IllustrationCRACKED EXHAUST MANIFOLDS BOTH SIDES. NOTICED IT AROUND 60000 MILES. VEHICLE PURCHASED FROM DENNIS DILLON NISSAN BOISE IDAHO. DEALER HAS BEEN NO HELP AS OF YET EVEN THOUGH THE CATALYTIC SYSTEM HAS A 8/80 WARRANTY . *TR
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
Engine complaints
61 reportsPLEASE ISSUE A RECALL FOR THE DEFECTIVE EXHAUST MANIFOLDS FOR THE NISSAN TITANS. I KNOW THAT THERE IS A WARRANTY UP TO 80000 MILES BUT MY TRUCK IS OVER THAT MILEAGE. THIS IS A KNOWN FACTORY DEFECT THAT CAN BE VERY DANGEROUS DUE TO EXHAUST LEAKAGE. *TR
AFTER HAVING IPDM MODULE REPLACED (CAMPAIGN NUMBER 10V517000), THE SES LIGHT SHOWED BAD CATALYTIC CONVERTERS WITHIN A FEW THOUSAND MILES. THE IPDM MODULE FAILED BEFORE BEING REPLACED AND IT CAUSED RAW FUEL TO BE DUMPED ON THE CATALYTIC CONVERTERS WHICH CAUSED THEM TO FAIL. I THINK NISSAN SHOULD BE RESPONSIBLE FOR THE COST OF F…
Read full complaint
AFTER HAVING IPDM MODULE REPLACED (CAMPAIGN NUMBER 10V517000), THE SES LIGHT SHOWED BAD CATALYTIC CONVERTERS WITHIN A FEW THOUSAND MILES. THE IPDM MODULE FAILED BEFORE BEING REPLACED AND IT CAUSED RAW FUEL TO BE DUMPED ON THE CATALYTIC CONVERTERS WHICH CAUSED THEM TO FAIL. I THINK NISSAN SHOULD BE RESPONSIBLE FOR THE COST OF FAILED CATALYTIC CONVERTERS WHEN THEIR FAULTY PART CAUSED THE DAMAGE. THIS IS AN EXPENSIVE REPAIR ($2,800). AFTER LOOKING AT FORUMS ON THE INTERNET, I SEE MANY PEOPLE HAVING ISSUES WITH THE TITAN CATALYTIC CONVERTERS AND HAVING THEM FAIL BEFORE THE VEHICLE REACHES 100K MILES. I FILED A COMPLAINT WITH NISSAN AND THEY WOULD NOT HELP WITH THE REPAIR. THEY SAID THE FAULTY IPDM WOULD NOT CAUSE CATS TO FAIL. *TR
TRUCK IN MID 50'S RANDOMLY STALLS AT HIGHWAY SPEED AND WILL NOT RESTART. ALL SYMPTOMS IDENTICAL TO EVERY OTHER OF THE MANY THOUSANDS OF COMPLAINTS OF ECM/IPDM FAILURE. NISSAN CLAIMS RELAY FOR RECALL WAS CHANGED IN 2011, THAT WE HAVE NO OPEN RECALL AND NO OTHER RECOURSE OTHER THAN TO CALL NISSAN AMERICA--EVEN FOR JUST A REPLACEM…
Read full complaint
TRUCK IN MID 50'S RANDOMLY STALLS AT HIGHWAY SPEED AND WILL NOT RESTART. ALL SYMPTOMS IDENTICAL TO EVERY OTHER OF THE MANY THOUSANDS OF COMPLAINTS OF ECM/IPDM FAILURE. NISSAN CLAIMS RELAY FOR RECALL WAS CHANGED IN 2011, THAT WE HAVE NO OPEN RECALL AND NO OTHER RECOURSE OTHER THAN TO CALL NISSAN AMERICA--EVEN FOR JUST A REPLACEMENT RELAY THAT COSTS THEM PENNIES. NISSAN AMERICA SAYS THE LOCAL DEALERSHIP MUST RECTIFY THE PROBLEM. THESE HUGE TRUCKS ARE STALLING AT HIGHWAY SPEED ALL OVER THE COUNTRY. I SPECIFICALLY ASKED MY LOCAL DEALER TO CHECK FOR THIS KNOWN ISSUE THE LAST TIME IT HAPPENED AND THEY KEPT MY TRUCK FOR A WEEK AND CHANGED THE BATTERY TERMINALS--FOR $400 INSTEAD OF CHECKING THE $4.00 RELAY. THAT'S RETAIL--IT COSTS THEM ABOUT A QUARTER. EVEN WITH THE .3 HOURS OF LABOR, IT WOULD HAVE BEEN UNDER $90 FOR ME AT FULL RETAIL. INSTEAD, I STALLED AGAIN AT HIGHWAY SPEED 3 WEEKS LATER. I DO NOT BELIEVE FOR A MINUTE THAT THERE HAVE BEEN NO DEATHS DIRECTLY RELATED TO THIS PROBLEM. HOW HAS THERE NOT BEEN A FULL INVESTIGATION AND NEWS REPORTS OF THIS FREQUENTLY REPORTED PROBLEM? *TR
LOUD EXHAUST SOUND COMING FROM THE FRONT, ON BOTH SIDES FOR THE ENGINE COMPARTMENT. DUE TO A CRACKED MANIFOLD. I COULD ALSO SMELL EXHAUST FUMES INSIDE. I KEEP THE WINDOW CRACKED OPEN WHEN I DRIVE FOR SAFETY REASONS, MOSTLY WHEN I HAVE MY WIFE AND KIDS IN THE VEHICLE. *TR
RADIATOR BEGAN LEAKING AND HAD TO BE REPLACED DUE TO CRACKS/SEPARATION OF PLASTIC COMPONENTS. *TR
WHILE DRIVING MY TRUCK HOME FROM WORK,I NOTICED THE SOUND OF THE EXHAUST BECAME PROGRESSIVELY LOUDER. I PARKED THE TRUCK FOR THE NIGHT. PRIOR TO LEAVING THE NEXT MORNING I TRIED TO LOCATE THE SOURCE OF THE INCREASED NOISE. HOWEVER, I NOTICED AFTER STARTING THE VEHICLE THE NOISED WOULD DECREASE. THEREFORE, I TOOK THE TRUCK TO M…
Read full complaint
WHILE DRIVING MY TRUCK HOME FROM WORK,I NOTICED THE SOUND OF THE EXHAUST BECAME PROGRESSIVELY LOUDER. I PARKED THE TRUCK FOR THE NIGHT. PRIOR TO LEAVING THE NEXT MORNING I TRIED TO LOCATE THE SOURCE OF THE INCREASED NOISE. HOWEVER, I NOTICED AFTER STARTING THE VEHICLE THE NOISED WOULD DECREASE. THEREFORE, I TOOK THE TRUCK TO MY MECHANIC FOR DIAGNOSIS. HE TOLD ME THAT THE HEADER ON ONE SIDE IS CRACKED AND THE OTHER HEADER ON THE OTHER-SIDE SHOWS SIGNS OF STRESS. ALSO, HE EXPLAINED THIS A COMMON ISSUE WITH THE NISSAN TITAN AND I MIGHT WANT TO EXPLORE MY REPAIR OPTION WITH THE LOCAL NISSAN DEALERSHIP. HOWEVER, AFTER DISCUSSING THIS ISSUE WITH THE NISSAN DEALERSHIP, I WAS TOLD THERE IS NO RECALL FOR THE NOTORIOUS ISSUE AND THE COST OF THE REPAIR IS MY RESPONSIBILITY. UPON HEARING THIS, I DECIDE I WOULD LODGE MY COMPLAINT ABOUT THIS ISSUE HERE. *TR
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE PARKED, THE CONTACT SMELLED A STRONG ODOR OF RADIATOR FLUID INSIDE OF THE VEHICLE. HE ALSO NOTICED A CONSTANT LEAK OF FLUID FROM THE RADIATOR WHICH FORMED A LARGE PUDDLE ON THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES WHERE THE RADIA…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE PARKED, THE CONTACT SMELLED A STRONG ODOR OF RADIATOR FLUID INSIDE OF THE VEHICLE. HE ALSO NOTICED A CONSTANT LEAK OF FLUID FROM THE RADIATOR WHICH FORMED A LARGE PUDDLE ON THE GROUND. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES WHERE THE RADIATOR WAS REPLACED EACH TIME. MOST RECENT THE FAILURE RECURRED AND THE VEHICLE WAS IN THE PROCESS OF BEING DIAGNOSED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE FAILURE MILEAGE AND VIN WERE UNAVAILABLE.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE EXHAUSTS MANIFOLD CRACKED DUE TO DEFECTIVE MATERIAL AND CAUSED THE FUMES TO PENETRATE THE VEHICLE INTERIOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 130,00…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE EXHAUSTS MANIFOLD CRACKED DUE TO DEFECTIVE MATERIAL AND CAUSED THE FUMES TO PENETRATE THE VEHICLE INTERIOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 130,000.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL TICKING SOUND. THE CONTACT STATED THAT THE TICKING SOUND WOULD CEASE AFTER THE ENGINE BECAME WARM. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR THE FAILURE. THE DEALER ADVISED THAT THE EXHAUST MANIFOLD WAS …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT WHILE STARTING THE VEHICLE, THE CONTACT HEARD AN ABNORMAL TICKING SOUND. THE CONTACT STATED THAT THE TICKING SOUND WOULD CEASE AFTER THE ENGINE BECAME WARM. THE CONTACT TOOK THE VEHICLE TO A DEALER FOR THE FAILURE. THE DEALER ADVISED THAT THE EXHAUST MANIFOLD WAS CRACKED AND NEEDED TO BE REPLACED. THE DEALER DID NOT STATE WHAT CAUSED THE MANIFOLD TO CRACK. THE CONTACT REPLACED THE EXHAUST MANIFOLD. THE FAILURE MILEAGE WAS 83,000.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.