TL* THE CONTACT OWNS A 1997 OLDSMOBILE AURORA. THE CONTACT WAS TURNING IN REVERSE APPROXIMATELY 2 MPH WHEN HE HEARD A LOUD POP. THE VEHICLE WAS PARKED AND SHUT OFF. THE CONTACT THEN NOTICED A LARGE AMOUNT OF FLUID LEAKING FROM UNDERNEATH THE VEHICLE. THE CONTACT THEN DISCOVERED A BOLT WAS MISSING FROM THE STEERING RACK TO TH…
Read full complaint
TL* THE CONTACT OWNS A 1997 OLDSMOBILE AURORA. THE CONTACT WAS TURNING IN REVERSE APPROXIMATELY 2 MPH WHEN HE HEARD A LOUD POP. THE VEHICLE WAS PARKED AND SHUT OFF. THE CONTACT THEN NOTICED A LARGE AMOUNT OF FLUID LEAKING FROM UNDERNEATH THE VEHICLE. THE CONTACT THEN DISCOVERED A BOLT WAS MISSING FROM THE STEERING RACK TO THE FRAME. THE RACK AND PINION HOUSING WAS ALSO FRACTURED AND THERE WERE SEVERAL RUSTED BOLTS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.
NHTSA ODI #10356147
102,000 miles · Aug 4, 2009
Steering
1997 OLDSMOBILE AURORA. I HAVE OWNED THIS VEHICLE FOR THE PAST 6 YEARS. OVER THE PAST YEAR, I HAVE NOTICED SOME "PLAY" IN THE TILT STEERING COLUMN. MY RESEARCH HAS REVEALED AN INHERENT PROBLEM THAT THESE MODEL OF CARS HAVE HAD WITH THE PIVOTS IN THE STEERING-TILT MECHANISM BACKING THEMSELVES OUT. ONE DAY I CLIMBED INTO THE CAR …
Read full complaint
1997 OLDSMOBILE AURORA. I HAVE OWNED THIS VEHICLE FOR THE PAST 6 YEARS. OVER THE PAST YEAR, I HAVE NOTICED SOME "PLAY" IN THE TILT STEERING COLUMN. MY RESEARCH HAS REVEALED AN INHERENT PROBLEM THAT THESE MODEL OF CARS HAVE HAD WITH THE PIVOTS IN THE STEERING-TILT MECHANISM BACKING THEMSELVES OUT. ONE DAY I CLIMBED INTO THE CAR TO BACK DOWN THE DRIVEWAY, AND THE WHOLE STEERING ASSEMBLY JUST PLOPPED INTO MY LAP. I SUSPECTED THE PIVOTS WERE TO BLAME, SO I BEGAN REMOVAL OF THE JUNK AROUND THE STEERING COLUMN, ENOUGH TO GET A VIEW OF THE PIVOTS, AND TO MY DISMAY, I DISCOVERED THAT THE PIVOT ON ONE SIDE HAD WORKED LOOSE, BUT THE CAST METAL THAT SURROUNDS THE PIVOT ON THE OTHER SIDE HAD BROKEN COMPLETELY. I CAN THINK OF NO OTHER REMEDY THAN TO REPLACE THE ENTIRE COLUMN. *TR
NHTSA ODI #10279380
115,000 miles · Mar 9, 2005
Steering
WHEN I TRY TO START MY VEHICLE I AM FORCED AT TIMES TO SIT AND WAIT 3 MINUTES BEFORE THE CAR WILL START DUE TO THE PASS-KEY THEFT-DETERRENT SYSTEM. I HAVE REPLACED MY KEY AND CLEANED THE IGNITION SWITCH WITH ELECTRONIC CONTACT CLEANER. NOTHING HELPED. SOME DAYS / WEEKS / MONTHS ARE BETTER THEN OTHERS. THE MAX TIME I HAD TO SIT A…
Read full complaint
WHEN I TRY TO START MY VEHICLE I AM FORCED AT TIMES TO SIT AND WAIT 3 MINUTES BEFORE THE CAR WILL START DUE TO THE PASS-KEY THEFT-DETERRENT SYSTEM. I HAVE REPLACED MY KEY AND CLEANED THE IGNITION SWITCH WITH ELECTRONIC CONTACT CLEANER. NOTHING HELPED. SOME DAYS / WEEKS / MONTHS ARE BETTER THEN OTHERS. THE MAX TIME I HAD TO SIT AND WAIT WAS 12 MINUTES. HEAVEN FORBID I HAVE TO DRIVE AWAY IN A LIFE OR DEATH SITUATION.*AK
NHTSA ODI #10112759
117,000 miles · Feb 19, 2004
Steering
WHEN MAKING LEFT TURNS IT WAS DIFFICULT TO STEER AND THE STEERING WHEEL BECAME STIFF. DEALER INDICATED THAT THERE WAS NO RECALL ON THIS VEHICLE. *AK *MR
NHTSA ODI #10053878
68,000 miles · Jan 30, 2004
Steering
STEERING WHEEL ALMOST COMPLETELY OFF IN MY SON'S HAND.. SERVICE MANAGER SAID THE CAR SHOULD OF NEVER BEEN SOLD. THIS DEFAULT COULD OF KILLED MY SON. THIS CAR STAYED IN THE SHOP MORE THAN IT WAS DROVE. ONE PROBLEM AFTER THE OTHER. I GAVE THE CAR BACK TO KINGS NISSAN WHEN ANOTHER PROBLEM WITH WIRING AND FUSE CAME UP. MECHANIC SA…
Read full complaint
STEERING WHEEL ALMOST COMPLETELY OFF IN MY SON'S HAND.. SERVICE MANAGER SAID THE CAR SHOULD OF NEVER BEEN SOLD. THIS DEFAULT COULD OF KILLED MY SON. THIS CAR STAYED IN THE SHOP MORE THAN IT WAS DROVE. ONE PROBLEM AFTER THE OTHER. I GAVE THE CAR BACK TO KINGS NISSAN WHEN ANOTHER PROBLEM WITH WIRING AND FUSE CAME UP. MECHANIC SAID THE CAR WOULD END UP CATCHING ON FIRE. I HAD ENOUGH. THIS COMPANY IS VERY RUDE AND DOES NOT TAKE CARE OF THEIR CUSTOMERS OR COMPLAINTS.
NHTSA ODI #10056207
115,000 miles · Jan 13, 2004
Steering
No narrative supplied in this record.
NHTSA ODI #10053038
97,675 miles · Sep 24, 2003
Steering
LOSS OF ABILITY TO STEER TO LEFT IN 1997 AURORA
NHTSA ODI #10039491
Mileage unknown · Mar 27, 2003
Steering
WHEN THE CONSUMER ATTEMPTED TO MAKE A LEFT TURN, THE STEERING WHEEL TURNED, HOWEVER THE FRONT TIRES DID NOT TURN. *JB
NHTSA ODI #10014604
Mileage unknown · Dec 10, 2002
Steering
ECONSUMER STATES WHILE MAKING A LEFT TURN THE STEERING WHEEL LOCKS UP. TS
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
1997 Oldsmobile Aurora Problems, Complaints & Recalls | Skip That Year
Illustration