NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
46 reportsClear category filterMileage unknown · May 4, 2007
Fuel System, Gasoline
TL*THE CONTACT OWNS A 1997 OLDSMOBILE AURORA. THE CONTACT RECEIVED RECALL NOTICE # 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE DEALER WAS WILLING TO REPLACE THE FUEL RAIL, BUT NOT THE FUEL LINE. THE DEALER CLAIMED THAT THE RECALL WAS ISSUED BY THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTR…
Read full complaint
TL*THE CONTACT OWNS A 1997 OLDSMOBILE AURORA. THE CONTACT RECEIVED RECALL NOTICE # 04V110000 (FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS). THE DEALER WAS WILLING TO REPLACE THE FUEL RAIL, BUT NOT THE FUEL LINE. THE DEALER CLAIMED THAT THE RECALL WAS ISSUED BY THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION AND NOT FULLY BY THE MANUFACTURER. THEY ALSO STATED THAT THE REPAIR AGREEMENT ONLY COVERED REPLACING THE FUEL RAIL. THE CURRENT AND FAILURE MILEAGES WERE UNKNOWN.
NHTSA ODI #10189768
72,000 miles · Oct 23, 2006
Fuel System, GasolineFire
DT*: THE CONTACT STATED WHILE STOPPED AT A TRAFFIC LIGHT, BLACK SMOKE EMANATED FROM UNDER THE HOOD OF THE VEHICLE. WITHIN 8 SECONDS OF THE CONTACT EXITING THE VEHICLE, FLAMES WERE OBSERVED COMING FROM UNDER THE FRONT WHEEL WELLS, AND FROM UNDER THE HOOD. THE HOOD MELTED, THE ENGINE WAS BURNED COMPLETELY, THE FRONT AXLE MELTED …
Read full complaint
DT*: THE CONTACT STATED WHILE STOPPED AT A TRAFFIC LIGHT, BLACK SMOKE EMANATED FROM UNDER THE HOOD OF THE VEHICLE. WITHIN 8 SECONDS OF THE CONTACT EXITING THE VEHICLE, FLAMES WERE OBSERVED COMING FROM UNDER THE FRONT WHEEL WELLS, AND FROM UNDER THE HOOD. THE HOOD MELTED, THE ENGINE WAS BURNED COMPLETELY, THE FRONT AXLE MELTED TO THE POINT OF PREVENTING ANY MOVEMENT OF THE FRONT WHEELS, AND THE ENTIRE DASH WAS MELTED. THE VEHICLE WAS CONSIDERED A TOTAL LOSS. POLICE AND FIRE REPORTS WERE TAKEN. THE FIRE DEPARTMENT DETERMINED THAT THE CAUSE OF THE FIRE WAS A FUEL LEAK. THERE WAS A NHTSA RECALL #04V110000 WHICH PERTAINS TO THE PIPINGS AND FITTINGS TO THE FUEL SYSTEM. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10171596
133,000 miles · Oct 19, 2006
Fuel System, Gasoline
WHILE DRIVING VEHICLE NOTICED STRONG GASOLINE ODOR. WITH ENGINE RUNNING A FINE MIST OF GASOLINE WAS SHOOTING ACROSS ENGINE COMPARTMENT FROM A PINHOLE IN A PLASTIC FUEL DELIVERY LINE (HIGH PRESSURE?) NEAR THE FITTING CONNECTING IT TO THE METAL FUEL RAIL LINE. (FUEL RAIL WAS REPLACED 6/05 UNDER RECALL #04014) NEITHER THE LEAK NO…
Read full complaint
WHILE DRIVING VEHICLE NOTICED STRONG GASOLINE ODOR. WITH ENGINE RUNNING A FINE MIST OF GASOLINE WAS SHOOTING ACROSS ENGINE COMPARTMENT FROM A PINHOLE IN A PLASTIC FUEL DELIVERY LINE (HIGH PRESSURE?) NEAR THE FITTING CONNECTING IT TO THE METAL FUEL RAIL LINE. (FUEL RAIL WAS REPLACED 6/05 UNDER RECALL #04014) NEITHER THE LEAK NOR THE PINHOLE IS VISIBLE WHEN ENGINE IS NOT RUNNING. EXTREME FIRE HAZARD! VEHICLE CURRENTLY AT GM DEALERSHIP FOR REPLACEMENT OF FUEL LINES (LINES MARKED NON-REPAIRABLE) (REPAIR ESTIMATE APPROX $500). WEB SEARCH REVEALED NUMEROUS SIMILAR COMPLAINTS. CONTACTED OLDS CUSTOMER SERVICE AND WAS TOLD THAT THERE WAS NOTHING THEY COULD DO DUE TO THE AGE OF THE VEHICLE. APPEARS TO BE A HIGH-HAZARD SITUATION THAT COULD EASILY RESULT IN PROPERTY DAMAGE, INJURY AND/OR DEATH. *NM
NHTSA ODI #10171383
125,000 miles · Aug 18, 2006
Fuel System, Gasoline
DT*: THE CONTACT STATED THE NYLON TUBING IN THE FUEL RAIL DEGRADED WHICH CAUSED FUEL TO LEAK ALL OVER THE ENGINE. THERE WAS A NHTSA RECALL, # 04V110000 REGARDING THE FUEL SYSTEM, GASOLINE: DELIVERY: HOSES, LINES/PIPING, AND FITTINGS. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.
NHTSA ODI #10165953
Mileage unknown · Jan 21, 2005
Fuel System, GasolineFire
WHILE WAITING AT A RED LIGHT, CONSUMER NOTICED THAT THE VEHICLE CAUGHT ON FIRE. WHEN INVESTIGATED IT WAS DETERMINED TO BE DUE TO THE FUEL RAIL. *NM
NHTSA ODI #10108670
Mileage unknown · Jan 19, 2005
Fuel System, GasolineFire
THE FUEL LINE WAS LEAKING FUEL AND CAUSED THE VEHICLE TO CATCH ON FIRE. *JB
NHTSA ODI #10108513
103,000 miles · Oct 1, 2004
Fuel System, Gasoline
RECALL 04V110000 CONCERNING FUEL RAIL TUBING. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR SERVICE, AND HAD THE RECALL NOTICE TOO. DEALER STILL CHARGED CONSUMER $423.63 FOR REPAIRS, BUT HAD GIVEN CONSUMER A REIMBURSEMENT FORM TO SEND TO THE MANUFACTURER. CONSUMER MADE SEVERAL ATTEMPTS TO CONTACT THE MANUFACTURER, AND WAS GETT…
Read full complaint
RECALL 04V110000 CONCERNING FUEL RAIL TUBING. CONSUMER TOOK THE VEHICLE TO THE DEALER FOR SERVICE, AND HAD THE RECALL NOTICE TOO. DEALER STILL CHARGED CONSUMER $423.63 FOR REPAIRS, BUT HAD GIVEN CONSUMER A REIMBURSEMENT FORM TO SEND TO THE MANUFACTURER. CONSUMER MADE SEVERAL ATTEMPTS TO CONTACT THE MANUFACTURER, AND WAS GETTING NO WHERE TO BE REIMBURSED. *AK
NHTSA ODI #10094810
Mileage unknown · Aug 27, 2004
Fuel System, Gasoline
WHILE DRIVING SMELLED SMELLED GAS FUMES COMING IN FROM THE VENTS. CONSUMER PULLED OVER TO THE SHOULDER, LIFTED UP THE HOOD, AND NOTICED GASOLINE LEAKING FROM THE HOLE. WAS DROVE VEHICLE TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT FUEL RAIL NEEDED TO BE REPLACED. *AK
NHTSA ODI #10089913
Mileage unknown · Aug 18, 2004
Fuel System, Gasoline
WHILE VEHICLE WAS PARKED CONSUMER NOTICED THAT LIQUID WAS LEAKING FROM UNDERNEATH THE VEHICLE. CONSUMER COULD NOT START UP THE VEHICLE, AND HAD IT TOWED TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. CONSUMER WAS CONCERNED THAT DEALER AND MANUFACTURER DID NOT DECIDE WHO WOULD…
Read full complaint
WHILE VEHICLE WAS PARKED CONSUMER NOTICED THAT LIQUID WAS LEAKING FROM UNDERNEATH THE VEHICLE. CONSUMER COULD NOT START UP THE VEHICLE, AND HAD IT TOWED TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL SYSTEM NEEDED TO BE REPLACED. CONSUMER WAS CONCERNED THAT DEALER AND MANUFACTURER DID NOT DECIDE WHO WOULD PAY FOR REPAIRS. *AK
NHTSA ODI #10089207
Mileage unknown · Aug 11, 2004
Fuel System, GasolineFire
CONSUMER RECEIVED NHTSA RECALL 04V110000 FOR THE FUEL RAIL TUBING; BEFORE THE VEHICLE COULD HAVE RECALL REPAIRS PERFORMED VEHICLE CAUGHT ON FIRE WHILE PARKED AT A GAS STATION. AFTER HAVING THE VEHICLE INSPECTED BY AN OLDSMOBILE SERVICE MANAGER,WHO INSISTED THAT THE FIRE WAS RELATED TO THE FUEL RAIL, BUT CLAIMED MINIMUM RESP…
Read full complaint
CONSUMER RECEIVED NHTSA RECALL 04V110000 FOR THE FUEL RAIL TUBING; BEFORE THE VEHICLE COULD HAVE RECALL REPAIRS PERFORMED VEHICLE CAUGHT ON FIRE WHILE PARKED AT A GAS STATION. AFTER HAVING THE VEHICLE INSPECTED BY AN OLDSMOBILE SERVICE MANAGER,WHO INSISTED THAT THE FIRE WAS RELATED TO THE FUEL RAIL, BUT CLAIMED MINIMUM RESPONSIBILITY.*AK
NHTSA ODI #10087710
NHTSA investigations
2EA04003 · Fuel Rail Leaks
Opened Feb 3, 2004 · Closed Apr 23, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Additional source detail variants (3)
Fuel System, Gasoline:delivery
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
Fuel System, Gasoline
ON MARCH 3, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS RECALLING APPROXIMATELY 94,000 MY 1995-97 OLDSMOBILE AURORA VEHICLES EQUIPPED WITH 4.0L V8 ENGINES (RPO L47 - VIN8 C) TO ADDRESS CONCERNS WITH UNDERHOOD FUEL LEAKAGE FROM CRACKED FUEL RAILS AND, IN SOME OF THE VEHICLES, CRACKED FUEL RETURN LINES. ACCORDING TO GM, THE NYLON TUBING (PA12) USED IN THE FUEL RAIL CONSTRUCTION IN THESE VEHICLES MAY DEGRADE AND CRACK.GM'S SUPPLIER ATTRIBUTED THE CRACKING TO THE COMBINED EFFECTS OF HEAT, TIME, ALCOHOL FUEL, FUEL PRESSURE CYCLING, AND DESIGN STRESSES.IN ADDITION, GM STATED THAT THE MY 1995 AURORA USES A UNIQUE UNDERHOOD FUEL RETURN LINE THAT MAY ALSO CRACK AT UNUSUALLY HIGH RATES.GM DEALERS WILL INSTALL A NEW FUEL RAIL CONSTRUCTED OUT OF STAINLESS STEEL IN ALL OF THE RECALLED VEHICLES AND WILL ALSO INSTALL A REVISED CHASSIS FUEL RETURN LINE IN THE MY 1995 AURORAS. ON APRIL 16, 2004, GENERAL MOTORS NOTIFIED ODI THAT IT WAS ADDING APPROXIMATELY 389,000 MY 1995-97 CADILLAC SEVILLE, DEVILLE AND ELDORADO VEHICLES EQUIPPED WITH 4.6L V8 ENGINES (RPO'S LD8 AND L37 - VIN8 Y AND 9) TO RECALL 04V-110.THE RECALLED CADILLACS WILL RECEIVE THE NEW STAINLESS STEEL FUEL RAILS.THIS ENGINEERING ANALYSIS IS CLOSED.
PE03050 · Fuel Rail Leakage
Opened Oct 30, 2003 · Closed Feb 3, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail
THE FUEL RAIL ASSEMBLIES USED IN THE SUBJECT VEHICLES WERE MANUFACTURED BY DANA.THE FUEL RAIL JUMPER TUBES WERE MADE OF MONOLAYER NYLON 12 (PA12).IN MODEL YEAR (MY) 1998, THE JUMPER TUBE MATERIAL WAS CHANGED FROM PA12 TO M-BOND (A MULTI-LAYER PTFE/PA12).IN ADDITION, ALL SERVICE PARTS PRODUCED SINCE THE END OF PRODUCTION 1997 USE THE M-BOND JUMPER TUBES. MATERIAL ANALYSIS PERFORMED BY DANA ON FAILED FUEL RAILS SHOWED THAT THE MONO-LAYER NYLON 12 JUMPER TUBES ARE SUSCEPTIBLE TO ENVIRONMENTAL STRESS CRACKING (ESC).GM BELIEVES THE ESC IS A RESULT OF HEAT, TIME, ALCOHOL BLENDED FUEL, FUEL PRESSURE CYCLING, AND DESIGNED IN STRESS. EIGHT OF THE GM COMPLAINTS ARE DUPLICATIVE OF ODI COMPLAINTS.ODI HAS RECEIVED 77 OF IT'S 123 COMPLAINTS IN THE PAST 12 MONTHS.FUEL RAIL PART SALES OVER THE LAST THREE YEARS RANGE FROM 3.0 PERCENT OF PRODUCTION FOR THE MY 1997 CADILLAC VEHICLES TO 13.1 PERCENT FOR THE MY 1995 AURORAS.AT LEAST ONE OF THE FIRE INCIDENTS OCCURED WHILE THE VEHICLE WAS PARKED WITHIN A GARAGE ATTACHED TO THE CONSUMERS HOME.THE FIRE RESULTED IN DAMAGE TO THE DWELLING AS WELL AS THE TOTAL LOSS OF THE VEHICLE.THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS.
Illustration