Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
What owners actually said
891 reports
44,500 miles · May 5, 2010
Power Train
BOUGHT A USED 2005 NISSAN 4X4 TITAN, FRONT DIFFERENTIAL FAILED. I NOTICED FRONT DIFFERENTIAL WAS LEAKING IN THE DRIVEWAY THE NEXT DAY. NOTICED THE DRIVERS SIDE CV SHAFT WAS PULLING OUT OF THE DIFFERENTIAL AND NOT PROPERLY SEATED. AUTOMOTIVE SHOP FOUND C CLIP ON THE END OF THE SPLINED AXLE SHAFT BROKEN AND THE SPLINES STRIPPED AN…
Read full complaint
BOUGHT A USED 2005 NISSAN 4X4 TITAN, FRONT DIFFERENTIAL FAILED. I NOTICED FRONT DIFFERENTIAL WAS LEAKING IN THE DRIVEWAY THE NEXT DAY. NOTICED THE DRIVERS SIDE CV SHAFT WAS PULLING OUT OF THE DIFFERENTIAL AND NOT PROPERLY SEATED. AUTOMOTIVE SHOP FOUND C CLIP ON THE END OF THE SPLINED AXLE SHAFT BROKEN AND THE SPLINES STRIPPED AND TWISTED WHERE IT GOES INTO THE GEAR. REPLACED THE DRIVERS SIDE CV SHAFT, AXLE SHAFT, GEAR, & BEARINGS. VEHICLE HAD 44500 MILES ON IT. *TR
NHTSA ODI #10329034
73,000 miles · Apr 29, 2010
Parking BrakeSteering
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, HE NOTICED THAT THE FRONT END OF THE VEHICLE WOULD MOVE FROM THE LEFT THEN TO THE RIGHT SIDE WHEN SHIFTED INTO 4-WHEEL DRIVE . ON A SEPARATE OCCASION, WHILE TRAVELING AT SPEEDS OF 2 MPH IN THE REVERSE POSITION, THE CONTACT HEARD AN UNUSUALLY …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, HE NOTICED THAT THE FRONT END OF THE VEHICLE WOULD MOVE FROM THE LEFT THEN TO THE RIGHT SIDE WHEN SHIFTED INTO 4-WHEEL DRIVE . ON A SEPARATE OCCASION, WHILE TRAVELING AT SPEEDS OF 2 MPH IN THE REVERSE POSITION, THE CONTACT HEARD AN UNUSUALLY LOUD POPPING NOISE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE EMERGENCY BRAKE PADS HAD SEPARATED AND THE FRONT PINION BEARING NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 83,000.
NHTSA ODI #10328048
81,025 miles · Apr 26, 2010
Power Train
REAR DIFFERENTIAL ON 2005 NISSAN TITAN BROKE WHILE TRAVELING AT HIGHWAY SPEEDS. IN RESEARCHING ONLINE IT SEEMS THAT THIS IS A CHRONIC PROBLEM WITH NISSAN TITANS AROUND THE 50K -85K MILE RANGE. BELIEVE THIS SHOULD BECOME A RECALL ISSUE AS THIS COULD HAVE SEVERE CONSEQUENCES IF THE REAR END LOCKS UP WHEN IT BRAKE AT SPEED. *…
Read full complaint
REAR DIFFERENTIAL ON 2005 NISSAN TITAN BROKE WHILE TRAVELING AT HIGHWAY SPEEDS. IN RESEARCHING ONLINE IT SEEMS THAT THIS IS A CHRONIC PROBLEM WITH NISSAN TITANS AROUND THE 50K -85K MILE RANGE. BELIEVE THIS SHOULD BECOME A RECALL ISSUE AS THIS COULD HAVE SEVERE CONSEQUENCES IF THE REAR END LOCKS UP WHEN IT BRAKE AT SPEED. *TR
NHTSA ODI #10327601
71,212 miles · Apr 26, 2010
Power Train
DRIVING ALONG. STOPPED AT A STOP SIGN TO MAKE A RIGHT TURN. THE REAR END ON MY 2005 NISSAN TITAN CREWCAB, MADE A REAL LOUD CLUNK SOUND. THIS ONLY HAPPENS WHEN BACKING UP TO THE RIGHT, AND TURN RIGHT. GOING SLOW. THE TRUCK ONLY HAS 71212 MILES ON THE ODOMETER. *TR
NHTSA ODI #10327364
38,403 miles · Apr 24, 2010
Power Train
TRUCK STARTED MAKING CLUNK NOISE 5 MONTHS AGO EVERY ONE IN A WHILE I THOUGHT IT WAS STUFF IN THE BED OF THE TRUCK. LAST NIGHT I WAS TURNING A CORNER IS MADE A THE CLUNK NOISE AND EVERY TURN I TOOK UNDER POWER MADE THE CLUNK NOISE AND WHEN I START FROM A STOP ON WET DRIVING SURFACES. *TR
NHTSA ODI #10327292
48,000 miles · Apr 13, 2010
Service Brakes, HydraulicStructure
TL - THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 25 MPH DURING CLEAR WEATHER CONDITIONS THE ELECTRIC BRAKES CONTROL STOPPED WORKING. HE STATE THE VEHICLE HAS NOT BEEN REPAIRED. HE REFERENCED RECALL NHTSA CAMPAIGN ID NUMBER: 07E046000 (EQUIPMENT). THE CONTACT ALSO STATED THE RIGHT REAR DOOR OPENS IN COLD WEATHER CONDITIO…
Read full complaint
TL - THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 25 MPH DURING CLEAR WEATHER CONDITIONS THE ELECTRIC BRAKES CONTROL STOPPED WORKING. HE STATE THE VEHICLE HAS NOT BEEN REPAIRED. HE REFERENCED RECALL NHTSA CAMPAIGN ID NUMBER: 07E046000 (EQUIPMENT). THE CONTACT ALSO STATED THE RIGHT REAR DOOR OPENS IN COLD WEATHER CONDITIONS WHILE DRIVING. HE STATED THE PROBLEM WITH THE DOOR WAS REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 48000 AND THE CURRENT MILEAGE WAS 57,000. VWB
NHTSA ODI #10325409
99,000 miles · Apr 12, 2010
Power Train
2005 NISSAN TITAN 4X4 CREW CAB AND ALL OF A SUDDEN HAS A BROKEN REAR DIFFERENTIAL. THE COST TO REPAIR IS $3,500 AN NOT COVERED UNDER WARRANTY. HOW IS THIS POSSIBLE? I'VE TOWED A WATERCRAFT TRAILER ABOUT 5 TIMES AND NOTHING ELSE. *TR
NHTSA ODI #10325150
57,000 miles · Apr 7, 2010
Fuel System, Other
MY 05 NISSAN TITAN FUEL GAUGE READS THAT I HAVE A QUARTER OF A TANK LEFT WHEN I RUN OUT OF GAS. I HAVE BEEN TOLD THIS IS DUE TO A FAULTY SENDING UNIT IN THE GAS TANK. THIS IS DISTURBING BECAUSE IF I WERE TO RUN OUT OF GAS ON THE HIGHWAY OR MY WIFE HAS MY TRUCK AND RUNS OUT OF GAS, THE POWER STEERING SHUTS OFF WHEN THE TRUCK DI…
Read full complaint
MY 05 NISSAN TITAN FUEL GAUGE READS THAT I HAVE A QUARTER OF A TANK LEFT WHEN I RUN OUT OF GAS. I HAVE BEEN TOLD THIS IS DUE TO A FAULTY SENDING UNIT IN THE GAS TANK. THIS IS DISTURBING BECAUSE IF I WERE TO RUN OUT OF GAS ON THE HIGHWAY OR MY WIFE HAS MY TRUCK AND RUNS OUT OF GAS, THE POWER STEERING SHUTS OFF WHEN THE TRUCK DIES FROM NO FUEL. THIS COULD CAUSE A COLLISION AND RESULT IN SERIOUS INJURY OR DEATH. THIS IS NOT A CHANCE I AM WANTING TO TAKE WITH THE LIVES OF MY FAMILY. THIS ITEM HAS BEEN RECALLED ON OTHER NISSAN TITANS, BUT WHEN I CALLED ABOUT MINE IT WAS SAID THAT IT IS NOT COVERED UNDER THE RECALL. I WOULD LIKE TO MAKE IT KNOWN THAT THE 2005 NISSAN TITAN CREW CAB SE 4 WD ..VIN NUMBER [XXX]...ALSO HAS THIS PROBLEM AND SHOULD BE INCLUDED IN THIS RECALL. AND THE RECALL ID # 49063 IS FOR THE FUEL GAUGE SYSTEM RECALL. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10324296
86,000 miles · Apr 7, 2010
Power Train
WHILE DRIVING ON THE FREEWAY, I HAD A SUDDEN LOSS OF ACCELERATION, A LOUD THUMP UNDER THE VEHICLE AND THEN THUMPING WHEN I TRIED TO ACCELERATE AGAIN. AFTER TAKING MY TITAN TO A MECHANIC, HE TOLD ME THE REAR DIFFERENTIAL WAS DESTROYED AND NEEDED TO BE REPLACED. *TR
NHTSA ODI #10324142
50 miles · Apr 6, 2010
Electrical System
TL*-THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE IGNITION SWITCH FELL OUT OF PLACE ON THE STEERING COLUMN SO SHE WOULD HAVE TO PUT IT BACK IN ORDER TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE HINGE THAT HELD THE SWITCH IN PLACE WAS MISSING …
Read full complaint
TL*-THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE IGNITION SWITCH FELL OUT OF PLACE ON THE STEERING COLUMN SO SHE WOULD HAVE TO PUT IT BACK IN ORDER TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE HINGE THAT HELD THE SWITCH IN PLACE WAS MISSING AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 50. THE CURRENT MILEAGE WAS APPROXIMATELY 37,000.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration