NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
891 reports140,000 miles · May 20, 2014
EngineEngine And Engine Cooling
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WERE STRONG FUMES EMITTING FROM THE VEHICLE UNDERNEATH THE HOOD WHICH ENTERED THROUGH THE AC OR HEATING SYSTEM INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIR…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THERE WERE STRONG FUMES EMITTING FROM THE VEHICLE UNDERNEATH THE HOOD WHICH ENTERED THROUGH THE AC OR HEATING SYSTEM INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED AND THE FAILURE RECURRED. THE CONTACT CONTINUED TO SMELL STRONG FUMES INSIDE THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE EXHAUST MANIFOLD NEEDED TO BE REPLACED AGAIN. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.
NHTSA ODI #10592657
28,000 miles · Apr 22, 2014
Suspension
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED AND PUNCTURED THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE REAR LEAF SPRING NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF FAILURE. TH…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE REAR LEAF SPRING FRACTURED AND PUNCTURED THE BED OF THE TRUCK. THE VEHICLE WAS TAKEN TO THE DEALER AND THE TECHNICIAN DIAGNOSED THAT THE REAR LEAF SPRING NEEDED TO BE REPLACED. NO REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 28,000.
NHTSA ODI #10584228
150,000 miles · Apr 15, 2014
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT EXHAUST FUMES WERE EMITTED INTO THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.
NHTSA ODI #10582945
53,592 miles · Mar 31, 2014
Power Train
I FIRST FELT AND HEARD A LOUD CLANKING NOISE COMING FROM THE REAR END WHILE ACCELERATING FROM A STOP LIGHT. APPROXIMATELY 30 SECONDS LATER I FELT IT AGAIN WHILE ENTERING THE ON RAMP TO A FREEWAY GOING APPROXIMATELY 25 MPH. I PULLED OVER AND INSPECTED THE REAR END OF MY TRUCK AND FOUND NO VISIBLE DAMAGE OR LEAKING OF FLUIDS. I GO…
Read full complaint
I FIRST FELT AND HEARD A LOUD CLANKING NOISE COMING FROM THE REAR END WHILE ACCELERATING FROM A STOP LIGHT. APPROXIMATELY 30 SECONDS LATER I FELT IT AGAIN WHILE ENTERING THE ON RAMP TO A FREEWAY GOING APPROXIMATELY 25 MPH. I PULLED OVER AND INSPECTED THE REAR END OF MY TRUCK AND FOUND NO VISIBLE DAMAGE OR LEAKING OF FLUIDS. I GOT BACK IN MY TRUCK AND STARTED TO ACCELERATE AND IMMEDIATELY FELT AND HEARD THE CLANKING NOISE AGAIN. I THEN DROVE STRAIGHT TO THE NISSAN DEALERSHIP WHICH FORTUNATELY WAS ONLY TWO MILES AWAY. THE NISSAN SERVICE DEPARTMENT DID AN INSPECTION AND DETERMINE THE GEARS IN DIFFERENTIAL WERE BINDING. THE NISSAN TECHNICIANS WERE UNABLE TO DETERMINE WHY A DIFFERENTIAL WITH ONLY 53,000 MILES THAT WAS MAINTAINED AS WELL AS MINE WAS WOULD FAIL. THE NISSAN DEALERSHIP HAS PERFORMED ALL THE MAINTENANCE ON MY TRUCK AND ARE WELL AWARE OF HOW WELL ITS MAINTAINED. THEY SUGGESTED ITS A DEFECT AND RECOMMENDED I SPEAK WITH NISSAN USA DIRECTLY IN HOPES OF THEM COVERING THE REPLACEMENT OF THE DEFECTIVE DIFFERENTIAL ON MY TRUCK. I SPOKE WITH A REPRESENTATIVE FROM NISSAN USA AND THEY INFORMED ME THAT BECAUSE MY TRUCK IS OUT OF WARRANTY, THE DEFECTIVE DIFFERENTIAL ITS NOT GOING TO BE COVERED. THE WORST PART IS THAT THERE IS NO REPLACEMENT PARTS FOR THE DIFFERENTIAL. I HAVE TO REPLACE THE WHOLE REAR AXLE. THIS IS A COST OF (AXLE) $3500.00 +( LABOR) $1000.00. LETS NOT FORGET TAXES ALSO. NISSAN IS AWARE OF THE DEFECTIVE DIFFERENTIALS AND IS COUNTING ON PEOPLE TO NOT MAKE THE EFFORT TO BRING THIS ISSUE TO LIGHT. PLEASE HELP MAKE A CHANGE BEFORE SOMEONE GETS SERIOUSLY HURT BY THIS DEFECT. *TR
NHTSA ODI #10576091
122,000 miles · Mar 25, 2014
Power Train
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS A CONSISTENT TICKING NOISE FROM DRIVE SHAFT. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR DIAGNOSIS. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 122,…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THERE WAS A CONSISTENT TICKING NOISE FROM DRIVE SHAFT. THE VEHICLE WAS NOT TAKEN FOR INSPECTION OR DIAGNOSIS. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 122,000.
NHTSA ODI #10574671
55,000 miles · Mar 25, 2014
Power Train
I STARTED TO FEEL A THUD IN THE REAR AXLE AS I TURNED THE VEHICLE. IF FELT LIKE THE AXLE WAS BINDING UP. ULTIMATELY, I TOOK IT TO NISSAN WHO SAID THEY COULD REPLACE THE AXLE FOR $3000. SINCE THIS WAS WAY TO EXPENSIVE FOR A KNOW DEFECT, I HAD THE LOCKER REPLACED AT FOUR WHEEL PARTS. IT COST NEARLY $2500 WHEN ALL SAID AND DONE. …
Read full complaint
I STARTED TO FEEL A THUD IN THE REAR AXLE AS I TURNED THE VEHICLE. IF FELT LIKE THE AXLE WAS BINDING UP. ULTIMATELY, I TOOK IT TO NISSAN WHO SAID THEY COULD REPLACE THE AXLE FOR $3000. SINCE THIS WAS WAY TO EXPENSIVE FOR A KNOW DEFECT, I HAD THE LOCKER REPLACED AT FOUR WHEEL PARTS. IT COST NEARLY $2500 WHEN ALL SAID AND DONE. *TR
NHTSA ODI #10574662
120,000 miles · Mar 24, 2014
Engine And Engine CoolingPower Train
STARTED HAVING OVER HEATING ISSUES IN 8/2012. EVENTUALLY HAD RADIATOR COMPLETELY REPLACED IN 2/14. HAD TRANSMISSION FLUSHED AROUND SAME TIME. ON 3/26/14, I WAS ON THE INTERSTATE GOING 65MPH WHEN I LOST USE OF THE TRANSMISSION, CAUSING THE ENGINE TO STALL, BARELY AVOIDING A SERIOUS ACCIDENT. TODAY FOUND OUT THERE IS A DEFECT WITH…
Read full complaint
STARTED HAVING OVER HEATING ISSUES IN 8/2012. EVENTUALLY HAD RADIATOR COMPLETELY REPLACED IN 2/14. HAD TRANSMISSION FLUSHED AROUND SAME TIME. ON 3/26/14, I WAS ON THE INTERSTATE GOING 65MPH WHEN I LOST USE OF THE TRANSMISSION, CAUSING THE ENGINE TO STALL, BARELY AVOIDING A SERIOUS ACCIDENT. TODAY FOUND OUT THERE IS A DEFECT WITH NISSAN RADIATORS OVER HEATING AND CAUSING COOLANT TO LEAK INTO THE TRANSMISSION, DETERIORATING THE GEARS OVER TIME. SPENT AROUND $1,000.00 GETTING THE RADIATOR REPLACED UNAWARE OF THIS FACTORY DEFECT. NOW I AM WITHOUT A FUNCTIONING VEHICLE AND I THINK LUCKY TO BE ALIVE. *TR
NHTSA ODI #10574586
118,000 miles · Mar 20, 2014
Fuel/propulsion System
WHILE DRIVING WITH MY FAMILY, MY TITAN RAN OUT OF GAS WHILE THE GAUGE SHOWED 1/4 TANK, STRANDING MYSELF, MY PREGNANT WIFE AND 2YR OLD DAUGHTER IN A DANGEROUS AREA, AND IN THE MIDDLE OF A BUSY STREET. I HAD TO GET OUT AND PUSH THE TRUCK TO A PARKING LOT. I THEN WALKED TWO MILES TO GET 2 GALLONS OF GAS, FORCED TO LEAVE MY FAMILY W…
Read full complaint
WHILE DRIVING WITH MY FAMILY, MY TITAN RAN OUT OF GAS WHILE THE GAUGE SHOWED 1/4 TANK, STRANDING MYSELF, MY PREGNANT WIFE AND 2YR OLD DAUGHTER IN A DANGEROUS AREA, AND IN THE MIDDLE OF A BUSY STREET. I HAD TO GET OUT AND PUSH THE TRUCK TO A PARKING LOT. I THEN WALKED TWO MILES TO GET 2 GALLONS OF GAS, FORCED TO LEAVE MY FAMILY WITH THE STRANDED TRUCK(MY WIFE CAN'T WALK THAT FAR RIGHT NOW). I RETURNED, PUT THE 2 GALLONS IN THE TANK AND IT STARTED RIGHT UP. I CALLED THE DEALER, WHICH GAVE ME A LOUSY EXCUSE AS TO WHY THOUSANDS OF THESE TRUCKS WERE RECALLED BECAUSE OF THIS SAME ISSUE, EXCEPT MINE. THEY OFFERED TO GIVE ME A GREAT DEAL. 600 DOLLARS FOR THE REPAIR WHEN THE PART COSTS $77. THEN JUST LAST WEEK THE TRUCK RAN OUT OF GAS, THIS TIME ON THE FREEWAY, NEARLY CAUSING AN ACCIDENT WITH A SEMI TRUCK, WHILE SHOWING ALMOST 1/2 TANK. UPON RESEARCHING THIS ISSUE, I HAVE DISCOVERED THAT THOUSANDS OF TITAN OWNERS ARE HAVING THE SAME PROBLEM AND NOT BEING COVERED UNDER THE RECALL. I CONTACTED THE BAR AND AFTER THEIR INVESTIGATION, THE DEALER DISCLOSED THAT ALL TITANS WERE MADE WITH THE DEFECTIVE FUEL LEVEL SENSOR, AND THAT THE DEALER WAS REPLACING THESE PARTS EVERY DAY, NOT COVERED BY THE RECALL. TO SUM IT UP, I SPENT GOOD MONEY FOR A TRUCK THAT I THOUGHT WOULD BE A SAFE VEHICLE FOR MYSELF AND MY FAMILY, WHICH IT IS NOT. I'M VERY SERIOUS I WAS ALMOST KILLED WHEN IT HAPPENED ON THE FREEWAY. I HAVE OWNED A LOT OF VEHICLES, AND HAVE NEVER EVER HEARD OF SUCH A SAFETY ISSUE THAT ISN'T ADDRESSED BY RECALLS. BASICALLY THIS TRUCK IS A DEATH TRAP, IT'S ONLY A MATTER OF TIME UNTIL SOMETHING TRAGIC HAPPENS, ALL BECAUSE NISSAN WILL NOT OWN UP TO THEIR FAULTY PARTS. IN FACT THEY ARE VERY DISRESPECTFUL, AND UNPROFESSIONAL WHEN TALKING TO THEM ABOUT IT. I WILL NEVER PURCHASE ANOTHER NISSAN AGAIN, KNOWING HOW UNSAFE THEY ARE AND THE WAY THEY TREAT THEIR LOYAL CUSTOMERS AFTER A PURCHASE. .... UPDATED 08/05/14 *BF *TR UPDATED 08/18/2014 *JS
NHTSA ODI #10573650
82,000 miles · Mar 19, 2014
Engine And Engine CoolingWheels
OIL LEAKING ON LEFT REAR WHEEL CAUSE BY A BAD SEAL. TRUCK HAVE BEEN REPAIRED TWICE BY A LOCAL LICENSED SHOP, . THE PROBLEM PERSIST. IT MAY BE CAUSE BY A BAD DIFFERENTIAL. LET ME KNOW IF IS ANY RECALLS FROM FACTORY. OR ANY ON GOING INVESTIGATION. *TR
NHTSA ODI #10573312
65,000 miles · Mar 17, 2014
Engine And Engine CoolingPower Train
WHILE DOING A LIQUIDS CHECK I NOTICED THE COOLANT RESERVOIR WAS LOW. I ADDED DISTILLED WATER TO THE RADIATOR AND LOOKED UNDERNEATH TO LOOK FOR A LEAK. I FOUND COOLANT LEAKING FROM THE TRANSMISSION LINE AT THE BOTTOM OF THE RADIATOR. AS I BACKED INTO MY GARAGE, I HEARD THE COOLANT RESERVOIR PRESSURIZE AND START TO OVERFLOW. T…
Read full complaint
WHILE DOING A LIQUIDS CHECK I NOTICED THE COOLANT RESERVOIR WAS LOW. I ADDED DISTILLED WATER TO THE RADIATOR AND LOOKED UNDERNEATH TO LOOK FOR A LEAK. I FOUND COOLANT LEAKING FROM THE TRANSMISSION LINE AT THE BOTTOM OF THE RADIATOR. AS I BACKED INTO MY GARAGE, I HEARD THE COOLANT RESERVOIR PRESSURIZE AND START TO OVERFLOW. THE RESERVOIR WAS FILLED WITH TRANNY FLUID. I DRAINED THE TRANSMISSION AND FOUND COOLANT IN THE TRANSMISSION. I DON'T KNOW HOW MANY MILES I DROVE THE VEHICLE IN THIS CONDITION BUT I'M AFRAID THE TRANSMISSION IS DAMAGED AND I CAN'T GET THE COOLANT COMPLETELY OUT OF THE TRANSMISSION. I'VE DRAINED AND FILLED IT TWICE SO FAR AND STILL HAVE SIGNS OF COOLANT. I TALKED TO A LOCAL DEALER AND THEY RECOMMENDED THAT I KEEP DRAINING AND FLUSHING UNTIL THE TRANNY FLUID COMES OUT THE SAME COLOR AS IT WENT IN. *TR
NHTSA ODI #10572800
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration