NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
891 reports8,600 miles · Nov 10, 2005
Power Train
CATASTROPHIC REAR DIFFERENTIAL FAILURE. WAS LEAVING WORK AND EVERYTHING SEEMED FINE, CAME TO STOP AT STOPSIGN, HIT THROTTLE TO GO AND BANG, THE REAR BLEW. AFTERWARDS THE TRUCK WOULD NOT MOVE, BUT THE DRIVESHAFT WAS SPINNING AND BAD GRINDING AND CLUNKING SOUNDS COULD BE HEARD. I'M SURE NISSAN IS GOING TO REPLACE THE AXEL ASSEMBLY…
Read full complaint
CATASTROPHIC REAR DIFFERENTIAL FAILURE. WAS LEAVING WORK AND EVERYTHING SEEMED FINE, CAME TO STOP AT STOPSIGN, HIT THROTTLE TO GO AND BANG, THE REAR BLEW. AFTERWARDS THE TRUCK WOULD NOT MOVE, BUT THE DRIVESHAFT WAS SPINNING AND BAD GRINDING AND CLUNKING SOUNDS COULD BE HEARD. I'M SURE NISSAN IS GOING TO REPLACE THE AXEL ASSEMBLY ALTHOUGH IT IS STILL IN THE SHOP. I HAVE CORRESPONDED WITH OTHERS WHO HAVE HAD THIS HAPPEN, AND THE REAR IS ALWAYS REPLACED AS A UNIT, AND NISSAN ISN'T REALLY ACNOWLEDGING THAT A PROBLEM EXISTS, ALTHOUGH SOME HAVE GONE THROUGH 3 REAR ENDS. AS FAR AS I KNOW, THEY ALL HAVE THE ELECTRONIC LOCKING DIFFERENTIAL OPTION. NOBODY WAS HURT, BUT I WOULDN'T WANT TO SEE WHAT WOULD HAPPEN IF IT FAILED ON THE HIGHWAY. *NM
NHTSA ODI #10142368
250 miles · Nov 3, 2005
Fuel System, Gasoline
WITH 1/4 TANK OF GAS OR LESS LEFT IN FUEL TANK,GAS POURS BACK OUT WHEN FILLING FROM ANY GAS STATION.GAS PUMP WILL CLICK WITHIN 10-15 SECONDS OF GETTING GAS AND UP COMES GAS FROM THE TANK.WHEN A PUMP CLICKS,YOUR TANK IS SUPPOSE TO BE FULL.BUT IN THIS SITUATION,IT DOESN'T EVEN COME CLOSE TO BEING FULL.IT HAPPENED TO ME WHEN IT GOT…
Read full complaint
WITH 1/4 TANK OF GAS OR LESS LEFT IN FUEL TANK,GAS POURS BACK OUT WHEN FILLING FROM ANY GAS STATION.GAS PUMP WILL CLICK WITHIN 10-15 SECONDS OF GETTING GAS AND UP COMES GAS FROM THE TANK.WHEN A PUMP CLICKS,YOUR TANK IS SUPPOSE TO BE FULL.BUT IN THIS SITUATION,IT DOESN'T EVEN COME CLOSE TO BEING FULL.IT HAPPENED TO ME WHEN IT GOT AROUND 2-3 GALLONS INTO THE FILL UP.OTHER OWNERS OF THIS TRUCK(NISSAN TITAN '04-'05) HAVE THIS SAME PROBLEM.DEALER HAS AVOIDED FIXING THIS ISSUE.THIS IS A SAFETY ISSUE THAT NISSAN MUST FIX.A COUPLE GALLONS OF GAS POURING OUT OF THIS TRUCK AT EVERY FILL UP IS DANGEROUS FOR ME AND THE PEOPLE AROUND THE GAS STATION.I HAVE 2 KIDS AND I HESITATE EVERYTIME I FILL MY TRUCK UP WITH THEM INSIDE.PLEASE INVESTIGATE AND SEE THAT NISSAN FIX THIS PROBLEM.THE FORUM ON THIS IS FOUND AT "TITANTALK.COM(GAS TANK ISSUES)".
NHTSA ODI #10141707
8,000 miles · Oct 20, 2005
Air Bags
MY 125 LB WIFE DOES NOT ACTIVATE THE SEAT SENSOR FOR THE AIRBAG IN MY 05 NISSAN TITAN. WHILE IT DOESN'T HAPPEN 100% OF THE TIME, IT HAS OCCURRED REPEATEDLY. THE DEALER CHECKED & CONFIRMED THAT THE SYSTEM IS OPERATING NORMALLY AND STATED THAT THEY COULD DO NOTHING MORE. AT THIS POINT MY WIFE IS RIDING IN OUR TRUCK WITHOUT AN AIRB…
Read full complaint
MY 125 LB WIFE DOES NOT ACTIVATE THE SEAT SENSOR FOR THE AIRBAG IN MY 05 NISSAN TITAN. WHILE IT DOESN'T HAPPEN 100% OF THE TIME, IT HAS OCCURRED REPEATEDLY. THE DEALER CHECKED & CONFIRMED THAT THE SYSTEM IS OPERATING NORMALLY AND STATED THAT THEY COULD DO NOTHING MORE. AT THIS POINT MY WIFE IS RIDING IN OUR TRUCK WITHOUT AN AIRBAG. WHILE SHE DOES WEAR A SEAT BELT, I WOULD LIKE TO HAVE THE COMFORT OF KNOWING THE FULL SAFETY SYSTEM IS OPERATIONAL IN THE EVENT OF AN ACCIDENT. RESEARCH AND OTHER COMPLAINTS POSTED HERE SHOW THAT THIS IS NOT AN ISOLATED PROBLEM. *NM
NHTSA ODI #10140356
Mileage unknown · Oct 13, 2005
Service Brakes, Hydraulic
2005 NISSAN TITAN LE 5.6 4/4 KING CAB VIN# [XXX]; I TOOK MY TRUCK TO THE DEALER 10/06/05 TO REPLACE A COOLING FAN THAT THEY ORDERED 3 WEEKS AGO AND CHECK MY BRAKES. THE BRAKE PEDAL GOES TO THE FLOOR WHEN YOU ARE STOPPED OR COMING TO A STOP. YOU HAVE TO PUMP IT UP TO BRING IT BACK UP. THEY INSTALLED THE FAN AND TOLD ME THERE …
Read full complaint
2005 NISSAN TITAN LE 5.6 4/4 KING CAB VIN# [XXX]; I TOOK MY TRUCK TO THE DEALER 10/06/05 TO REPLACE A COOLING FAN THAT THEY ORDERED 3 WEEKS AGO AND CHECK MY BRAKES. THE BRAKE PEDAL GOES TO THE FLOOR WHEN YOU ARE STOPPED OR COMING TO A STOP. YOU HAVE TO PUMP IT UP TO BRING IT BACK UP. THEY INSTALLED THE FAN AND TOLD ME THERE IS NOTHING WRONG WITH THE BRAKES AS SOME OF THE OTHER MODELS DO THE SAME THING. THE BRAKE CYLINDER FLUID WAS FULL. IT SCARES ME TO DRIVE WITH THE PEDAL GOING TO THE FLOOR. THE FLUID HAS TO BE GOING SOMEWHERE MAYBE BYPASSING THE SEALS AS THIS IS A CLOSED SYSTEM. I HAD TO CALL CUSTOMER SERVICE TO HAVE THE FAN REPLACED AND THEY SAID THERE WERE VERY FEW REPLACEMENT PARTS AVAILABLE FOR THESE TRUCKS(3WKS FOR A FAN). I NEED HELP AS I DON'T WANT TO KILL SOMEONE OR MYSELF. NISSAN DOES NOT CARE. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10139584
7,500 miles · Oct 12, 2005
Power Train
NO PRIOR EVENTS LEADING TO FAILURE. THE VEHICLE WAS DRIVEN NORMALLY ACCORDING TO MANUFACTURERS RECOMMENDED PROCEDURE. THE REAR DIFFERENTIAL OF MY 2004 NISSAN TITAN BROKE 4 TIMES, FIRST TIME WAS AT 6,000 MILES, THEN EVERY 3,000 MILES THERE AFTER. NISSAN THEN REPLACED FREE OF CHARGE WITH A 2005 IN WHICH THE REAR DIFFERENTIAL HAS …
Read full complaint
NO PRIOR EVENTS LEADING TO FAILURE. THE VEHICLE WAS DRIVEN NORMALLY ACCORDING TO MANUFACTURERS RECOMMENDED PROCEDURE. THE REAR DIFFERENTIAL OF MY 2004 NISSAN TITAN BROKE 4 TIMES, FIRST TIME WAS AT 6,000 MILES, THEN EVERY 3,000 MILES THERE AFTER. NISSAN THEN REPLACED FREE OF CHARGE WITH A 2005 IN WHICH THE REAR DIFFERENTIAL HAS NOW BROKE 1 TIME. WHEN THE DIFFERENTIAL BREAKS THE VEHICLE IS IMMOBILIZED AND SOMETIMES LEFT IN HARMS WAY (I.E. UNABLE TO GET OUT OF THE MIDDLE OF AN INTERSECTION, TOWING DOWNHILL AND THE DIFFERENTIAL BREAKS MAKING THE VEHICLE VERY HARD TO STOP) NISSAN HAS REPLACED 3 REAR DIFFERENTIALS IN THE 2004 VEHICLE. THEY THEN GAVE A NEW 2005 NISSAN TITAN TO ME. NISSAN HAS REPAIRED 1 REAR DIFFERENTIAL IN THIS VEHICLE. I DO NOT TRUST THIS VEHICLE AND FEEL UNSAFE DRIVING IT AS I AM NOT SURE WHEN THE NEXT FAILURE WILL HAPPEN. THE INCIDENT DATE BELOW IS THE MOST RECENT ONE.*JB
NHTSA ODI #10139423
3,095 miles · Oct 10, 2005
Power Train
(1)REAR END BRAKES NO MOVEMENT WHILE DRIVING (2)FORTUNATELY INCIDENT HAPPENED AT NIGHT WITH NOT A LOT OF TRAFFIC AND NO ACCIDENT HAPPENED, HOWEVER IF THIS HAPPENED DURING THE DAY IT COULD HAVE CAUSED A MAJOR ACCIDENT. THE VEHICLES REAR END, DRIVING FORCE, FAILED CAUSING THE VEHICLE TO STOP WHILE DRIVING AND ROLL BACKWARDS WHILE…
Read full complaint
(1)REAR END BRAKES NO MOVEMENT WHILE DRIVING (2)FORTUNATELY INCIDENT HAPPENED AT NIGHT WITH NOT A LOT OF TRAFFIC AND NO ACCIDENT HAPPENED, HOWEVER IF THIS HAPPENED DURING THE DAY IT COULD HAVE CAUSED A MAJOR ACCIDENT. THE VEHICLES REAR END, DRIVING FORCE, FAILED CAUSING THE VEHICLE TO STOP WHILE DRIVING AND ROLL BACKWARDS WHILE GAS PEDAL IS PRESSED. (3)VEHICLE WAS PUT INTO 4HI TO GET HOME, THIS OCCURED SATURDAY NIGHT, HAVE TO WAIT TILL MONDAY TO HAVE VEHICLE TOWED TO NISSAN DEALERSHIP. *JB
NHTSA ODI #10139173
4,800 miles · Oct 4, 2005
Service Brakes, Hydraulic
NISSAN TITAN BRAKES LOCKING, TIRES SCREECHING, SHAKING IN FRONT END AT ONLY 4800 MILES OF DRIVING. *JB
NHTSA ODI #10138477
4,000 miles · Sep 25, 2005
Service Brakes, Hydraulic
FRONT BRAKE SHUDDER - LESS THAN 4000 MILES - REVIEWED MANY COMPLAINTS ON NHTSA SITE OF EXACT SAME PROBLEM - WILL CONTACT DEALER AND PLAY THE GAME THAT EVERYONE ELSE SEEMS TO HAVE TO PLAY - CONSTANT TRIPS TO DEALER FOR REPAIR/REPLACEMENT OF ROTOR. WOULD SAVE SERIOUS GRIEF ON ALL PARTIES IF RECALL WAS SIMPLY ISSUED AND SITUATION…
Read full complaint
FRONT BRAKE SHUDDER - LESS THAN 4000 MILES - REVIEWED MANY COMPLAINTS ON NHTSA SITE OF EXACT SAME PROBLEM - WILL CONTACT DEALER AND PLAY THE GAME THAT EVERYONE ELSE SEEMS TO HAVE TO PLAY - CONSTANT TRIPS TO DEALER FOR REPAIR/REPLACEMENT OF ROTOR. WOULD SAVE SERIOUS GRIEF ON ALL PARTIES IF RECALL WAS SIMPLY ISSUED AND SITUATION FIXED BY REPLACING EQUIPMENT THAT WORKS. *JB
NHTSA ODI #10137532
2,700 miles · Sep 19, 2005
Service Brakes, Hydraulic
DT: THE CONSUMER OWNS A 2005 NISSAN TITAN PICKUP TRUCK AND HAS TO REPLACE THE BRAKES AT 2,700 MILES. THE DEALERSHIP IS THE ONE THAT CHANGED THE BRAKES. THE DEALER SAID THAT IF THEY HAD TO CHANGE THE BRAKES AGAIN TO BRING THE TRUCK BACK IN. THE FRONT ROTORS AND PADS WERE REPLACED, THE BACK ROTORS WERE RESURFACED , AND THE PADS WE…
Read full complaint
DT: THE CONSUMER OWNS A 2005 NISSAN TITAN PICKUP TRUCK AND HAS TO REPLACE THE BRAKES AT 2,700 MILES. THE DEALERSHIP IS THE ONE THAT CHANGED THE BRAKES. THE DEALER SAID THAT IF THEY HAD TO CHANGE THE BRAKES AGAIN TO BRING THE TRUCK BACK IN. THE FRONT ROTORS AND PADS WERE REPLACED, THE BACK ROTORS WERE RESURFACED , AND THE PADS WERE REPLACED. THE TRUCK IS DRIVING FINE NOW. THE CONSUMER HAS NOT CONTACTED NISSAN. *AK
NHTSA ODI #10136992
4,600 miles · Sep 18, 2005
Service Brakes, HydraulicCrashInjury
I WAS DRIVING ON ROUTE "A" STATE BLACKTOP COMING INTO A SHARP CORNER AND WHEN I APPLIED THE BRAKES THE FRONT WHEELS BEGAN TO SHIMMY VERY HARD. IT CAUSED THE 2005 NISSAN TITAN PICKUP TO LOSE CONTACT WITH THE HIGHWAY CAUSING IT TO LEAVE THE ROAD AND OVERTURN. THE TRUCK WAS TOTALED AND I RECEIVED MINOR INJURIES. AIR BAG AND SEAT BE…
Read full complaint
I WAS DRIVING ON ROUTE "A" STATE BLACKTOP COMING INTO A SHARP CORNER AND WHEN I APPLIED THE BRAKES THE FRONT WHEELS BEGAN TO SHIMMY VERY HARD. IT CAUSED THE 2005 NISSAN TITAN PICKUP TO LOSE CONTACT WITH THE HIGHWAY CAUSING IT TO LEAVE THE ROAD AND OVERTURN. THE TRUCK WAS TOTALED AND I RECEIVED MINOR INJURIES. AIR BAG AND SEAT BELT SAVED ME. NISSAN KNOWS THEY HAVE A PROBLEM AND I WAS NOT NOTIFIED ABOUT A POSSIBLE BRAKE PROBLEM UNTIL IT WRECKED ME. THEY SHOULD BE RESPONSIBLE FOR RECALLING ALL THEIR TRUCKS WITH THIS PROBLEM. IF I WOULD HAVE DIED IN THE CRASH, NO ONE WOULD KNOW THE CAUSE. I DO NOT HAVE THE MONEY TO BUY BACK THE TRUCK FROM THE INSURANCE COMPANY FOR THE PROOF OF WARPED ROTORS CAUSING THE ACCIDENT. IT ALSO APPEARED THE REAR BRAKES DID NOT WORK BECAUSE THE ABS SYSTEM WAS CONFUSED? I COULD USE SOME HELP HERE. *NM
NHTSA ODI #10136883
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration