IllustrationTHE FRONT AND REAR WHEEL SEALS AND SPACERS ARE FAULTY AND CAUSING FLUID TO LEAK OUT ONTO THE BRAKES AND BRAKE PADS. WHICH COULD CAUSE FIRE, BRAKING PROBLEMS AND IF UNFIXED COULD CAUSE THE FRONT/REAR END TO GO OUT ON THE TRUCK. *TR
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
Power Train complaints
469 reportsBACKING INTO PARKING SPOT, HEARD LOUD CLUNK FROM REAR END, DROVE THROUGHOUT DAY AND IT GOT WORSE WHEN TURNING OR ACCELERATING BOTH FORWARD AND REVERSE. VARIOUS SPEEDS IT OCCURS, HIGHWAY, DRIVEWAY, IT DOES NOT DIFFER. DIAGNOSED, NEEDS REAR AXLE REPLACEMENT. GARAGE APPROXIMATELY 2 GRAND, NISSAN ABOUT 4 GRAND. *TR
CREW CAB SHORT BED. 5.6L. SE MODEL. 4WD. 97,171 MILES REAR DIFFERENTIAL CATASTROPHICALLY FAILED IN A MATTER OF A COUPLE OF MILES. PROGRESSIVELY LOUDER LOW FREQUENCY GROWL. CLUNK WHEN SHIFTING FROM REVERSE TO DRIVE AND VICE VERSA. SEEPING DIFFERENTIAL GEAR OIL AND SEAL / BEARING FAILURE. CONSIDERABLE METAL SUSPENDED IN DIFFEREN…
Read full complaint
CREW CAB SHORT BED. 5.6L. SE MODEL. 4WD. 97,171 MILES REAR DIFFERENTIAL CATASTROPHICALLY FAILED IN A MATTER OF A COUPLE OF MILES. PROGRESSIVELY LOUDER LOW FREQUENCY GROWL. CLUNK WHEN SHIFTING FROM REVERSE TO DRIVE AND VICE VERSA. SEEPING DIFFERENTIAL GEAR OIL AND SEAL / BEARING FAILURE. CONSIDERABLE METAL SUSPENDED IN DIFFERENTIAL FLUID. ALL OF THIS HAPPENED IN A 24 HOUR PERIOD AND A COUPLE OF MILES AT LOW TO MODERATE CITY STREET SPEED. DRIVING HISTORY: MINIMAL 4WD OPERATION - PRIMARILY IN SNOW AND ICE DURING WINTER. NO MUDDING OR OFF ROADING. NO ROCK CLIMBING. HAVE FACTORY TOW PACKAGE AND TRANS. TOWS ULTRA LIGHT 24-FOOT TRAVEL TRAILER WEIGHING APPROXIMATELY 6,000 LBS (RATED TO TOW 9,500) FOUR TO FIVE TIMES A SUMMER. MAYBE 7,000 TOWING MILES. MAINLY FREEWAY AND CITY DRIVING. MINIMAL CARGO EVER IN BED. NORMALLY EMPTY. *TR
I HAVE A 2005 NISSAN TITAN WITH ONLY 44000 MILES ON IT. DURING RECENT DRIVING IT SOUNDED AS IF THE RIGHT REAR WAS GRINDING TO PIECES. IT CONTINUALLY GOT WORSE SO I LOOKED UNDER THE TRUCK TO SEE IF THERE WAS SOMETHING THAT WAS CAUGHT AND DRAGGING. IT WAS SO LOUD THAT PEOPLE WOULD STARE AT THE TRUCK WHEN IT PASSED BY. AFTER IT…
Read full complaint
I HAVE A 2005 NISSAN TITAN WITH ONLY 44000 MILES ON IT. DURING RECENT DRIVING IT SOUNDED AS IF THE RIGHT REAR WAS GRINDING TO PIECES. IT CONTINUALLY GOT WORSE SO I LOOKED UNDER THE TRUCK TO SEE IF THERE WAS SOMETHING THAT WAS CAUGHT AND DRAGGING. IT WAS SO LOUD THAT PEOPLE WOULD STARE AT THE TRUCK WHEN IT PASSED BY. AFTER IT WAS TAKEN TO THE GARAGE THEY DISCOVERED THAT THE INSIDES OF THE RIGHT REAR AXLE WERE ALMOST COMPLETELY TORN APART. IT WAS VERY FORTUNATE THAT IT DID NOT CAUSE A SERIOUS PROBLEM WHILE DRIVING. THEY ALSO FOUND THAT THE LEFT AXLE WAS LEAKING AND WOULD LIKELY ALSO BREAK DOWN. THE COST TO REPAIR THE TRUCK WAS OVER $1700.00. *TR
I NOTICED A BLACK DARK GREASE ON THE INNER RIM AND AXLE HUB. I WAS TOLD BY A NEIGHBOR WITH THE SAME MAKE AND YEAR THAT THIS IS A LEAKING BEARING SEAL AND THAT THE ENTIRE AXLE HAS TO BE REPLACED. I CONSIDER THIS A HAZARD IF THE BEARING SEAL HAS LEAKED ALL OVER THE REAR BRAKE PADS AND SHOES. *KB
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS TRAVELING UPHILL AT 25 MPH WHEN THE REAR PASSENGER SIDE TIRE SEIZED. THE CONTACT WAS ABLE TO GET THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE REAR DIFFERENTIAL FAILED. THE DEALER ALSO ADVISED THAT THE FAILURE WAS A COMMON FAILURE ON THE PARTICULAR YEAR AND MODEL. THE F…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT WAS TRAVELING UPHILL AT 25 MPH WHEN THE REAR PASSENGER SIDE TIRE SEIZED. THE CONTACT WAS ABLE TO GET THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE REAR DIFFERENTIAL FAILED. THE DEALER ALSO ADVISED THAT THE FAILURE WAS A COMMON FAILURE ON THE PARTICULAR YEAR AND MODEL. THE FAILURE MILEAGE WAS 90,000.
I WAS DRIVING MY 2005 NISSAN TITAN CREW CAB TRUCK. I HAD HEARD A CLICKING WHILE TURNING A WEEK PRIOR BUT DID NOT HERE IT AGAIN. A FEW DAYS LATER WHEN ALMOST HOME I TURNED THE CORNER AND HEARD A LOUD CLANKING SOUND IN THE REAR OF THE TRUCK. AS I GOT RIGHT AT MY STREET THE BACK END STARTED TO FREEZE UP AS THE TIRES STARTED TO LOCK…
Read full complaint
I WAS DRIVING MY 2005 NISSAN TITAN CREW CAB TRUCK. I HAD HEARD A CLICKING WHILE TURNING A WEEK PRIOR BUT DID NOT HERE IT AGAIN. A FEW DAYS LATER WHEN ALMOST HOME I TURNED THE CORNER AND HEARD A LOUD CLANKING SOUND IN THE REAR OF THE TRUCK. AS I GOT RIGHT AT MY STREET THE BACK END STARTED TO FREEZE UP AS THE TIRES STARTED TO LOCK UP I PARKED THE TRUCK ON SIDE OF ROAD. TRIED TO MOVE IT AFTER I LOOK UNDER THE TRUCK BUT IT WOULD NOT MOVE. I HAD IT TOWED TO THE LOCAL NISSAN DEALER WHERE I FOUND OUT THAT THE REAR DIFFERENTIAL NEEDS TO BE REPLACED ON IT AT A COST OF $4000.00!!!! I HAVE LOOKED ONLINE AND SEEN HUNDREDS OF COMPLAINTS ON THE SAME ISSUE. NISSAN IS TELLING ME THAT THEY HAVE NEVER SEEN THIS BEFORE. I JUST THANK GOD THAT I WAS NEXT TO MY HOUSE AS I WOULD HAVE LOST CONTROL / GOT HURT / OR HURT SOMEONE ELSE IF IT LOCKED UP WHILE DRIVING DOWN THE HIGHWAY. I CURRENTLY AWAITING IT TO BE FIXED. NOT SURE WHAT TO DO? *TR
BOTH REAR AXLE SEALS LEAKED AT 38,XXX IN 9/2009 AND WERE REPLACED UNDER WARRANTY. NO ISSUES FOR TWO YEARS. IN 8/2011 DRIVER SIDE IS LEAKING AGAIN. TRIED TO EXPRESS MY CONCERNS TO NISSAN AND WAS REJECTED BECAUSE OF "WARRANTY" ISSUES. SEEMS TO BE AN INHERENT PROBLEM EXPERIENCED BY A LOT OF 04-07' TITAN/ARMADA OWNERS. TSB ISSU…
Read full complaint
BOTH REAR AXLE SEALS LEAKED AT 38,XXX IN 9/2009 AND WERE REPLACED UNDER WARRANTY. NO ISSUES FOR TWO YEARS. IN 8/2011 DRIVER SIDE IS LEAKING AGAIN. TRIED TO EXPRESS MY CONCERNS TO NISSAN AND WAS REJECTED BECAUSE OF "WARRANTY" ISSUES. SEEMS TO BE AN INHERENT PROBLEM EXPERIENCED BY A LOT OF 04-07' TITAN/ARMADA OWNERS. TSB ISSUED BY NISSAN TO REPLACE ENTIRE AXLE ASSEMBLY 5 MONTHS AFTER MY FIRST LEAK, BUT THEY DON'T FEEL IT'S THEIR RESPONSIBILITY TO NOTIFY OWNERS WHO EXPERIENCED THE ISSUE PRIOR TO THE BULLETIN. WAS TOLD BY A NISSAN REP. THAT THE TSB IS A GUIDELINE FOR TECH'S. TO PROPERLY FIX AN ISSUE IF IT ARISES. I HAD THE ISSUE BUT IT WAS 5 MONTHS BEFORE THEY FIGURED OUT HOW TO DO A "PROPER" FIX, AND ACCORDING TO THEM IT DOESN'T APPLY TO ME UNLESS THE PART OR LABOR OR DRIVETRAIN WAS STILL UNDER WARRANTY. WAS TOLD THAT IF THIS WAS A WIDESPREAD ISSUE THEY MIGHT OFFER GOOD FAITH CREDIT. CURIOUS AS TO HOW MANY IT WILL TAKE FOR THEM TO NOT TURN THE BLIND EYE TO AN OBVIOUS PROBLEM WITH WHAT I FEEL IS A SAFETY ISSUE. IF THERE IS A PROBLEM WITH THE DRIVE AXLE OF A VEHICLE, I BELIEVE THAT SHOULD QUALIFY AS A SAFETY ISSUE OR RECALL. *TR
DRIVING HOME FROM WORK WHEN REAR DIFFERENTIAL FAILED AS I WAS CROSSING INTERSECTION. *TR
DRIVING HOME ONE EVENING THE TRUCK STARTED MAKING VERY LOUD NOISES IN THE REAR OF THE VEHICLE. AFTER CHECKING IT SEVERAL TIMES FOR OBVIOUS PROBLEMS I TOOK IT TO A LOCAL GARAGE WHO INFORMED ME THE REAR DIFFERENTIAL WAS THE PROBLEM. THEY ADVISED THERE WERE METAL SHAVINGS ALL INSIDE THE HOUSING. *TR
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.