDITIONAL COMPLAINT REGARDING THE ALLEGED DEFECT.THE INCIDENT RATES FOR THE SUBJECT VEHICLES ARE ABOUT ONE-THRID OF THE RATES OF THE RECALLED VEHICLES (WHEN THE RECALL WAS INITIATED).BASED ON THE AVAILABLE INFORMATION, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOSE NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY FUTURE CIRCUMSTANCES.
Illustration