IllustrationEngine stalled while driving then would crank but not start
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
Fuel/propulsion System complaints
68 reportsMy truck just stopped in the middle of the road while driving. I could not move the steering wheel and the engine would not turn over. The gas hand was registering a quarter of a tank of fuel so I did not think that I had run out of gas. After being towed to the shop the mechanic checked the vehicle and said that it was just o…
Read full complaint
My truck just stopped in the middle of the road while driving. I could not move the steering wheel and the engine would not turn over. The gas hand was registering a quarter of a tank of fuel so I did not think that I had run out of gas. After being towed to the shop the mechanic checked the vehicle and said that it was just out of gas but the gas gauge was still registering 1/4 of a tank of gas. Gas was put in the truck and it started right up. The mechanic informed me of a recall on the 2005 nissan titans that matched what was happening to my truck. When I informed nissan they told me there is a recall but that my vin number is not included in the recall. I have had the same incident where the truck just shut off 2 more times now and this should be covered by the nissan recall since this is the exact problem that is happening to my truck that is stated in the recall and my truck is the exact year. Can someone please help me to get nissan to honor this recall for my truck? Recall ID#68290
THE INSTRUMENT PANEL FUEL GAUGE INACCURATELY DISPLAYS THAT THE VEHICLE STILL HAS SOME FUEL, AT ONE QUARTER TANK, WHEN THE FUEL TANK IS ACTUALLY EMPTY. THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH. THERE IS A RECALL FOR THIS BUT WAS TOLD THAT MY TRUCK WAS NOT AFFECTED EVEN TH…
Read full complaint
THE INSTRUMENT PANEL FUEL GAUGE INACCURATELY DISPLAYS THAT THE VEHICLE STILL HAS SOME FUEL, AT ONE QUARTER TANK, WHEN THE FUEL TANK IS ACTUALLY EMPTY. THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH. THERE IS A RECALL FOR THIS BUT WAS TOLD THAT MY TRUCK WAS NOT AFFECTED EVEN THOUGH IT IS HAVING THE SAME ISSUE.
THE FEEL GAUGE DOES NOT SHOW ACCURATE GASOLINE LEVELS. IT DOES THIS REGARDLESS OF SPEED OR WHETHER THE VEHICLE IS STATIONARY. THIS IS VERY UNSAFE AS IF YOU WERE TRAVELING AT HIGH SPEEDS AND RAN OUT OF GAS YOU COULD CAUSE A CRASH. THE FUEL GAUGE CAN SHOW YOU HAVE HALF A TANK BUT YOU ONLY ACTUALLY HAVE A QUARTER OF A TANK. THERE I…
Read full complaint
THE FEEL GAUGE DOES NOT SHOW ACCURATE GASOLINE LEVELS. IT DOES THIS REGARDLESS OF SPEED OR WHETHER THE VEHICLE IS STATIONARY. THIS IS VERY UNSAFE AS IF YOU WERE TRAVELING AT HIGH SPEEDS AND RAN OUT OF GAS YOU COULD CAUSE A CRASH. THE FUEL GAUGE CAN SHOW YOU HAVE HALF A TANK BUT YOU ONLY ACTUALLY HAVE A QUARTER OF A TANK. THERE IS A RECALL FOR THIS FOR ANOTHER MODEL BUT NOT FOR MINE.
INSTRUMENT PANEL FUEL GAUGE NOT PROPERLY READING AMOUNT OF FUEL IN TANK. THIS CAUSED THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE CITY STREET, WHICH COULD HAVE CAUSED A CRASH.
I HAVE HAD THE TRUCK FOR ABOUT 3 YEARS AND ITS GETTING WORSE FUEL TANK IS HARD TO FILL AND MAKES A WHISTLING SOUND.
GAS GUAGE SAYS 189 THEN DROPS TO 70 AND CHANGES EVERY 5 MINS AND ITS DIED WITH READING HALF FULL AND 197 MILES TILL EMPTY IT FLUCTUATES IN MOTION AT A STOP AT RANDOM TIMES
THEIR IS A CURRENT RECALL ON THE FUEL SYSTEM FOR THE GAUGE READING INCORRECTLY AND COULD CAUSE AN ACCIDENT. MY TRUCK IS HAVING THAT ISSUE, BUT MY VIN SHOWS NOT TO BE UNDER THAT RECALL. I AM ALSO HAVING ENGINE PROBLEMS THAT I ALSO BELIEVE TO BE DUE TO A FAILING FUEL PUMP OR POSSIBLY ONE OF THE OTHER MANY PROBLEMS WITH ENGINE PERF…
Read full complaint
THEIR IS A CURRENT RECALL ON THE FUEL SYSTEM FOR THE GAUGE READING INCORRECTLY AND COULD CAUSE AN ACCIDENT. MY TRUCK IS HAVING THAT ISSUE, BUT MY VIN SHOWS NOT TO BE UNDER THAT RECALL. I AM ALSO HAVING ENGINE PROBLEMS THAT I ALSO BELIEVE TO BE DUE TO A FAILING FUEL PUMP OR POSSIBLY ONE OF THE OTHER MANY PROBLEMS WITH ENGINE PERFORMANCE ON THIS MODEL TITAN. I DON'T UNDERSTAND WHY THE RECALL FOR THE FUEL GAUGE PROBLEM IS NOT COVERING MY VEHICLE , I HAVE HAD MANY PROBLEMS WITH MY NISSAN TITAN SINCE I BOUGHT IT BRAND NEW AND ABSOLUTELY NO HELP FROM NISSAN TO FIX FAULTY PARTS, INCLUDING THE VALVE COVER THAT IF CLOGGED WILL ALLOW ENGINE OIL DOWN INTO THE VALVES AND CYLINDER AND CAUSE SMOKING PROBLEM, AND EVENTUALLY RUIN THE ENGINE CYLINDER. MY TITAN WILL NOT TAKE FUEL AND STARTS STALING OUT AT 2000 RPM CAUSING ME TO ALMOST BE IN SEVERAL ACCIDENTS ALREADY. ALL VEHICLES WITH PARTS THAT ARE BEING RECALLED SHOULD BE INVOLVED IN THE RECALL. NISSAN SHOULD'NT BE ABLE TO PIC AND CHOOSE WHO GETS COVERED, THEY SHOULD MAN UP AND FIX THEIR CHEAP PARTS WHEN THEY FAIL.
I WAS DRIVING ON A CITY STREET AND STOPPED FOR A RED TRAFFIC SIGNAL TO MAKE A RIGHT TURN ONTO A HIGHWAY. WITHOUT ANY WARNING THE ENGINE SUDDENLY STOPPED RUNNING. I WAS UNABLE TO RESTART THE ENGINE. I WAS BLOCKING THE LANE OF TRAFFIC TO ENTER THE HIGHWAY. I HAD TO HAVE THE VEHICLE TOWED AS IT WOULD NOT START AND IT WAS A TRAF…
Read full complaint
I WAS DRIVING ON A CITY STREET AND STOPPED FOR A RED TRAFFIC SIGNAL TO MAKE A RIGHT TURN ONTO A HIGHWAY. WITHOUT ANY WARNING THE ENGINE SUDDENLY STOPPED RUNNING. I WAS UNABLE TO RESTART THE ENGINE. I WAS BLOCKING THE LANE OF TRAFFIC TO ENTER THE HIGHWAY. I HAD TO HAVE THE VEHICLE TOWED AS IT WOULD NOT START AND IT WAS A TRAFFIC HAZARD/BLOCKING TRAFFIC. THE VEHICLE WAS TOWED TO AN AUTO REPAIR SHOP. THE MECHANIC DISCOVERED THE VEHICLE'S GAS TANK WAS COMPLETELY EMPTY, DESPITE THE FUEL GAUGE SHOWING THE GAS TANK JUST OVER 1/4 TANK FULL. THE MECHANIC FOUND A RECALL NOTICE, NHTSA RECALL BULLETIN #10V074000 FOR MY VEHICLE, 2005 NISSAN TITAN, DESCRIBING THE EXACT DEFECT THAT MY VEHICLE EXPERIENCED; "THE FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT 1/4 TANK, WHEN THE FUEL TANK IS EMPTY." I TOOK MY VEHICLE TO A NISSAN DEALER AND THEY TOLD ME THAT MY VEHICLE IS NOT INCLUDED IN THIS RECALL DUE TO THE VIN, EVEN THOUGH IT IS THE SAME YEAR/MAKE/MODEL, 2005 NISSAN TITAN, AND HAS THE EXACT SAME DEFECT AS THE ONE DESCRIBED IN THE ABOVE MENTIONED NHTSA RECALL BULLETIN. HAD I ENTERED THE HIGHWAY WHEN THE ENGINE STOPPED SUDDENLY WITHOUT WARNING, I MOST LIKELY WOULD HAVE CRASHED. SEE THE ATTACHED DIAGNOSTIC REPAIR INVOICE, NHTSA RECALL BULLETIN #10V074000, AND NISSAN SERVICE BULLETIN. I BELIEVE THAT MY VEHICLE IS OR SHOULD BE INCLUDED IN THE EXISTING NHTSA RECALL AND NISSAN SHOULD COMPLY WITH THE RECALL AND REPAIR THE DEFECT AT NO COST TO ME.
I PURCHASED A USED 2005 NISSAN TITAN WITH ALMOST 117,000 MILES ON IT. EVEN THOUGH IT WAS 14 YEARS IT WAS IN EXCELLENT CONDITION AND WELL MAINTAINED. I SEARCHED THE NISSAN WEBSITE FOR ANY POSSIBLE RECALLS BECAUSE ANOTHER TITAN I HAD LOOKED AT HAD SEVERAL RECALLS. THE SEARCH SHOWED NO RECALLS FOR MY VIN NUMBER. THEN I CALLED THE …
Read full complaint
I PURCHASED A USED 2005 NISSAN TITAN WITH ALMOST 117,000 MILES ON IT. EVEN THOUGH IT WAS 14 YEARS IT WAS IN EXCELLENT CONDITION AND WELL MAINTAINED. I SEARCHED THE NISSAN WEBSITE FOR ANY POSSIBLE RECALLS BECAUSE ANOTHER TITAN I HAD LOOKED AT HAD SEVERAL RECALLS. THE SEARCH SHOWED NO RECALLS FOR MY VIN NUMBER. THEN I CALLED THE LOCAL NISSAN DEALER TO VERIFY THE INFORMATION. AFTER 2 SHORT TRIPS I NOTICED IT DID NOT USE ENOUGH GASOLINE TO MOVE THE GAUGE FROM SLIGHTLY OVER A QUARTER OF A TANK. ON THE THIRD TRIP THE ENGINE QUIT ON A RURAL PAVED ROAD, FORTUNATELY THERE WAS A LARGE GRASSY AREA I COULD COAST TO. I KNEW SOME TITANS HAD BEEN RECALLED FOR THE FUEL GAUGE SHOWING AROUND A QUARTER OF A TANK WHEN THEY WERE EMPTY. FORTUNATELY AGAIN I WAS ONLY 2 MILES FROM HOME WHERE I HAD A GAS CAN WITH GAS IN IT AND MY WIFE WAS AT HOME TO BRING IT TO ME. AFTER FILLING ALL 5 GALLONS INTO THE TANK, THE TRUCK CRANKED UP AND DROVE WITH NO PROBLEMS. I IMMEDIATELY REFUELED AT THE NEXT FUEL STATION WHERE IT TOOK ANOTHER 23 GALLONS TO FILL UP, 28 GALLONS TOTAL, THAT IS THE ENTIRE CAPACITY OF THE FUEL TANK. I FEEL THAT NISSAN PUT MY AND MY FAMILIES LIFE AT RISK BY NOT ACKNOWLEDGING A WIDER PROBLEM AND EXPANDING THE FUEL LEVEL SENDING UNIT RECALL. FUEL LEVEL IS A SAFETY CONCERN RIGHT AFTER BRAKES, STEERING AND TIRES, NOT TO BE OVERLOOKED. THIS SITUATION COULD HAVE ENDED IN TRAGEDY, MANY PEOPLE HAVE LOST THEIR LIFE BECAUSE THEY RAN OUT OF GASOLINE AND IT PUT THEM IN A DANGEROUS SITUATION. EVEN THOUGH THE ENGINE SHUTTING OFF IS NOT A DANGER IN ITSELF, LIKE WITH AN AIRPLANE, IT'S WHAT HAPPENS AFTER THE VEHICLE STOPS AND THE OTHER TRAFFIC IS STILL MOVING THAT RESULTS IN TRAGEDY.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.