IllustrationWHILE DRIVING HEARD A CLANKING NOISE COMING FROM THE REAR OF THE VEHICLE, AT TIMES FROM A STANDING STILL POSITION THE VEHICLE AS YOU TRY TO GO WILL SLIP AND YOU WILL HEAR CLANKING NOISES FROM THE REAR AND THE VEHICLE WILL JERK. VEHICLE WAS TAKEN TO LOCAL MECHANIC AND DIAGNOSED AS HAVING A DEFECTIVE DIFFERENTIAL. *TR
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reportsCOMPLETE REAR END FAILURE OF MY 2005 NISSAN TITAN WHILE DRIVING 45MPH ON THE HIGHWAY. FAILURE HAPPENED AT 62500 MILES AND IS THE FIRST TIME TO MY KNOWLEDGE (PRE-OWNED). REAREND IS BEING REPLACED BY NISSAN SERVICE CENTER AT A COST OF $3500 THAT HAS TO BE PAID PERSONALLY AS THE TRUCK IS CURRENTLY 2500 MILES OUTSIDE OF THE DRIVETRA…
Read full complaint
COMPLETE REAR END FAILURE OF MY 2005 NISSAN TITAN WHILE DRIVING 45MPH ON THE HIGHWAY. FAILURE HAPPENED AT 62500 MILES AND IS THE FIRST TIME TO MY KNOWLEDGE (PRE-OWNED). REAREND IS BEING REPLACED BY NISSAN SERVICE CENTER AT A COST OF $3500 THAT HAS TO BE PAID PERSONALLY AS THE TRUCK IS CURRENTLY 2500 MILES OUTSIDE OF THE DRIVETRAIN WARRANTY AND IT APPEARS DOUBTFUL THAT NISSAN WILL ASSIST OR EVEN ACKNOWLEDGE THE SEVERE DESIGN FLAW.*CW
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 15 MPH HE NOTICED THAT THE REAR WHEELS SUDDENLY LOCKED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE DRIVE SHAFT AND REAR AXLE NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT MILEAGE WAS 105,000. THE…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 15 MPH HE NOTICED THAT THE REAR WHEELS SUDDENLY LOCKED CAUSING THE VEHICLE TO STOP. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE DRIVE SHAFT AND REAR AXLE NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT MILEAGE WAS 105,000. THE FAILURE MILEAGE WAS 50,000.
2005 NISSAN TITAN, DRIVING ON GRAVEL ROAD IN 4WD AND I HAD GOTTEN STUCK IN 1 INCH OF SNOW. I REALIZED THAT MY 4WD WAS NOT WORKING ANY LONGER. I EXITED MY TRUCK AND GOT TO THE TOP OF THE HILL JUST IN TIME TO STOP ON COMING TRAFFIC THAT COULD OF STRUCK MY TRUCK AND CAUSED SERIOUS INJURY TO ME AND MY PASSENGER. I CONTACTED THE D…
Read full complaint
2005 NISSAN TITAN, DRIVING ON GRAVEL ROAD IN 4WD AND I HAD GOTTEN STUCK IN 1 INCH OF SNOW. I REALIZED THAT MY 4WD WAS NOT WORKING ANY LONGER. I EXITED MY TRUCK AND GOT TO THE TOP OF THE HILL JUST IN TIME TO STOP ON COMING TRAFFIC THAT COULD OF STRUCK MY TRUCK AND CAUSED SERIOUS INJURY TO ME AND MY PASSENGER. I CONTACTED THE DEALERSHIP WHERE I HAD PURCHASED IT, AND THEY ARE UNABLE TO LOCATE A NEW OR USED FRONT DIFFERENTIAL FOR THE TRUCK. THE WHOLE DIFFERENTIAL NEEDS REPLACED AND HERE I AM STILL WAITING FOR THE PART BUT THEY ARE UNABLE TO LOCATE ANY. I HAVE NOTICED ON SEVERAL THREADS AND FORUMS THAT I AM NOT THE ONLY ONE WITH THIS PROBLEM. IT HAS HAPPENED TO HUNDREDS IF NOT THOUSANDS OF PEOPLE ACROSS THE US. THIS PROBLEM NEEDS TO BE RESOLVED, BY THE MANUFACTURER IN MY OPINION. *TR
ALTHOUGH I HAVEN'T HAD AN "INCIDENT" YET, I WORRY ABOUT IT EVERYDAY. MY 2005 NISSAN TITAN HAS THE WORST BRAKES THAT I'VE EVER HAD IN A VEHICLE. THE BRAKE PEDAL GOES TO THE FLOOR ON EVERY STOP. SOMETIMES WHILE THE BRAKE PEDAL IS DEPRESSED IT "SKIPS" AND IT FEELS LIKE THE BRAKES RELEASE THEN GRAB AGAIN. THIS TRUCK WAS MEANT TO TOW…
Read full complaint
ALTHOUGH I HAVEN'T HAD AN "INCIDENT" YET, I WORRY ABOUT IT EVERYDAY. MY 2005 NISSAN TITAN HAS THE WORST BRAKES THAT I'VE EVER HAD IN A VEHICLE. THE BRAKE PEDAL GOES TO THE FLOOR ON EVERY STOP. SOMETIMES WHILE THE BRAKE PEDAL IS DEPRESSED IT "SKIPS" AND IT FEELS LIKE THE BRAKES RELEASE THEN GRAB AGAIN. THIS TRUCK WAS MEANT TO TOW UP TO 9,000LBS, BUT WHEN I TOWED ABOUT 4,000 AND TRIED TO STOP, I ALMOST RAN INTO SOMEONE. THE BRAKES ARE HORRIBLE WITHOUT TOWING AND BEYOND ACCEPTABLE TOWING ANY WEIGHT. SINCE THAT HAPPENED, I HAVE YET TO TOW ANYTHING ELSE, I'M AFRAID THE TRUCK WON'T STOP. I'VE TAKEN IT TO THE DEALER MULTIPLE TIMES AND THEY ACKNOWLEDGE THE BRAKES AREN'T "WHAT THEY SHOULD BE" BUT THERE'S NOTHING THAT THEY CAN DO BECAUSE NISSAN HASN'T ADDRESSED THE PROBLEM. I'M HOPING THAT THIS PROBLEM COULD BE LOCKED INTO. THE DEALER ALSO TOLD ME THAT THE NISSAN ARMADA HAS THE SAME BRAKES AND THE SAME PROBLEMS. THANK YOU AS FAR AS THE INCIDENT DATE, I'M JUST USING THE FIRST DATE THAT I CAN REMEMBER REALIZING THE PROBLEM. *TR
HAVE A NISSAN 4X4 TITAN. BOUGHT IT NEW. FOR THE SECOND TIME THE REAR END LOCKED UP BREAKING THE DRIVE SHAFT. GOOD THING THIS HAPPENED AT MINIMAL SPEED. THIS IS EXTREMELY DANGEROUS. NISSAN REPAIRED THE FIRST TIME DUE TO OUR EXTENDED WARRANTY. THEY SHOULD BE LIABLE BECAUSE THEY MUST KNOW THE REPAIR THEY DO WILL FAIL AGAIN. THESE V…
Read full complaint
HAVE A NISSAN 4X4 TITAN. BOUGHT IT NEW. FOR THE SECOND TIME THE REAR END LOCKED UP BREAKING THE DRIVE SHAFT. GOOD THING THIS HAPPENED AT MINIMAL SPEED. THIS IS EXTREMELY DANGEROUS. NISSAN REPAIRED THE FIRST TIME DUE TO OUR EXTENDED WARRANTY. THEY SHOULD BE LIABLE BECAUSE THEY MUST KNOW THE REPAIR THEY DO WILL FAIL AGAIN. THESE VEHICLES WITH ALL THEIR PROBLEMS SHOULD NOT BE ON THE ROAD IN MY OPINION. *TR
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. CONTACT STATED HE WAS DRIVING 25 MPH WHEN HE HEARD A NOISE AND THE VEHICLE BEGAN VIBRATING EXCESSIVELY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO STATED THAT THE REAR DIFFERENTIAL FAILED. THE VEHICLE IS STILL BEING DIAGNOSED. THE CONTACT HAS NOT CALLED THE MANUFACTURER. THE VIN…
Read full complaint
TL*THE CONTACT OWNS A 2005 NISSAN TITAN. CONTACT STATED HE WAS DRIVING 25 MPH WHEN HE HEARD A NOISE AND THE VEHICLE BEGAN VIBRATING EXCESSIVELY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHO STATED THAT THE REAR DIFFERENTIAL FAILED. THE VEHICLE IS STILL BEING DIAGNOSED. THE CONTACT HAS NOT CALLED THE MANUFACTURER. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 65,000.
DRIVING. *TR
I HAVE A 2005 NISSAN TITAN 4WD WITH 57660 MILES. WHILE TAKING MY VEHICLE TO THE DEALERSHIP FOR SERVICE, I EXPERIENCED A REAR END FAILURE. THE ROADS WERE WET FROM RAIN. WHEN I STARTED OFF IN A RIGHT TURN FROM THE STOPLIGHT, THE REAR END STARTED TO CLUNK AND THE TRUCK WAS JERKY. I LET OFF THE ACCELERATOR TO SEE IF THE PROBLEM CORR…
Read full complaint
I HAVE A 2005 NISSAN TITAN 4WD WITH 57660 MILES. WHILE TAKING MY VEHICLE TO THE DEALERSHIP FOR SERVICE, I EXPERIENCED A REAR END FAILURE. THE ROADS WERE WET FROM RAIN. WHEN I STARTED OFF IN A RIGHT TURN FROM THE STOPLIGHT, THE REAR END STARTED TO CLUNK AND THE TRUCK WAS JERKY. I LET OFF THE ACCELERATOR TO SEE IF THE PROBLEM CORRECTED ITSELF, BUT UPON RE-ACCELERATING THE SAME THING OCCURRED. I LET OFF THE ACCELERATOR ONCE AGAIN AND LET THE VEHICLE COAST DOWN THE HILL, STILL CLUNKING AND JERKING. ONCE THE VEHICLE WAS IN A STRAIGHT POSITION, THE REAR END JERKED REALLY HARD, AND THEN I CONTINUED ABOUT A 1/2 MILE TO THE DEALERSHIP WITH NO FURTHER INCIDENT. WHILE AT THE DEALERSHIP, THE TRUCK WAS MOVED FROM THE SERVICE BAY TO A PARKING SPACE AND THE ATTENDANT NOTICED THAT THE REAR END WAS JERKING AND CLUNKING IN A TURNING POSITION. HE PARKED THE VEHICLE AND ADVISED THE SERVICE ADVISER. UPON INSPECTION BY THE DEALER, IT WAS DETERMINED THAT THE SPIDER GEARS WERE DAMAGED AND NEEDED TO BE REPLACED. THE DEALER DETERMINED THAT THE ENTIRE REAR END HOUSING SHOULD BE REPLACED RATHER THAN TRYING TO REPLACE THE INTERNAL MECHANISMS. THE REPAIR WAS COVERED UNDER THE FACTORY WARRANTY WITH 2340 MILES LEFT ON THE WARRANTY. THE FACTORY WARRANTIES THE NEW REAR END HOUSING FOR A PERIOD OF 12 MONTHS OR 12000 MILES. THIS VEHICLE HAS BEEN EXTREMELY WELL MAINTAINED, AND HAS NEVER BEEN DRIVEN OFF-ROAD. THERE WAS NO PRIOR INDICATION THAT A PROBLEM EXISTED UNTIL THE VERY MOMENT IT STARED TO FAIL ON THIS DAY. UPON RETURNING TO THE DEALER TO PICK UP THE VEHICLE, THE SERVICE ADVISER DID AGREE THAT THIS WAS AN ONGOING PROBLEM WITH THIS TRUCK AND THAT THIS PARTICULAR DEALERSHIP HAD REPLACED MULTIPLE REAR ENDS IN THIS MODEL TRUCK IN RECENT MONTHS. WE ARE CONCERNED THAT THIS SAME FAILURE COULD OCCUR AGAIN. THIS COULD RESULT IN A SERIOUS ACCIDENT OCCURRING SHOULD THE FAILURE OCCUR AT HIGHWAY SPEEDS. *TR
2005 NISSAN TITAN. DOOR LATCH FAILURE DURING COLD WEATHER BELOW FREEZING. LIVE IN SMALLWOOD NY, SO TIME PERIOD OF THIS WEATHER IS OCTOBER - APRIL. LOCKED OUT OF TRUCK WHILE CHILDREN IN CAR AND UNABLE TO GET TO THEM BECAUSE ALL DOORS WERE FROZEN. KEEP IN MIND I HAVE NOT WASHED THE TRUCK IN SEVERAL MONTHS. THERE IS A NISSAN TSB T…
Read full complaint
2005 NISSAN TITAN. DOOR LATCH FAILURE DURING COLD WEATHER BELOW FREEZING. LIVE IN SMALLWOOD NY, SO TIME PERIOD OF THIS WEATHER IS OCTOBER - APRIL. LOCKED OUT OF TRUCK WHILE CHILDREN IN CAR AND UNABLE TO GET TO THEM BECAUSE ALL DOORS WERE FROZEN. KEEP IN MIND I HAVE NOT WASHED THE TRUCK IN SEVERAL MONTHS. THERE IS A NISSAN TSB THAT THEY WILL REPLACE DOOR LOCKING MECHANISM IF VEHICLE IS UNDER WARRANTY. NISSAN USA: TBNS BX56AA / TSB 05118. HOWEVER IF VEHICLE IS NOT UNDER WARRANTY THEY QUOTED ME AT $400+ PER DOOR X'S 4 DOORS. THIS IS UNREASONABLE AND A SEVERE SAFETY HAZARD FOR MOST OF THE COUNTRY THAT EXPERIENCES WEATHER BELOW 32DEGREES F. IT IS A KNOWN FAILURE THAT NISSAN USA KNOWS ABOUT. THIS SHOULD BE A MANDATED RECALL. BELOW ARE LINKS TO A NISSAN TITAN ONLINE FORUM WITH MULTIPLE OTHER COMPLAINTS ABOUT THIS. FROZEN DOOR LATCH PROBLEM NOT SOLVED...PLEASE ADVISE WINTER PROBLEMS WITH TITAN FROM USA FROZEN DOOR HANDLES FROZEN DOORS WONT CLOSE WHEN COLD!! NISSAN NEW TSB FOR THE FROZEN DOOR HANDLES! *TR
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.