2005 Nissan Titan

ROUTING OF MAIN REAR WIRING HARNESS THROUGH THE RIGHT REAR WHEEL WELL EXPOSES HARNESS TO ROAD DEBRIS, SAND, WATER, SALT, SNOW, ICE, ETC. WHICH DEGRADES THE HARNESS PREMATURELY CAUSING AND ELECTRICAL SHORT IN THE HARNESS. THE SHORT IN THE HARNESS CAUSED THE WIRE INSULATION TO CATCH FIRE AND MELT ALL ELECTRICAL INSULATING MATERIAL AND THE HARNESS JACKET. THE HARNESS SHORT, IN-TURN SHORTED OUT THE BCM (BODY CONTROL MODULE) CAUSING THE FAILURE OF ALL SYSTEMS CONTROLLED BY THE BCM (LIGHTS, TURN SIGNALS, BRAKE LIGHTS, HAZARD LIGHTS, ETC.) *LN

2/3/10: 2005 NISSAN TITAN BREAKS DOWN ON HWY 71 AT THE LIGHT RIGHT BEFORE THE ENTRANCE TO THE AIRPORT. MY 120 LBS FIANC HAS TO WORK TO PUSH THE TRUCK OUT OF THE LANE WITH CARS RACING BY AT 60 MPH WITH OUR 8 MONTH OLD DAUGHTER. 2/4/10: ENGAGED TERRY WISDOM WITH MAXWELL NISSAN IN ROUND ROCK AND HE WORKED TO HAVE MY ECM RELAY SWITCHED OUT AND CHARGES $340.06 FOR THE REPAIR.12/29/10: RECEIVED RECALL NOTICE ADVISES TO CONTACT NISSAN DEALER. 12/30/10: - ENGAGED SERVICE ADVISOR AT MAXWELL NISSAN IN RR ABOUT THE RECALL AND THEIR RECENT WORK IN FEBRUARY. SHE ADVISED I HAVE TO CALL INTO NISSANS 800 NUMBERS IN ORDER TO MOVE FORWARD WITH THE RECALL. SHE OFFERS MINIMAL ASSISTANCE WITH BRIDGING THAT GAP. I ASKED HER TO HAVE HER SUPERVISOR ENGAGE. SUPERVISORS CALLS BACK AND ADVISES THAT I HAVE CALL INTO NISSANS 800. PROVIDES DOCUMENTS, I ASK FOR ASSISTANCE? AND STATES HIS DEALERSHIPS CAN NOT GET INVOLVED. I SHOULD HAVE "CONSIDER TOYOTA OR FORD WITH MY PURCHASE" BUT MY ISSUES ARE WITH A NISSAN. CONTACT NISSAN NORTH AMERICA KALA ADVISES TO GO BACK TO THE DEALERSHIP TO HAVE THE PART RE-REPLACED DUE TO THE SERVICE TOOK PLACE IN FEB AND THIS RECALL STATES ANYTHING BEFORE NOVEMBER HAS TO ALSO BE REPLACED. FILE # 7042010 ENGAGE GM FOR MAXWELL NISSAN AND I INFORM HIM OF THE HISTORY WITH THIS ISSUE AND CUSTOMER SERVICE EXPERIENCE IVE RECEIVED WITH HIS SERVICE DEPARTMENT. HAVE I CONSIDERED GOING TO BACK TO THE DEALERSHIP WHERE I PURCHASED THE TRUCK FROM COMPARES MY EXPERIENCE TO HIS DELL HARD DRIVE CRASHING. I ADVISED THAT MY CHECK FOR SERVICE IF FEBRUARY WAS CUT TO HIS DEALERSHIP AND FOR ASSISTANCE WITH THE ENGAGEMENT, HE WOULD NOT. I ADVISED THAT I WAS GOING TO POST MY EXPERIENCE ON YOUTUBE OR FACEBOOK, IF YOU DO, DO NOT COME BACK TO THIS DEALERSHIP! SERVICE ADVISOR MANAGER IT IS SAD TO SEE OUR SOCIETY COME TO THE POINT OF HAVING TO USE SOCIAL MEDIA

NISSAN TITAN STALLED IN THE MIDDLE OF THE ROAD. I WAS DRIVING RUNNING ERRANDS WHEN SUDDENLY MY TRUCK STALLED IN THE MIDDLE OF THE ROAD, I WAS ABLE TO COAST TO THE SHOULDER LANE TO LET TRAFFIC THROUGH AND TO AVOID GETTING HIT. I WAS ABLE TO START THE ENGINE BACK AND HEADED HOME. I DID A LITTLE RESEARCH ONLINE AND CAME TO FIND OUT THAT NISSAN TITAN IS HAVING THIS PROBLEM WITH THE IPDM ECU RELAY. I THINK NISSAN SHOULD ADDRESS THIS PROBLEM BEFORE SOMEBODY GETS HURT OR WORSE KILLED. *TR

TRUCK WAS STALLING AND DYING, HAS HAPPENED A COUPLE OF TIMES. TOOK TRUCK TO DEALERSHIP TO REPAIR, DEALER SAID THE PROBLEM WAS THE IPDM (MODULE) AND REPLACED IT WITH MY EXTENDED WARRANTY. DEALER ALSO INFORMED ME THAT I CAN EXPECT MY CATALYTIC CONVERTERS TO GO OUT IN THE NEAR FUTURE, BECAUSE THE IPDM IS AN IMPORTANT PART FOR CONTROLLING THE WAY THE ENGINE RUNS. IF THIS IS THE CAUSE OF GREATER PROBLEMS IN THE FUTURE FOR MY TRUCK, THEY SHOULD REALLY LOOK INTO GETTING THE PROBLEM FIXED. *TR

THE CAR WILL STOP IN THE MIDDLE OF THE ROAD AT ANY SPEED AND START KNOCKING. THE LIGHTS WILL GO ON AND OFF IN THE DASH FOR A FEW SECOND BEFORE IT COMPLETELY SHUTS OFF. IF YOU TRY TO IGNITION AGAIN YOU MAY NOT BE ABLE TO START. BUT YOU CAN TURN OFF THE CAR FOR A MINUTE AND START IT BACK UP. ONE TIME I WAS ABLE TO SHUT OFF MY TRUCK HITTING THE CRUISE BUTTON. THE BIG PROBLEM WITH THIS IS THAT WHEN YOU ARE ON THE ROAD CURSING AND YOU VEHICLE STALLS YOU JUST HOPE NO ONE IS BEHIND OR IN FRONT OF YOU. THE DEALER REPLACED THE PART BUT I HAD TO COVER HALF OF THE COST OF LABOR AND PART. *TR

DESIGN FLAW ON NISSAN TITAN DUE TO EXHAUST LEAK WHICH WILL THEN BURN THE ELECTRICAL WIRING AND THE TRUCK WILL STOP ALL OF SUDDEN WITH LOST OF POWER AND BRAKES, WHICH MAY CAUSE ACCIDENTS. *TR WE WERE ON OUR WAY BACK FROM CAMPING TRIP WITH TRAVEL TRAILER IN TOW. ON INTERSTATE 81 NEAR WILKES BARRE, PA...WE WERE GOING 65 MPH AND ALL OF A SUDDEN THE VEHICLE ENGINE STOPPED, WE HAD A LOST OF POWER AND BRAKES AND HAD TO CRIPPLE TOWARDS THE SHOULDER AND COULDN'T START THE ENGINE AGAIN. WHAT CAUSED THIS FAILURE IS THE TAIL PIPE CAME LOOSE DUE TO RUST AND THE HEAT FROM THE EXHAUST BURNED THE ELECTRICAL WIRING THAT WAS PLACED ALONGISDE THE EXHAUST CAUSING THE ENGINE COMPUTER TO MALFUNCTION. WE HAD TO PAY $1,300.00 TO GET THE VEHICLE REPAIRED NOT INCLUDING ONE NIGHT HOTEL STAY AND RENTING A CAR BACK HOME BECAUSE THE PART WAS NOT AVAILABLE FOR A FEW DAYS AND HAVING TO DRIVE BACK UP TO PICK UP THE TRUCK WITH THE TRAVEL TRAILER AND BRING THEM ALL BACK HOME. THE DISTANCE IS 156 MILES FROM WHERE IT BROKE DOWN TO WHERE WE LIVE. I BELIEVE THERE'S A DESIGN FLAW THAT COULD BE DANGEROUS. THIS IS NOT THE FIRST TIME IT HAPPENED, SERVICE MANAGER IN WILKES BARRE ACKNOWLEDGED SEVERAL OTHER TITANS WITH THE SAME PROBLEM WHEN THERE IS AN EXHAUST LEAK AS WELL AS OUR LOCAL NISSAN SERVICE MANAGER ACKNOWLEDGED THE SAME. NISSAN SHOULD HAVE PROTECTED THE WIRING IN THE EXHAUST AREA WITH HEAT SHIELD OF SOME SORT. EXHAUST LEAKS OVER TIME, IT'S THE NATURE OF THE EXHAUST BUT IT SHOULD NOT REQUIRE CUSTOMERS TO PAY $1,300.00 TO GET THE ELECTRICAL SYSTEM REPAIRED. I HAVE REPORTED THIS TO NISSAN CONSUMER AFFAIRS ASKING FOR ASSISTING IN THE REPAIR COST DUE TO DESIGN FLAW, THEY DECLINED ASSISTANCE INDICATING THAT IT IS MY NEGLIGENCE THAT THE TAILPIPE SEPARATED FROM THE MUFFLER. NO OTHER CARS ON THE ROAD WITH A DANGLING TAILPIPE NEEDS TO HAVE ELECTRICAL WIRINGS REPLACED BECAUSE OF THAT, IT'S BECAUSE THEY DON'T RUN THE WIRINGS PARALLEL TO THE EXHAUST. *TR

1. TRUCK WILL RANDOMLY STALL WHILE RUNNING OR IN IDLE POSITION. THIS OCCURRED STARTING AROUND MARCH 1ST OF 2010 AND INCREASED IN OCCURRENCE UP UNTIL IT WAS TOWED TO NORTHERN AUTO OF BERKELEY MICHIGAN THE MORNING OF MAY 28TH. THE VEHICLE HAD BEEN IN TO NORTHERN AUTO TWICE BETWEEN MARCH 1ST AND MAY 28TH, BUT COULD NOT BE FIXED BECAUSE THE PROBLEM COULD NOT BE REPLICATED BY THEIR MECHANICS. WHEN IT WAS TOWED IN THE MORNING OF MAY 28TH TO NORTHERN AUTO, THEY WERE ABLE TO REPLICATE THE ISSUE AND RECOMMENDED IT BE TAKEN TO THE NISSAN DEALERSHIP. THE VEHICLE WAS TOWED FROM NORTHERN AUTO OF BERKELEY MICHIGAN TO THE NISSAN DEALERSHIP OF TROY MICHIGAN ON THE AFTERNOON OF MAY 28TH OF 2010. 2. THE STALLS WOULD HAPPEN SPORADICALLY WHILE DRIVING AT SPEEDS BELOW 40 MPH OR IDLE. THE VEHICLE WOULD LOSE ALL POWER, HENCE RENDERING THE POWER STEERING AND BRAKES USELESS. THIS DID NOT CAUSE ANY ACCIDENTS BUT HAS THE POTENTIAL TO DO SO, BECAUSE THE VEHICLE LOSES SIGNIFICANT STOPPING AND STEERING POWER WHILE STILL MOVING. AT ONE POINT THE VEHICLE COMPLETELY SHUT DOWN WHILE TRAVELING AT APPROXIMATELY 30 MPH. 3. THE NISSAN DEALERSHIP OF TROY MICHIGAN REPORTED THE PROBLEM WAS A FAULTY ECM RELAY ON THE INTERNAL POWER DISTRIBUTION MODULE (IPDM). THE DEALERSHIP RECOMMENDED AND IS REPLACING THE ENTIRE IPDM. *TR

TL*-THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE IGNITION SWITCH FELL OUT OF PLACE ON THE STEERING COLUMN SO SHE WOULD HAVE TO PUT IT BACK IN ORDER TO START THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THE HINGE THAT HELD THE SWITCH IN PLACE WAS MISSING AND NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 50. THE CURRENT MILEAGE WAS APPROXIMATELY 37,000.