WHILE DRIVING ONE THE HIGHWAY I NOTICED MY VEHICLE START TO SHUTTER AND SHUT DOWN AS IF IT RAN OUT OF GAS. MY FUEL GAUGE SAID HALF A TANK SO I DIDN'T THINK IT WAS THE PROBLEM UNTIL I WALKED TO THE GAS STATION TO FILL UP A GAS CAN. I PUT 2 GALLONS OF GAS INTO MY FUEL TANK THAT SAID I HAD A HALF A TANK. I STARTED MY TRUCK AND IT S…
Read full complaint
WHILE DRIVING ONE THE HIGHWAY I NOTICED MY VEHICLE START TO SHUTTER AND SHUT DOWN AS IF IT RAN OUT OF GAS. MY FUEL GAUGE SAID HALF A TANK SO I DIDN'T THINK IT WAS THE PROBLEM UNTIL I WALKED TO THE GAS STATION TO FILL UP A GAS CAN. I PUT 2 GALLONS OF GAS INTO MY FUEL TANK THAT SAID I HAD A HALF A TANK. I STARTED MY TRUCK AND IT STARTED. SINCE THAT INCIDENT IT HAS HAPPENED 3 TIMES, THE MOST RECENT BEING YESTERDAY 07/02/18. I REPLACED THE FUEL PUMP TODAY IN HOPES THAT IT FIXES THE PROBLEM.
NHTSA ODI #11105393
121,000 miles · Mar 23, 2018
Engine
2005 NISSAN TITAN 121K MILES. CRACKED EXHAUST MANIFOLD CAUSING A EXHAUST LEAK. THERE IS A STRONG EXHAUST SMELL IN THE CAB WHEN TRAVELING AT SLOWER SPEEDS (UNDER 35MPH). IT HAS BEEN SO BAD AT TIMES IT MAKES YOU LIGHT HEADED AND SICK TO YOUR STOMACH. THIS COULD CAUSE SOMEONE TO PASS OUT WHILE DRIVING CAUSING THEM TO LOOSE CONTROL …
Read full complaint
2005 NISSAN TITAN 121K MILES. CRACKED EXHAUST MANIFOLD CAUSING A EXHAUST LEAK. THERE IS A STRONG EXHAUST SMELL IN THE CAB WHEN TRAVELING AT SLOWER SPEEDS (UNDER 35MPH). IT HAS BEEN SO BAD AT TIMES IT MAKES YOU LIGHT HEADED AND SICK TO YOUR STOMACH. THIS COULD CAUSE SOMEONE TO PASS OUT WHILE DRIVING CAUSING THEM TO LOOSE CONTROL OF THEIR VEHICLE. DEFIANTLY A SAFETY HAZARD! ALSO CAUSING A DECREASE IN GAS MILEAGE AS WELL AS A LOUD KNOCKING/PUFFING NOISE UPON ACCELERATION. I HAVE SEARCHED THE INTERNET FINDING 100'S IF NOT 1000'S OF COMPLAINTS ABOUT THIS! WHY HAS THIS NEVER BEEN RECALLED? THE SAFETY ISSUE ALONE SHOULD WARRANT A RECALL, ITS OBVIOUSLY A FAULTY COMPONENT!
NHTSA ODI #11081019
Mileage unknown · Sep 18, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER (RIVERHEAD NISSAN, 1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) WHO STATED THAT THEY REPAIRED THE VEHICLE WITH A WARRANTY REPAIR CONCERNING THE EXHAUST MANIFOLD. THE CONTACT REPORTED TO THE DEALER AND THE MANUFACTURER…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER (RIVERHEAD NISSAN, 1800 OLD COUNTRY RD, RIVERHEAD, NY 11901, (631) 369-0600) WHO STATED THAT THEY REPAIRED THE VEHICLE WITH A WARRANTY REPAIR CONCERNING THE EXHAUST MANIFOLD. THE CONTACT REPORTED TO THE DEALER AND THE MANUFACTURER THAT THE REPLACEMENT PART FAILED AGAIN AND WAS UNCERTAIN IF THE MANUFACTURER WOULD PROVIDE A SOLUTION WITH NO RECALL CAMPAIGN. THE WARRANTY REPLACEMENT PART PROVIDED NO SOLUTION AND, A FEW YEARS LATER, THERE WAS A CRACK AND LEAK WHICH FROM THE EXHAUST MANIFOLD. IN ADDITION, THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V517000 (ENGINE AND ENGINE COOLING). THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISOCNNECT.
NHTSA ODI #11024081
84,000 miles · Aug 10, 2017
Engine
EXHAUST MANIFOLD CRACKED AT LESS THAN 85000 MILES
NHTSA ODI #11014522
Mileage unknown · Jul 28, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MELLOY NISSAN (LOCATED AT 7707 LOMAS BLVD NE, ALBUQUERQUE, NM 87110) WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT REPAIRED T…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 65 MPH, THE VEHICLE LOST POWER AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO MELLOY NISSAN (LOCATED AT 7707 LOMAS BLVD NE, ALBUQUERQUE, NM 87110) WHERE IT WAS DIAGNOSED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CONTACT REPAIRED THE VEHICLE HIMSELF; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE.
NHTSA ODI #11011354
134,000 miles · Jul 14, 2017
EnginePower Train
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE LOST POWER WHILE AT A STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RADIATOR AND TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REP…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE VEHICLE LOST POWER WHILE AT A STOP. THERE WERE NO WARNING INDICATORS ILLUMINATED. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE RADIATOR AND TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 134,000.
NHTSA ODI #11005343
31,000 miles · Jul 9, 2017
Engine
MY NISSAN TITAN HAS ROUGHLY 31,000 MILES ON IT OVER THE LAST 12 YEARS . THE EXHAUST MANIFOLD IS CRACKED . I DID A SEARCH TO SEE IF THIS WAS A KNOWN PROBLEM AND THERE ARE TONS OF COMPLAINTS AND PICTURES ON THE INTERNET SO I WAS AMAZED TO SEE THAT THERE ARE NO RECALLS . MANY PEOPLE HAVE HAD THE ISSUE TAKEN CARE OF UNDER THE 8 YEA…
Read full complaint
MY NISSAN TITAN HAS ROUGHLY 31,000 MILES ON IT OVER THE LAST 12 YEARS . THE EXHAUST MANIFOLD IS CRACKED . I DID A SEARCH TO SEE IF THIS WAS A KNOWN PROBLEM AND THERE ARE TONS OF COMPLAINTS AND PICTURES ON THE INTERNET SO I WAS AMAZED TO SEE THAT THERE ARE NO RECALLS . MANY PEOPLE HAVE HAD THE ISSUE TAKEN CARE OF UNDER THE 8 YEAR 80,000 MILE EMISSIONS WARRANTY . THE ONLY PROBLEM IS MANY PEOPLE ( INCLUDING MYSELF ) ARE PAST THE 8 YEARS EVEN THOUGH WAY UNDER THE MILEAGE . MY TRUCK IS PRACTICALLY BRAND NEW INSIDE AND OUT AND HAS BEEN SPARINGLY USED AND STILL NOW I HAVE HARMFUL EXHAUST FUMES LEAKING OUT AND THE TRUCK IS ROBBED OF POWER .
NHTSA ODI #11003844
189,963 miles · Jun 29, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT OBSERVED AN ABNORMAL ODOR INSIDE THE VEHICLE WITHOUT WARNING. IN ADDITION, THE CONTACT NOTICED A FRACTURE WITHIN THE EXHAUST MANIFOLD/PIPES, WHICH LEAKED FUMES BACK INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT OBSERVED AN ABNORMAL ODOR INSIDE THE VEHICLE WITHOUT WARNING. IN ADDITION, THE CONTACT NOTICED A FRACTURE WITHIN THE EXHAUST MANIFOLD/PIPES, WHICH LEAKED FUMES BACK INTO THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 189,963.
NHTSA ODI #11002094
90,500 miles · Apr 24, 2017
Engine
CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NO…
Read full complaint
CRACKED EXHAUST MANIFOLDS. NISSAN HAS A POOR DESIGN AND I HAVE CHECKED ON LINE AND 100'S OF OTHERS HAVE COMMENTED ABOUT THE CRACKED EXHAUST MANIFOLDS. THESE ARE A SAFETY CONCERN AS I CAN SMELL THE EXHAUST GAS AROUND THE FRONT OF THE TRUCK, INSTEAD OF IT BEING PROPERLY TRANSFERRED OUT THE EXHAUST SYSTEM AS DESIGNED. NISSAN IS NOT SUPPORTING THE REQUIRED REPLACEMENT WHICH SHOULD BE FREE. THE REPAIR COST ARE IN THE THOUSANDS NOT ACCEPTABLE WHEN IT IS NISSAN POOR DESIGN ALL ALL TRUCKS WITH THESE MANIFOLDS ARE AFFECTED.
NHTSA ODI #10980273
122,000 miles · Feb 9, 2017
Engine
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE F…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING THE FAILURE WAS PERSISTENT. THE CONTACT ALSO STATED THAT THE VEHICLE FAILED TO INCREASE SPEED WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 122,000. UPDATED 04/10/17 LJ *CN
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2005 Nissan Titan Problems, Complaints & Recalls | Skip That Year
Illustration