Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
625–50K
1150–75K
575–100K
23100–150K
8150K+
54 reports with mileage · 71 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports17 fire reports1 injury reports
What owners actually said
125 reports
Mileage unknown · Aug 18, 2004
Fuel System, Gasoline
WHILE VEHICLE WAS PARKED CONSUMER NOTICED THAT LIQUID WAS LEAKING FROM UNDERNEATH THE VEHICLE. CONSUMER COULD NOT START UP THE VEHICLE, AND HAD IT TOWED TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. CONSUMER WAS CONCERNED THAT DEALER AND MANUFACTURER DID NOT DECIDE WHO WOULD…
Read full complaint
WHILE VEHICLE WAS PARKED CONSUMER NOTICED THAT LIQUID WAS LEAKING FROM UNDERNEATH THE VEHICLE. CONSUMER COULD NOT START UP THE VEHICLE, AND HAD IT TOWED TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. CONSUMER WAS CONCERNED THAT DEALER AND MANUFACTURER DID NOT DECIDE WHO WOULD PAY FOR REPAIRS. *AK
NHTSA ODI #10089207
Mileage unknown · Aug 11, 2004
Fuel System, GasolineFire
CONSUMER RECEIVED NHTSA RECALL 04V110000 FOR THE FUEL RAIL TUBING; BEFORE THE VEHICLE COULD HAVE RECALL REPAIRS PERFORMED VEHICLE CAUGHT ON FIRE WHILE PARKED AT A GAS STATION. AFTER HAVING THE VEHICLE INSPECTED BY AN OLDSMOBILE SERVICE MANAGER,WHO INSISTED THAT THE FIRE WAS RELATED TO THE FUEL RAIL, BUT CLAIMED MINIMUM RESP…
Read full complaint
CONSUMER RECEIVED NHTSA RECALL 04V110000 FOR THE FUEL RAIL TUBING; BEFORE THE VEHICLE COULD HAVE RECALL REPAIRS PERFORMED VEHICLE CAUGHT ON FIRE WHILE PARKED AT A GAS STATION. AFTER HAVING THE VEHICLE INSPECTED BY AN OLDSMOBILE SERVICE MANAGER,WHO INSISTED THAT THE FIRE WAS RELATED TO THE FUEL RAIL, BUT CLAIMED MINIMUM RESPONSIBILITY.*AK
NHTSA ODI #10087710
Mileage unknown · Jul 16, 2004
Fuel System, Gasoline
CONSUMER TOOK VEHICLE TO DEALER FOR RECALL REPAIRS ON THE CHASSIS FUEL RETURN LINE LEAKING. BUT HAD NOT SEEN ANY FUEL IN THE DRIVEWAY OR GROUND. HE WAS TOLD BY THE DEALER THAT THERE WAS A RECALL ON FUEL RAIL.HE STATED THAT THEY WILL NOT REPAIR ONE WITHOUT THE OTHER, AND HE DID NOT HAVE A RECALL NOTICE FOR THE OTHER. THIS COST…
Read full complaint
CONSUMER TOOK VEHICLE TO DEALER FOR RECALL REPAIRS ON THE CHASSIS FUEL RETURN LINE LEAKING. BUT HAD NOT SEEN ANY FUEL IN THE DRIVEWAY OR GROUND. HE WAS TOLD BY THE DEALER THAT THERE WAS A RECALL ON FUEL RAIL.HE STATED THAT THEY WILL NOT REPAIR ONE WITHOUT THE OTHER, AND HE DID NOT HAVE A RECALL NOTICE FOR THE OTHER. THIS COST $500.00 TO REPAIR.*AK
NHTSA ODI #10082161
Mileage unknown · Jul 13, 2004
Fuel System, GasolineFire
VEHICLE EXPLODED ON IGNITION.*MR THE VEHICLE EXPLODED IN THE CONSUMERS GARAGE. THE CONSUMER REQUESTING A NEW VEHICLE. *JB
NHTSA ODI #10082071
Mileage unknown · Jul 2, 2004
Fuel System, Gasoline
TOOK VEHICLE FOR SAFETY RECALL, DEALER DID NOT REPAIR, CONDITION IS WORSE. DEALER DIDN'T ASSEMBLE UNDERCARRIAGE, CAUSING DAMAGE TO COMPONENTS. *AK
NHTSA ODI #10079174
Mileage unknown · Jun 28, 2004
Fuel System, Gasoline
REQUEST FOR REIMBURSEMENT FOR DEFECTIVE FUEL RAIL REPLACEMENT.*MR THE CONSUMER STATED THE REPAIR WAS NECESSARY DUE TO AN EXCESSIVE GASOLINE ODOR COMING FROM A LEAK IN THE VEHICLE. IN JUNE OF 2004, ONE MONTH BEFORE HAVING THE WORK PERFORMED ON THE VEHICLE, THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE SAME ISS…
Read full complaint
REQUEST FOR REIMBURSEMENT FOR DEFECTIVE FUEL RAIL REPLACEMENT.*MR THE CONSUMER STATED THE REPAIR WAS NECESSARY DUE TO AN EXCESSIVE GASOLINE ODOR COMING FROM A LEAK IN THE VEHICLE. IN JUNE OF 2004, ONE MONTH BEFORE HAVING THE WORK PERFORMED ON THE VEHICLE, THE CONSUMER RECEIVED A RECALL NOTICE IN THE MAIL REGARDING THE SAME ISSUE, HOWEVER THE CONSUMER WAS DENIED REIMBURSEMENT BECAUSE THE WORK WAS NOT PERFORMED AT A GENERAL MOTORS DEALER. *JB
NHTSA ODI #10081846
Mileage unknown · Jun 25, 2004
Fuel System, Gasoline
WHILE VEHICLE WAS PARKED CONSUMER SAW THE GAS LINE LEAKING, AND SMELLED GAS FUMES. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK
NHTSA ODI #10079951
103,000 miles · Jun 25, 2004
Electrical System
IGNITION FAILURE. ERROR MESSAGE TO CLEAN KEY AND WAIT 3 MINUTES. THE KEY HAS A MICROCHIP, AND THE MICROCHIP HAS BEEN TESTED AND IS WORKING CORRECTLY. THE IGNOTION SWITCH, WHEN TESTED IS SHOWING TO BE WORKING PROPERLY. NO ONE CAN GIVE ME A REASON FOR THE MALFUNCTION, BUT I HAVE BEEN STRANDED NUMEROUS TIMES DUE TO THE MALFUNCT…
Read full complaint
IGNITION FAILURE. ERROR MESSAGE TO CLEAN KEY AND WAIT 3 MINUTES. THE KEY HAS A MICROCHIP, AND THE MICROCHIP HAS BEEN TESTED AND IS WORKING CORRECTLY. THE IGNOTION SWITCH, WHEN TESTED IS SHOWING TO BE WORKING PROPERLY. NO ONE CAN GIVE ME A REASON FOR THE MALFUNCTION, BUT I HAVE BEEN STRANDED NUMEROUS TIMES DUE TO THE MALFUNCTION.*AK
NHTSA ODI #10078796
Mileage unknown · Jun 23, 2004
Fuel System, Gasoline
FUEL RAIL LEAK WITH 1997 OLDSMOBILE AURORA.*MR WHILE IN THE PROCESS OF PARKING, THE FUEL RAIL FAILED SPEWING GASOLINE OVER THE ENGINE. *JB
NHTSA ODI #10079776
38,206 miles · Jun 23, 2004
Wheels
ALL FOUR HUB CAP WERE LOOSE AND DID NOT FIT ANY MORE. THE DEALER TOLD THE CONSUMER TO REPORTED THE PROBLEM TO NHTSA. *JB THE CONSUME FEELS THAT THE INTEGRITY OF THE MATERIAL USED IN MANUFACTURING THE HUB CAPS IS IN QUESTION. THE PLASTIC CLIPS THAT HOLD THE RETAINING WIRE, WHICH SECURES THE HUB CAP ONTO THE WHEEL, WAS BRITT…
Read full complaint
ALL FOUR HUB CAP WERE LOOSE AND DID NOT FIT ANY MORE. THE DEALER TOLD THE CONSUMER TO REPORTED THE PROBLEM TO NHTSA. *JB THE CONSUME FEELS THAT THE INTEGRITY OF THE MATERIAL USED IN MANUFACTURING THE HUB CAPS IS IN QUESTION. THE PLASTIC CLIPS THAT HOLD THE RETAINING WIRE, WHICH SECURES THE HUB CAP ONTO THE WHEEL, WAS BRITTLE AND BROKE WHEN REMOVING OR REPLACING IT. THE CONSUMER EXPERIENCED THIS PROBLEM WITH THE ORIGINAL HUB CAPS AND 2 USED REPLACEMENTS. *NM
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1997 Oldsmobile Aurora Problems, Complaints & Recalls | Skip That Year
Illustration