NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
60 reportsClear category filter121,000 miles · Apr 12, 2012
Electrical SystemService Brakes, HydraulicSteering
DRIVING NORTH ON THE HIGHWAY @ 70MPH, VEHICLE BACKFIRED AND ENGINE SHUT DOWN, NO POWER STEERING OR BRAKES. MOVED VEHICLE OFF THE HIGHWAY, CRANKED BUT WOULD NOT START. LEFT VEHICLE FOR THE DAY AND RETURNED AND REPLACED A RECALLED (BUT KNOWN GOOD REPLACEMENT) ECM RELAY AND VEHICLE STARTED AND RAN CORRECTLY BUT SHOWED SES LIGHT A…
Read full complaint
DRIVING NORTH ON THE HIGHWAY @ 70MPH, VEHICLE BACKFIRED AND ENGINE SHUT DOWN, NO POWER STEERING OR BRAKES. MOVED VEHICLE OFF THE HIGHWAY, CRANKED BUT WOULD NOT START. LEFT VEHICLE FOR THE DAY AND RETURNED AND REPLACED A RECALLED (BUT KNOWN GOOD REPLACEMENT) ECM RELAY AND VEHICLE STARTED AND RAN CORRECTLY BUT SHOWED SES LIGHT AND CODE SHOWED P0335 CRK POS SENSOR. THIS VEHICLE HAD A CATASTROPHIC FAILURE WHILE DRIVING WHICH REPRESENTED A SERIOUS HAZARD TO BOTH THE DRIVER AND SURROUNDING VEHICLES SHOULD THE DRIVER HAS PANICKED IN THIS SITUATION AND HEAVY TRAFFIC. TO DATE THE VEHICLE IS A NISSAN FACILITY AND STILL HAS NOT BEEN REPAIRED AT GREAT EXPENSE AND INCONVENIENCE TO THE OWNER. *TR
NHTSA ODI #10454954
75,000 miles · Sep 19, 2011
Power TrainService Brakes, Hydraulic
I NOTICED A BLACK DARK GREASE ON THE INNER RIM AND AXLE HUB. I WAS TOLD BY A NEIGHBOR WITH THE SAME MAKE AND YEAR THAT THIS IS A LEAKING BEARING SEAL AND THAT THE ENTIRE AXLE HAS TO BE REPLACED. I CONSIDER THIS A HAZARD IF THE BEARING SEAL HAS LEAKED ALL OVER THE REAR BRAKE PADS AND SHOES. *KB
NHTSA ODI #10426354
Mileage unknown · Jan 25, 2011
Service Brakes, Hydraulic
2005 NISSAN TITAN. CONSUMER HAD RECALL WORK FOR BRAKE JUDDER. THE REPAIRS WERE DONE EVEN THOUGH THE CONSUMER WAS NOT EXPERIENCING ANY PROBLEMS. SOMETIME AFTER THE RECALL REPAIR, THE VEHICLE BEGAN TO MAKE NOISES . *KB THE CONSUMER STATED HE BEGAN TO EXPERIENCE OCCASIONAL SHUTTERING IN THE FRONT WHEELS WHEN HE APPLIED THE BRAKE.…
Read full complaint
2005 NISSAN TITAN. CONSUMER HAD RECALL WORK FOR BRAKE JUDDER. THE REPAIRS WERE DONE EVEN THOUGH THE CONSUMER WAS NOT EXPERIENCING ANY PROBLEMS. SOMETIME AFTER THE RECALL REPAIR, THE VEHICLE BEGAN TO MAKE NOISES . *KB THE CONSUMER STATED HE BEGAN TO EXPERIENCE OCCASIONAL SHUTTERING IN THE FRONT WHEELS WHEN HE APPLIED THE BRAKE. THE CONSUMER STATED THE DEALER REFUSED TO HONOR THE WARRANTY. THE CONSUMER STATED HE HAS CONTINUED TO EXPERIENCE BRAKE PROBLEMS TO THE POINT WHERE THE BRAKES WOULD NOT WORK. THERE WERE SEVERAL INCIDENTS, WHERE THE CONSUMER RAN SEVERAL STOP SIGNS AND INTO THE INTERSECTION. *JB UPDATED 03/1011 THE LEFT FRONT BRAKE ENGAGED WITH GREATER INTENSITY THAN THE OTHER BRAKES, WHICH CAUSED THE LEFT FRONT BRAKE TO GRAB DURING HARD BRAKING. THE CONSUMER STATED THE PROBLEM ONLY SEEMED TO OCCUR WITH HARD BRAKING DURING HAZARDOUS ROAD CONDITIONS. UPDATED 05/19/11 *JB.
NHTSA ODI #10379088
42,186 miles · Jan 9, 2011
Power TrainService Brakes, HydraulicSuspension
MULTIPLE FAILURES OF RIGHT REAR AXLE SEAL. FAILURES AT MILEAGES OF 42186/86082/106492/131033. SAME PARTS REPLACED 43252-7S200 REAR AXLE SEAL, 43070-7S200 REAR SPACER, 40210-7S210 AXLE BEARING. AXLE FLUID DRAINS DIRECTLY ON TO BRAKE CAUSING LOSS OF FUNCTION ON RIGHT REAR WHEEL. ALSO HAS CAUSED POSSIBLE PREMATURE SHOCK ABSORBER WE…
Read full complaint
MULTIPLE FAILURES OF RIGHT REAR AXLE SEAL. FAILURES AT MILEAGES OF 42186/86082/106492/131033. SAME PARTS REPLACED 43252-7S200 REAR AXLE SEAL, 43070-7S200 REAR SPACER, 40210-7S210 AXLE BEARING. AXLE FLUID DRAINS DIRECTLY ON TO BRAKE CAUSING LOSS OF FUNCTION ON RIGHT REAR WHEEL. ALSO HAS CAUSED POSSIBLE PREMATURE SHOCK ABSORBER WEAR.
NHTSA ODI #10376113
13,000 miles · Sep 9, 2010
Service Brakes, Hydraulic
I BELIEVE THAT THE NISSAN TITANS HAVE A SAFETY ISSUE WITH THEIR BRAKES. I PURCHASED THE TRUCK NEW IN 2005 WITH 14 MILES SHOWING ON THE ODOMETER. AFTER THE FIRST YEAR OF OWNERSHIP I NOTICED THAT THE BRAKE PEDAL PULSATED A LOT WHEN APPLYING THE BRAKES. I NEVER LEAVE MY FOOT ON OR RIDE THE BRAKE PEDAL NOR DO I USE THE BRAKES EXC…
Read full complaint
I BELIEVE THAT THE NISSAN TITANS HAVE A SAFETY ISSUE WITH THEIR BRAKES. I PURCHASED THE TRUCK NEW IN 2005 WITH 14 MILES SHOWING ON THE ODOMETER. AFTER THE FIRST YEAR OF OWNERSHIP I NOTICED THAT THE BRAKE PEDAL PULSATED A LOT WHEN APPLYING THE BRAKES. I NEVER LEAVE MY FOOT ON OR RIDE THE BRAKE PEDAL NOR DO I USE THE BRAKES EXCESSIVELY, MOST OF THE MILES ON THE VEHICLE ARE HIGHWAY MILES BECAUSE THE TRUCK IS USED MOSTLY FOR VACATION PURPOSES. I DO HOWEVER TOW A SMALL 6 BY 12 FOOT BOX TRAILER WITH 4 BICYCLES IN IT, WHICH MAKES FOR A LIGHT LOAD. IT HAS CONTINUED TO PROGRESS AND BECOME MORE PRONOUNCED AS THE VEHICLE AGES. AT AROUND 13,000 MILES THE BRAKES SOMETIMES GRAB OR WOULD NOT STOP WITH OUT APPLYING EXCESSIVE FORCE TO THE BRAKE PEDAL MUCH MORE THAN WHEN THE VEHICLE WAS NEW, THIS WOULD BRING THE TRUCK TO A SHAKING, ROUGH OR SOMETIMES TIRE SQUEALING STOP. AT 13,300 I TOOK THE VEHICLE TO A DEALERSHIP TO SEE IF THEY COULD CORRECT THIS PROBLEM, THEY SAID THEY COULD TRY MACHINING THE ROTORS FOR AROUND $440 OR REPLACE THE ROTORS WHICH WOULD COST QUITE A BIT MORE, HOWEVER THE REPAIR WOULD NOT BE COVERED UNDER THE WARRANTY. THE TRUCK STILL HAS THE SAME PROBLEM WITH 14,991 MILES ON THE ODOMETER. I FEEL IF THERE IS A PROBLEM WITH THE ROTORS IT IS A SAFETY ISSUE AND IT SHOULD BE COVERED BY THE WARRANTY. THIS IS THE ONLY VEHICLE OUT OF ABOUT 10 NEW VEHICLES THAT I PURCHASED WHICH HAS BRAKE PROBLEMS. *TR
NHTSA ODI #10354621
70,000 miles · Aug 15, 2010
Power TrainService Brakes, Hydraulic
REAR AXLE SEAL LEAKING, IT IS LEAKING SO BAD THAT IT IS ALL OVER MY REAR PASSENGER SIDE BRAKES. I NOTICED THE BRAKES SLIPPING YESTERDAY WHEN I TRYING TO STOP ON THE HIGHWAY. 05 NISSAN TITAN. *TR
NHTSA ODI #10349412
97,995 miles · Aug 11, 2010
Service Brakes, Hydraulic
1. THE INCIDENT OCCURRED AUG 11, 2010 WHILE I WAS DRIVING MY 2005 NISSAN TITAN TRUCK IN HEAVY TRAFFIC AT 65 MPH. 2.THE FAILURE OCCURRED WHEN I HAD TO APPLY FOOT PRESSURE TO THE BRAKE PEDAL DUE TO HEAVY TRAFFIC CONGESTION. AS SOON AS BRAKE PRESSURE WAS APPLIED TO THE BRAKE PEDAL FIVE THINGS HAPPENED: A. THE BRAKE PEDAL…
Read full complaint
1. THE INCIDENT OCCURRED AUG 11, 2010 WHILE I WAS DRIVING MY 2005 NISSAN TITAN TRUCK IN HEAVY TRAFFIC AT 65 MPH. 2.THE FAILURE OCCURRED WHEN I HAD TO APPLY FOOT PRESSURE TO THE BRAKE PEDAL DUE TO HEAVY TRAFFIC CONGESTION. AS SOON AS BRAKE PRESSURE WAS APPLIED TO THE BRAKE PEDAL FIVE THINGS HAPPENED: A. THE BRAKE PEDAL FELT SOFTER THAN NORMAL. B. THE BRAKE PEDAL WENT FURTHER DOWN TOWARD THE FLOORBOARD THAN NORMAL. C. I HEARD A POPPING/PULSATING SOUND AS I HAD TO APPLY THE BRAKES. D. I HEARD A GRINDING SOUND AS I HAD TO APPLY THE BRAKES. E. THE INSTRUMENT PANEL RED BRAKE LIGHT ILLUMINATED. I HAD NO CHOICE, BUT TO APPLY PRESSURE TO THE BRAKE PEDAL TO AVOID CREATING AN ACCIDENT EVEN THOUGH IT SOUNDED AND FELT LIKE BRAKE FAILURE WAS OCCURRING. THIS IS THE THIRD TIME THIS TYPE OF BRAKE INCIDENT/FAILURE HAS OCCURRED ON MY 2005 NISSAN TITAN. THE PREVIOUS TWO TIMES THIS BRAKE INCIDENT/FAILURE OCCURRED AT A MUCH LOWER SPEEDS AND I COULD NOT FIND RELATION TO WHAT WAS OCCURRING WHEN I INSPECTED THE VEHICLE. 3. ONCE I HAD THE VEHICLE BACK UNDER CONTROL I TURNED INTO A LOW TRAFFIC SIDE STREET AND SLOWLY TESTED THE BRAKES, BUT ALL FIVE SYMPTOMS FROM ABOVE WERE STILL OCCURRING. I ALSO TRIED GOING IN REVERSE VERY SLOWLY, BUT THE SYMPTOMS REMAINED. I COMPLETELY STOPPED THE VEHICLE AND TURNED OFF THE IGNITION KEY AND GOT OUT TO INSPECT THE TRUCK. I COULD NOT SEE ANY VISIBLE DAMAGE TO FRONT ROTORS OR CALIPERS AND I CHECKED THE BRAKE FLUID LEVEL, BUT NOTHING APPEARED TO BE WRONG. I TURNED THE IGNITION BACK ON AND THE RED BRAKE LIGHT HAD GONE OFF AND THE BRAKES WERE BACK TO NORMAL. I DO NOT FEEL THAT FAILURE HAS BEEN CORRECTED AND THAT IS WHY I AM WRITING THIS COMPLAINT BECAUSE I FEEL THERE IS SAFETY ISSUE AT HAND. IT APPEARS TO BE SOME TYPE OF INTERMENT ELECTRICAL FAILURE INTERCONNECTED TO THE BRAKE SYSTEM THAT CLEARS THE FAILURE WHEN THE IGNITION KEY IS TURNED OFF ONLY TO REAPPEAR AT ANOTHER TIME. *TR
NHTSA ODI #10348902
48,000 miles · Apr 13, 2010
Service Brakes, HydraulicStructure
TL - THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 25 MPH DURING CLEAR WEATHER CONDITIONS THE ELECTRIC BRAKES CONTROL STOPPED WORKING. HE STATE THE VEHICLE HAS NOT BEEN REPAIRED. HE REFERENCED RECALL NHTSA CAMPAIGN ID NUMBER: 07E046000 (EQUIPMENT). THE CONTACT ALSO STATED THE RIGHT REAR DOOR OPENS IN COLD WEATHER CONDITIO…
Read full complaint
TL - THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 25 MPH DURING CLEAR WEATHER CONDITIONS THE ELECTRIC BRAKES CONTROL STOPPED WORKING. HE STATE THE VEHICLE HAS NOT BEEN REPAIRED. HE REFERENCED RECALL NHTSA CAMPAIGN ID NUMBER: 07E046000 (EQUIPMENT). THE CONTACT ALSO STATED THE RIGHT REAR DOOR OPENS IN COLD WEATHER CONDITIONS WHILE DRIVING. HE STATED THE PROBLEM WITH THE DOOR WAS REPAIRED BY THE DEALER. THE FAILURE MILEAGE WAS 48000 AND THE CURRENT MILEAGE WAS 57,000. VWB
NHTSA ODI #10325409
55,000 miles · Mar 22, 2010
Service Brakes, Hydraulic
I THINK THE BRAKE SYSTEM IN MY 2005 TITAN IS INADEQUATE. THE FRONT DISC ROTORS WERE BENT @ 20000 MILES AND REPLACED BY NISSAN FOR THIS DEFECT BUT AT 60000 MILES, THE FRONT DISC ROTORS WERE BENT AGAIN. MAKING STOPPING THIS TRUCK HAZARDOUS AS THE STEERING WHEEL IS SHAKING VIOLENTLY AND IT TOOK MUCH FARTHER TO STOP. I CHECK THE DIS…
Read full complaint
I THINK THE BRAKE SYSTEM IN MY 2005 TITAN IS INADEQUATE. THE FRONT DISC ROTORS WERE BENT @ 20000 MILES AND REPLACED BY NISSAN FOR THIS DEFECT BUT AT 60000 MILES, THE FRONT DISC ROTORS WERE BENT AGAIN. MAKING STOPPING THIS TRUCK HAZARDOUS AS THE STEERING WHEEL IS SHAKING VIOLENTLY AND IT TOOK MUCH FARTHER TO STOP. I CHECK THE DISC ROTORS AND THE BRAKE PADS AND THEY ARE NORMAL. I CONTACT NISSAN BUT THEY DIDN'T RESPONSE.*DT
NHTSA ODI #10321422
1,500 miles · Jan 21, 2010
Service Brakes, Hydraulic
ALTHOUGH I HAVEN'T HAD AN "INCIDENT" YET, I WORRY ABOUT IT EVERYDAY. MY 2005 NISSAN TITAN HAS THE WORST BRAKES THAT I'VE EVER HAD IN A VEHICLE. THE BRAKE PEDAL GOES TO THE FLOOR ON EVERY STOP. SOMETIMES WHILE THE BRAKE PEDAL IS DEPRESSED IT "SKIPS" AND IT FEELS LIKE THE BRAKES RELEASE THEN GRAB AGAIN. THIS TRUCK WAS MEANT TO TOW…
Read full complaint
ALTHOUGH I HAVEN'T HAD AN "INCIDENT" YET, I WORRY ABOUT IT EVERYDAY. MY 2005 NISSAN TITAN HAS THE WORST BRAKES THAT I'VE EVER HAD IN A VEHICLE. THE BRAKE PEDAL GOES TO THE FLOOR ON EVERY STOP. SOMETIMES WHILE THE BRAKE PEDAL IS DEPRESSED IT "SKIPS" AND IT FEELS LIKE THE BRAKES RELEASE THEN GRAB AGAIN. THIS TRUCK WAS MEANT TO TOW UP TO 9,000LBS, BUT WHEN I TOWED ABOUT 4,000 AND TRIED TO STOP, I ALMOST RAN INTO SOMEONE. THE BRAKES ARE HORRIBLE WITHOUT TOWING AND BEYOND ACCEPTABLE TOWING ANY WEIGHT. SINCE THAT HAPPENED, I HAVE YET TO TOW ANYTHING ELSE, I'M AFRAID THE TRUCK WON'T STOP. I'VE TAKEN IT TO THE DEALER MULTIPLE TIMES AND THEY ACKNOWLEDGE THE BRAKES AREN'T "WHAT THEY SHOULD BE" BUT THERE'S NOTHING THAT THEY CAN DO BECAUSE NISSAN HASN'T ADDRESSED THE PROBLEM. I'M HOPING THAT THIS PROBLEM COULD BE LOCKED INTO. THE DEALER ALSO TOLD ME THAT THE NISSAN ARMADA HAS THE SAME BRAKES AND THE SAME PROBLEMS. THANK YOU AS FAR AS THE INCIDENT DATE, I'M JUST USING THE FIRST DATE THAT I CAN REMEMBER REALIZING THE PROBLEM. *TR
NHTSA ODI #10301807
Official recalls
4Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration