IllustrationREAR END DIFFERENTIAL FLUID LEAK. *TR
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsRIGHT REAR AXLE SEAL LEAKING ONTO BRAKES. *TR
NISSAN IPDM (INTELLIGENT POWER DISTRIBUTION MODULE) WHICH HOUSES THE FUEL PUMP RELAY WILL INADVERTENTLY SHUT OFF POWER TO THE FUEL PUMP. IT HAS HAPPENED TO ME FROM A PARKED VEHICLE AND HAS ALSO HAPPENED TO ME WHILE I WAS DRIVING DOWN THE ROAD. THERE IS NO TIMED SEQUENCE AS TO WHEN THIS HAPPENS, BUT WHEN IT DOES YOU LOSE POWER TO…
Read full complaint
NISSAN IPDM (INTELLIGENT POWER DISTRIBUTION MODULE) WHICH HOUSES THE FUEL PUMP RELAY WILL INADVERTENTLY SHUT OFF POWER TO THE FUEL PUMP. IT HAS HAPPENED TO ME FROM A PARKED VEHICLE AND HAS ALSO HAPPENED TO ME WHILE I WAS DRIVING DOWN THE ROAD. THERE IS NO TIMED SEQUENCE AS TO WHEN THIS HAPPENS, BUT WHEN IT DOES YOU LOSE POWER TO THE VEHICLE IMMEDIATELY. THE VEHICLE WILL RE-START AFTER SITTING FOR 10 MINUTES, BUT MAY CUT OUT AGAIN 15 MINUTES LATER. *TR
REAR AXLE SEALS 2005 NISSAN TITAN PREMATURELY LEAK BECAUSE AXLE NOT VENTED PROPERLY. LEAKING OIL TENDS TO COVER BRAKES. POSSIBLE HAZARD FROM BRAKE FAILURE. *TR
MY 2005 NISSAN TITAN HAD A REAR DIFFERENTIAL FAILURE AT APPROX. 73,000 MILES. THERE WAS A LOUD BANGING/RATCHETING SOUND AND THEN THE FAILURE. NISSAN (OR NO ONE ELSE, FOR THAT MATTER) WILL NOT SELL REPLACEMENT PARTS FOR THIS PROBLEM. YOU CAN ONLY PURCHASE THE "ENTIRE UNIT", AT A COST OF $3500.00, WHICH IS TOTALLY RIDICULOUS, S…
Read full complaint
MY 2005 NISSAN TITAN HAD A REAR DIFFERENTIAL FAILURE AT APPROX. 73,000 MILES. THERE WAS A LOUD BANGING/RATCHETING SOUND AND THEN THE FAILURE. NISSAN (OR NO ONE ELSE, FOR THAT MATTER) WILL NOT SELL REPLACEMENT PARTS FOR THIS PROBLEM. YOU CAN ONLY PURCHASE THE "ENTIRE UNIT", AT A COST OF $3500.00, WHICH IS TOTALLY RIDICULOUS, SINCE IT IS ONLY A PART OF THE ENTIRE UNIT THAT HAS FAILED. I'M AFRAID THAT IF I HAD BEEN AT HIGHWAY SPEED, THAT MYSELF AND/OR OTHERS COULD HAVE BEEN SERIOUSLY INJURED OR EVEN KILLED. *TR
2005 NISSAN TITAN. DOOR LATCH FAILURE DURING COLD WEATHER BELOW FREEZING. LIVE IN ANCHORAGE ALASKA, SO TIME PERIOD OF THIS WEATHER IS OCTOBER - APRIL. DOOR WILL NOT OPEN, NOR CLOSE PROPERLY FROM INSIDE, OR OUTSIDE OF VEHICLE. HAD THIS PROBLEM LAST WEEK, WAS NOT ABLE TO GET BACK INTO VEHICLE FOR 10MIN WHILE CHILD WAS STILL IN BAC…
Read full complaint
2005 NISSAN TITAN. DOOR LATCH FAILURE DURING COLD WEATHER BELOW FREEZING. LIVE IN ANCHORAGE ALASKA, SO TIME PERIOD OF THIS WEATHER IS OCTOBER - APRIL. DOOR WILL NOT OPEN, NOR CLOSE PROPERLY FROM INSIDE, OR OUTSIDE OF VEHICLE. HAD THIS PROBLEM LAST WEEK, WAS NOT ABLE TO GET BACK INTO VEHICLE FOR 10MIN WHILE CHILD WAS STILL IN BACK SEAT. YESTERDAY 2 NOV DRIVING ON A HIGHWAY DOOR OPENED UNEXPECTEDLY AND PASSENGER NEARLY FELL OUT OF VEHICLE. NO ONE INJURED, HOWEVER YOU CAN IMAGINE THE EXPERIENCE AT HIGHWAY SPEEDS. THERE IS A NISSAN TSB THAT THEY WILL REPLACE DOOR LOCKING MECHANISM IF VEHICLE IS UNDER WARRANTY. NISSAN USA: TBNS BX56AA / TSB 05118. HOWEVER IF VEHICLE IS NOT UNDER WARRANTY THEY QUOTED ME AT $400+ PER DOOR X'S 4 DOORS. THIS IS UNREASONABLE AND A SEVERE SAFETY HAZARD FOR MOST OF THE COUNTRY THAT EXPERIENCES WEATHER BELOW 32DEGREES F. IT IS A KNOWN FAILURE THAT NISSAN USA KNOWS ABOUT. THIS SHOULD BE A MANDATED RECALL. THERE WILL BE SEVERE LAWSUITS FILED IF ANOTHER PASSENGER, MY CHILD, OR MYSELF CANNOT GET INTO A VEHICLE, OR UNEXPECTEDLY FALLS OUT. BELOW ARE LINKS TO A NISSAN TITAN ONLINE FORUM WITH MULTIPLE OTHER COMPLAINTS ABOUT THIS. HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-GENERAL-DISCUSSION/49432-FROZEN-DOOR-LATCH-PROBLEM-NOT-SOLVED-PLEASE-ADVISE.HTML HTTP://WWW.TITANTALK.COM/FORUMS/CANADA-FORUM/85666-WINTER-PROBLEMS-TITAN-USA.HTML HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-PROBLEMS-DEALER-SERVICE/83826-FROZEN-DOOR-HANDLES.HTML HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-GENERAL-DISCUSSION/70975-FROZEN-DOORS.HTML HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-PARTS-ACCESSORIES/69105-DOORS-WONT-CLOSE-WHEN-COLD.HTML HTTP://WWW.TITANTALK.COM/FORUMS/TITAN-PROBLEMS-DEALER-SERVICE/33467-NISSAN-NEW-TSB-FROZEN-DOOR-HANDLES.HTML. *TR
THERE ARE NO EVENTS LEADING UP TO THE FAILURE. THE REAR DIFFERENTIAL WENT OUT ON MY 2005 NISSAN TITAN, IN ORDER TO REPAIR THE PART, I HAD TO BUY AN "ENTIRE" NEW REAR DIFFERENTIAL (BECAUSE THIS OF COURSE HAPPENED OUT OF WARRANTY). I WAS TOLD THE PART THAT NEEDED TO BE REPAIRED IS ACTUALLY A VERY SMALL PART OF THE DIFFERENTIAL, …
Read full complaint
THERE ARE NO EVENTS LEADING UP TO THE FAILURE. THE REAR DIFFERENTIAL WENT OUT ON MY 2005 NISSAN TITAN, IN ORDER TO REPAIR THE PART, I HAD TO BUY AN "ENTIRE" NEW REAR DIFFERENTIAL (BECAUSE THIS OF COURSE HAPPENED OUT OF WARRANTY). I WAS TOLD THE PART THAT NEEDED TO BE REPAIRED IS ACTUALLY A VERY SMALL PART OF THE DIFFERENTIAL, BUT I HAD TO PAY $4000 TO GET THE ENTIRE THING REPLACED. I WOULD LIKE TO STATE THAT I AM VERY VERY GLAD THAT THIS DID NOT HAPPEN WHILE I WAS DRIVING ON THE FREEWAY. I WAS ONLY DOING ABOUT 15 MPH WHEN IT WENT, AND IT FELT LIKE I GOT HIT BY A MACK TRUCK!!!!! I HAVE BEEN SEARCHING THE INTERNET TO SEE HOW OFTEN THIS IS HAPPENING AND IT SEEMS TO BE HAPPENING ALOT! SOMEONE SHOULD CHECK INTO THIS BEFORE SOMEONE GETS SERIOUSLY INJURED OR KILLED! *TR
DOOR LATCHES FREEZE AND WILL NOT OPEN, OR IF ABLE TO BE OPENED, WILL NOT LATCH IN FREEZING TEMPS. OTHERWISE, IF THE DOOR IS SECURED, THE LATCH FREEZES TRAPPING THE OCCUPANTS OF THE VEHICLE! WHAT IF THERE IS A FIRE? WHAT IF MY FAMILY IS INVOLVED IN A CRASH? DOES A CHILD HAVE TO FALL OUT OF A MOVING VEHICLE AND GET KILLED BEFORE S…
Read full complaint
DOOR LATCHES FREEZE AND WILL NOT OPEN, OR IF ABLE TO BE OPENED, WILL NOT LATCH IN FREEZING TEMPS. OTHERWISE, IF THE DOOR IS SECURED, THE LATCH FREEZES TRAPPING THE OCCUPANTS OF THE VEHICLE! WHAT IF THERE IS A FIRE? WHAT IF MY FAMILY IS INVOLVED IN A CRASH? DOES A CHILD HAVE TO FALL OUT OF A MOVING VEHICLE AND GET KILLED BEFORE SOMETHING IS DONE ABOUT THIS? YOU FOLKS HAVE BEEN AWARE FOR SOME TIME NOW, WHY HAVEN'T YOU DONE ANYTHING? THIS IS A VERY BLATANT SAFETY ISSUE. MY NEXT STEP IS TO CALL MY ATTORNEY. *TR
2005 NISSAN TITAN 4X4 FRONT AXLE FAILURE. THE FOUR WHEEL DRIVE IS INOPERABLE AR A RESULT OF A KNOWN DESIGN FLAW IN THIS VEHICLE. *TR
2005 TITAN, 36,000 MILES REAR SEAL FAILURE, LEAKING FLUID ON REAR BRAKES. *TR
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.