IllustrationWHILE DRIVING APPROXIMATELY 30 MPH DRIVER SMELLED GAS COMING THROUGH THE VENTS. DRIVER WAS ABLE TO PULL OVER. VEHICLE WAS TOWED TO THE BODY SHOP, AND MECHANIC DETERMINED THAT THE FUEL RAIL NEEDED TO BE REPLACED. *AK
1997 Oldsmobile Aurora
Owner reports · Recalls · Investigations
More warning signs than most Aurora years
Owner complaints for the 1997 Oldsmobile Aurora are substantially higher than the model-year median of 33.
About this comparison →How this year compares
Owner complaints by model year
Compare all Aurora years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
625–50K
1150–75K
575–100K
23100–150K
8150K+
54 reports with mileage · 71 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports17 fire reports1 injury reports
Fuel System, Gasoline complaints
46 reportsCONSUMER SMELLED GAS FUMES COMING INTO VEHICLE THROUGH THE VENT. CONSUMER LIFTED UP THE HOOD, AND UNSCREWED THE COVER FROM THE ENGINE. THEN, NOTICED A GASOLINE LEAK. CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THERE WAS A FUEL RAIL LEAK. *AK
THERE WAS A STRONG FUEL ODOR WHICH HAD ENTERED THE INSIDE OF THE VEHICLE WHILE THE VEHICLE WAS IN MOTION. THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALERSHIP. THE MECHANIC REPLACED THE FUEL RAIL SYSTEM BECAUSE OF A LEAK PROBLEM. *AK THE FUEL RAIL WAS REPLACED DUE TO THE LEAK BETWEEN THE TWO INJECTORS. *SCC *JB
MY CAR IS A 1997 OLDSMOBILE AURORA, 59,000.00 MILES. RECENTLY HAD A FUEL LINE LEAK, SO BAD IT WAS DRIPPING FROM UNDER MY CAR. COULD HAVE BEEN SERIOUS PROBLEMS, BUT HAD IT TAKEN TO MY AUTO REPAIR IMMEDIATELY. HE SAID HE HAD NEVER SEEN ANYTHING LIKE IT BEFORE. REPAIRS AROUND $2000.00 , I HAVE RECEIPTS. *LA
THE VEHICLE WAS PARKED IN THE GARAGE. THE DRIVER BEGAN TO SMELL GAS FUMES THROUGHOUT THE HOUSE. TOOK VEHICLE TO THE DEALER. THE DEALER STATED VEHICLE HAD A BAD FUEL RAIL. DEALER BELIEVED THAT IF THE HOUSE FURNACE WAS LIT THEN THE FUMES FROM THE VEHICLE MIGHT HAVE IGNITED A FIRE IN THE HOUSE. *AK
PLASTIC HOSES BETWEEN PRESSURIZED FUEL INJECTORS, CAN RUPTURE CAUSING POSSIBLE ENGINE FIRE/EXPLOSION HAZARD.*AK
FUEL RAIL LEAKING FUEL IN CLOSE PROXIMITY TO PLUG WIRES. I HAVE NOTICED A HIGH NUMBER OF AURORA'S FOR SALE AS SALVAGE THAT HAVE SUFFERED ENGINE FIRES. IS THIS RELATED?*AK
THE CONSUMER SMELLED GAS ODOR WHILE IN THE GARAGE WHILE HIS WIFE WAS DRIVING THE VEHICLE THE NEXT DAY THE VEHICLE SUDDENLY EXPLODED AND SMOKE AND FLAME POURED FROM UNDER THE HOOD. THE DRIVER WAS ABLE TO EXIT THE VEHICLE QUICKLY WITHOUT INJURIES. THE VEHICLE WAS TOTALED. THE MANUFACTURER WAS CONTACTED AND SENT AND INSPECTOR T…
Read full complaint
THE CONSUMER SMELLED GAS ODOR WHILE IN THE GARAGE WHILE HIS WIFE WAS DRIVING THE VEHICLE THE NEXT DAY THE VEHICLE SUDDENLY EXPLODED AND SMOKE AND FLAME POURED FROM UNDER THE HOOD. THE DRIVER WAS ABLE TO EXIT THE VEHICLE QUICKLY WITHOUT INJURIES. THE VEHICLE WAS TOTALED. THE MANUFACTURER WAS CONTACTED AND SENT AND INSPECTOR TO EXAMINE THE VEHICLE. THE INSPECTOR STATED THAT THE CAUSE OF THE PROBLEM COULD NOT BE FOUND THEREFORE THE MANUFACTURER ACCEPTED NO RESPONSIBILITY. A MECHANIC TOLD THE CONSUMER THAT HE FIXED FUEL RAIL LEAKS ON SEVERAL OTHER OLDSMOBILE AURORA. *PH *NLM
FUEL RAIL BURST WHILE DRIVING. FUEL SPILLED ALL OVER THE ENGINE. STRONG GAS ODOR SMELL. APPEARS TO BE POTENTIAL FIRE/EXPLOSION HAZARD.*AK
THREE OF THE VEHICLES EIGHT FUEL LINES RUPTURED WHICH CAUSED FUEL TO SPRAY ONTO THE HOT ENGINE, EXHAUST SYSTEM AND ONTO THE GROUND. THE CONSUMER COULD SMELL THE FUEL BUT COULDN'T SEE IT BECAUSE OF A COVER UNDER THE FUEL LINES. *JB *CB *NLM
Official recalls
104V110000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Mar 4, 2004
SOME PASSENGER VEHICLES EQUIPPED WITH 4.0L V8 ENGINES HAVE A CONDITION IN WHICH THE NYLON TUBING USED IN THE FUEL RAIL CONSTRUCTION MAY DEGRADE AND CRACK. ADDITIONALLY, THE 1995 MODEL YEAR USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY CRACK. CRACKING OF THE FUEL RAIL OR RETURN LINE TUBING CAN RESULT IN A FUEL LEAK INTO THE ENGINE COMPARTMENT.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE ENGINE FUEL RAIL WITH A NEW STAINLESS STEEL FUEL RAIL. DEALERS WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE. THE RECALL BEGAN ON JUNE 2, 2004, FOR 1996-1997 OLDSMOBILE AURORA VEHICLES. OWNERS OF 1995 CADILLACS AND 1996-1997 OLDSMOBILE AURORA WERE SENT LETTERS ON AUGUST 6, 2004. ADDITIONAL LETTERS TO OWNERS WILL BE FORTHCOMING. OWNERS SHOULD CONTACT OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.