Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 7 of 80 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports7 injury reports
What owners actually said
80 reports
Mileage unknown · May 16, 2000
Equipment
5-22-99 53527 MILES. THE FRONT A/C HAD TO BE FIXED. FRONT EVAP CORE, DRIER, EVAP CORE, EVACUATE AND RECHAREG, A/C COST $522.75. NOW 1 YEAR LATER 5-16-00 63502 MILES THE A/C NEEDS REPAIR AGAIN. CONDENSER, RECEIVER/DRIER, FREON, EVAC & RECHARGE FOR A TOTAL OF $561.15. CALLED CHRYSLER 5-16-00 WILL NOT DO ANYTHING. THEY SA…
Read full complaint
5-22-99 53527 MILES. THE FRONT A/C HAD TO BE FIXED. FRONT EVAP CORE, DRIER, EVAP CORE, EVACUATE AND RECHAREG, A/C COST $522.75. NOW 1 YEAR LATER 5-16-00 63502 MILES THE A/C NEEDS REPAIR AGAIN. CONDENSER, RECEIVER/DRIER, FREON, EVAC & RECHARGE FOR A TOTAL OF $561.15. CALLED CHRYSLER 5-16-00 WILL NOT DO ANYTHING. THEY SAY IT IS MY PROBLEM, I TOLD THEM IT IS THEIRS BECAUSE THEIR ARE SO MANY PEOPLE OUT THERE LIKE ME. *AK
NHTSA ODI #722779
Mileage unknown · Apr 11, 2000
Power Train
TRANSMISION FAILURE AT HWY SPEEDS WHICH CAUSED LOCKED UP ENGINE. TRANSMISION FAILURE AND TORQUE CONVERTER LOCKED UP, ENGINE- RESULTING IN LOSS OF POWER STEERING AND POWER BRAKES IN HEAVY TRAFFIC, MOMENTARY LOSS OF CONTROL DUE TO LOSS OF ALL POWER ASSISTANCE(DEAD ENGINE). *AK
NHTSA ODI #721344
Mileage unknown · Mar 27, 2000
Service Brakes, Hydraulic
WHILE DRIVING BRAKES MALFUNCTIONED, CAUSING A NOISE, AND EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #859229
Mileage unknown · Mar 21, 2000
Air BagsCrashInjury
WHILE DRIVING AND MAKING A LEFT HAND TURN ON THE RAMP OF I-76, VEHICLE STARTED TO SLOW DOWN BECAUSE OF AN ACCIDENT UP AHEAD, AND A SEMI TRUCK BEHIND WAS ALSO MAKING A LEFT HAND TURN, BUT IT DIDN'T SLOW DOWN. FISHTAILED AND HIT CONSUMER'S VEHICLE. UPON IMPACT, NEITHER AIRBAG DEPLOYED DUE TO A SHORT IN THE ELECTRICAL SYSTEM. …
Read full complaint
WHILE DRIVING AND MAKING A LEFT HAND TURN ON THE RAMP OF I-76, VEHICLE STARTED TO SLOW DOWN BECAUSE OF AN ACCIDENT UP AHEAD, AND A SEMI TRUCK BEHIND WAS ALSO MAKING A LEFT HAND TURN, BUT IT DIDN'T SLOW DOWN. FISHTAILED AND HIT CONSUMER'S VEHICLE. UPON IMPACT, NEITHER AIRBAG DEPLOYED DUE TO A SHORT IN THE ELECTRICAL SYSTEM. RECALL NOTICE ISSUED. *AK *ML
NHTSA ODI #858930
Mileage unknown · Jan 28, 2000
Structure
THE SLIDING DOOR FELL OFF TWICE CAUSING ENJURY TO CHILD PASSENGER. YH
NHTSA ODI #550685
Mileage unknown · Jan 20, 2000
StructureInjury
WHEN CONSUMER TRIED TO OPEN THE SLIDING DOOR, DOOR FELL OFF FOR THE SECOND TIME. THE FIRST TIME DOOR WAS OFF TRACKS. *AK
NHTSA ODI #855198
Mileage unknown · Jan 18, 2000
Power Train
INTERMITTENT FAILURE OF TRANSMISSION TO ENGAGE FROM STOP-INCREASINGLY HARSH SHIFTS. CAR ALWAYS DRIVEN CONSERVATIVELY AND NEVER CARRIED A HEAVY LOAD;NO TRAILER HITCH PRESENT. THIS IS FAR TOO EARLY FOR SUCH A MAJOR FAILURE ON A WELL-CARED FOR CAR. *AK
NHTSA ODI #717507
Mileage unknown · Nov 30, 1999
Power Train
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #715435
Mileage unknown · Nov 17, 1999
Structure
THE FRAME WHERE THE BOTTOM HINGE ATTACHES TO THE FRONT DOORS HAS DEVELOPED A STRESS FRACTURE. AS DOORS OPEN, THE FRACTURE BROADENS AND THERE IS ALSO A LATERAL FRACTURE INTO THE BOLT. LOCAL DEALER'S BODY SHOP HAS INDICATED THAT THE DOORS COULD FALL OFF. DEALER HAS BEEN NOTIFIED. *AK *YC
NHTSA ODI #853062
Mileage unknown · Oct 27, 1999
Power Train
WHEN DRIVING AT ANY SPEED VEHICLE IS SHIFTING HARD/GRINDING, AND GOING INTO REVERSE.IT WON'T SHIFT OUT OF SECOND GEAR. ALSO, VEHICLE HAS AN INTERMITTENT PROBLEM WITH TRANSMISSION IS SLIPPING. *AK
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Plymouth Grand Voyager Problems, Complaints & Recalls | Skip That Year
Illustration