Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 7 of 80 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Structure. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports7 injury reports
What owners actually said
80 reports
155,000 miles · Aug 29, 2013
Structure
TL* THE CONTACT OWNS A 1995 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO CLOSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE DOOR WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APP…
Read full complaint
TL* THE CONTACT OWNS A 1995 PLYMOUTH GRAND VOYAGER. THE CONTACT STATED THAT THE DRIVER'S SIDE DOOR FAILED TO CLOSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE DOOR WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.
NHTSA ODI #10537903
30,000 miles · May 12, 2004
Air BagsVisibility
REAR WIPER INOPERATIVE, AIRBAG LIGHT ON
NHTSA ODI #10072507
Mileage unknown · May 11, 2004
Seats
THE SEAT BACK RECLINER BOLT BROKE. *MR WHILE DRIVING IN A SNOW STORM THE DRIVER'S SEAT BACK COLLAPSED. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND PULLED IT ONTO THE SIDE OF THE ROAD. THE VEHICEL WAS TAKEN TO THE DEAER WHO INFORMED THE CONSUMER THAT THE REPAIRS WERE NOT COVERED UNDER WARRANTY. *NM
NHTSA ODI #10073767
143,000 miles · Dec 28, 2003
Electrical System
ENGINE DIES WITHOUT WARNING WHILE IN MOTION. TODAY, IT QUIT IN HEAVY TRAFFIC NEARLY RESULTING IN AN ACCIDENT. VEHICLE HAS 150K MILES. *AK THE STALLS USUALLY OCCUR UPON LETTING UP ON THE ACCELERATOR PEDAL. IT WILL NORMALLY RESTART IMMEDIATELY, BUT TO CONTINUE RUNNING THE ACCELERATOR NEEDS HELD DOWN TO HOLD THE ENGINE A LIT…
Read full complaint
ENGINE DIES WITHOUT WARNING WHILE IN MOTION. TODAY, IT QUIT IN HEAVY TRAFFIC NEARLY RESULTING IN AN ACCIDENT. VEHICLE HAS 150K MILES. *AK THE STALLS USUALLY OCCUR UPON LETTING UP ON THE ACCELERATOR PEDAL. IT WILL NORMALLY RESTART IMMEDIATELY, BUT TO CONTINUE RUNNING THE ACCELERATOR NEEDS HELD DOWN TO HOLD THE ENGINE A LITTLE ABOVE IDLE SPEED - YOU HAVE TO DRIVE WITH TWO FEET. NO ERROR CODES ARE RECORDED, SO ASSUMED MECHANICAL FAILURE WAS OCCURING. THERE WAS NO SPUTTERING, LIKE A FUEL PUMP FAILING WOULD CAUSE. REPLACED FUEL FILTER AND PRESSURE REGULATOR, BUT DID NOT RESOLVE THE PROBLEM. REPAIR SHOPS CAN ONLY GUESS AT THE CAUSE.
NHTSA ODI #10051186
142,000 miles · Oct 21, 2003
Structure
THE FRAME WHERE THE DRIVER'S DOOR IS ATTACHED IS CRACKING AROUND THE BOTTOM HINGE . THE DOOR HAS DROPPED DOWN A LITTLE. IT SEEMS TO BE AFFECTING THE LATCH. *LA
NHTSA ODI #10043278
100,000 miles · Jul 30, 2003
Power Train
WHILE DRIVING THERE WAS CLANKING NOISE FROM THE AUTO TRANSMISSION, AND THE VEHICLE WOULDN'T SHIFT GEARS. PER DEALERSHIP THE TRANSMISSION FAILED.
NHTSA ODI #10031537
Mileage unknown · Jul 15, 2003
Air BagsCrashInjury
VEHICLE INVOLVED IN COLLISION AND AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS INVOLVED IN AN ACCIDENT IN WHICH THE AIR BAGS FAILED TO DEPLOY. AS A RESULT THE DRIVER RECEIVED HEAD, NECK, CHEST AND BACK INJURIES. THE VEHICLE ALSO EXPERIENCED RECURRING ELECTRICAL AND TRANSMISSION PROBLEMS. THERE WERE SEVERAL REASONABLE REPAIR ATT…
Read full complaint
VEHICLE INVOLVED IN COLLISION AND AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS INVOLVED IN AN ACCIDENT IN WHICH THE AIR BAGS FAILED TO DEPLOY. AS A RESULT THE DRIVER RECEIVED HEAD, NECK, CHEST AND BACK INJURIES. THE VEHICLE ALSO EXPERIENCED RECURRING ELECTRICAL AND TRANSMISSION PROBLEMS. THERE WERE SEVERAL REASONABLE REPAIR ATTEMPTS MADE TO HAVE THE ELECTRICAL SYSTEM AND TRANSMISSION REPAIRED. *MR *CB *NLM
NHTSA ODI #10029418
118,500 miles · Feb 5, 2003
Structure
A STRESS FRACTURE HAS DEVELOPED IN THE BEAM THAT HOLDS THE BOTTOM HINGE OF THE DRIVER'S DOOR. DOOR SAGS AND WILL NOT PROPERLY SHUT.
NHTSA ODI #10005334
95,000 miles · Jan 22, 2003
Power Train
TOTAL TRANSMISSION FAILURE. DIFFERENTIAL PIN BROKE AND CRACKED THE BELL HOUSING. FAILURE OCCURRED WITHOUT WARNING AND LESS THAN 5000 MILES AFTER REGULAR 90K TRANSMISSION SERVICE. REQUIRES COMPLETE TRANSMISSION REPLACEMENT AT EST COST OF $3,500. VEHICLE HAS BEEN METICULOUSLY MAINTAINED WITH VERY LIGHT DUTY USE. CATASTROPHIC…
Read full complaint
TOTAL TRANSMISSION FAILURE. DIFFERENTIAL PIN BROKE AND CRACKED THE BELL HOUSING. FAILURE OCCURRED WITHOUT WARNING AND LESS THAN 5000 MILES AFTER REGULAR 90K TRANSMISSION SERVICE. REQUIRES COMPLETE TRANSMISSION REPLACEMENT AT EST COST OF $3,500. VEHICLE HAS BEEN METICULOUSLY MAINTAINED WITH VERY LIGHT DUTY USE. CATASTROPHIC FAILURE OF THIS COMPONENT IS UNWARRANTED FOR WELL MAINTAINED VEHICLE OF THIS AGE.
NHTSA ODI #10003181
Mileage unknown · Dec 20, 2002
Steering
SHE WAS TRAVELING ABOUT 60MPH ON HIGHWAY THE VEHICLE BECAME HARD TO STEER. SHE LOST CONTROL OF THE VEHICLE PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM. TS
VEHICLE DESCRIPTION: MINI VANS. THE WIRING THAT INITIATES THE DRIVER AND/OR PASSENGER AIR BAG COULD ELECTRICALLY SHORT CIRCUIT TO GROUND. A SHORT CIRCUIT TO GROUND THAT EXISTS IMMEDIATELY AFTER TURNING THE IGNITION KEY TO THE "ON" OR "START" POSITION CAN CAUSE THE AIR BAG(S) TO INADVERTENTLY DEPLOY.
Consequence & remedy
Consequence: INADVERTENT AIR BAG DEPLOYMENT CAN INJURE A FRONT SEAT OCCUPANT.
Remedy: DEALERS WILL PERFORM AN ELECTRONIC DIAGNOSTIC CHECK. ANY SHORT CIRCUITS IDENTIFIED IN EITHER THE DRIVER'S OR PASSENGER SIDE AIR BAG INITIATOR WIRE CIRCUIT WILL BE REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE97049 · Air Bag Circuit/windshield Wiper Motor
Opened Nov 18, 1997 · Closed Mar 17, 1998
Status: closed (inferred from source dates) · Visibility
There is no summary currently available
EA97003 · Integrated Child Seat Belt Lockup
Opened Jan 31, 1997 · Closed Aug 19, 1998
Status: closed (inferred from source dates) · Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Additional source detail variants (2)
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
Child Seat
THIS INVESTIGATION IS CLOSED.CHRYSLER CORPORATION HAS SUBMITTED A DEFECT INFORMATION REPORT IDENTIFYING A SAFETY DEFECT AND OUTLINING THE PROPOSED REMEDY.RECALL NUMBER 98V-185 HAS BEEN ASSIGNED TO THIS SAFETY RECALL.
ODI CONTINUES TO RECEIVE COMPLAINTS ALLEGING LATCHING/RETRACTOR MECHANISM PROBLEMS.CHRYSLER'S ASSESSMENT OF THE PROBLEM INDICATES THAT OWNERS OF THE VEHICLES ARE NOT ADHERING TO THE CLEANING REQUIREMENTS FOR THE SEAT.THE SEAT APPEARS TO MALFUNCTION IF CRUMBS OF FOOD OR BEVERAGE RESIDUE ACCUMULATES ON THE LATCHING TONGUE IN THEWELL LOCATED BETWEEN THE CHILD'S LEGS.ODI HAS 19 COMPLAINTS OF RETRACT LOCKUP.SEVEN OF THESE COMPLAINTS REPORT CUTTING THE STRAPS TO REMOVE THE CHILD.TWO OF THE SEVEN CONSUMERS ALLEGE THE CHILD WAS CHOKING.CHRYSLER REPORTS 60 OWNER/FIELD REPORTS WHICH INDICATED 19 HARNESSES WERE CUT TO REMOVE THE CHILDREN.ADDITIONAL INFORMATION IS NEEDED TO FULLY ASSESS THE SAFETY CONSEQUENCE OF THE ALLEGED DEFECT AND TO EVALUATE THE CHRYSLER CORPORATION'S RATIONAL FOR NOT CONDUCTING A SAFETY RECALL CAMPAIGN.
PE96008 · Safety Blt Latch Operation
Opened Jan 25, 1996 · Closed Jun 28, 1996
Status: closed (inferred from source dates) · Seat Belts
There is no summary currently available
1995 Plymouth Grand Voyager Problems, Complaints & Recalls | Skip That Year
Illustration