IllustrationTHE FUEL GAUGE DOES NOT READ CORRECTLY BELOW APPROXIMATELY A QUARTER TANK. IT OCCASIONALLY WILL STICK AND FLUCTUATE BUT ALWAYS AROUND A QUARTER TANK AND BELOW. THE FIRST TIME I REALIZED THE PROBLEM I HAD TO HAVE MY TRUCK TOWED HOME, THINKING IT WAS SOMETHING MAJOR WHEN ALL I DID WAS RUN OUT OF GAS.
2005 Nissan Titan
Owner reports · Recalls · Investigations
More warning signs than most Titan years
Owner complaints for the 2005 Nissan Titan are substantially higher than the model-year median of 46.
About this comparison →How this year compares
Owner complaints by model year
Compare all Titan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1240–25K
13825–50K
21550–75K
16175–100K
105100–150K
57150K+
800 reports with mileage · 91 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 469 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 68 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
11 crash reports7 fire reports10 injury reports
Electrical System complaints
57 reportsMY TITAN STALLS WHILE DRIVING, A VERY DANGEROUS SITUATION! REPLACED THE RECALLED ECM RELAY, THAT WORKED FOR A COUPLE OF WEEKS, THEN THE SAME ISSUE. FROM EVERYTHING I HAVE RESEARCHED, THE IPDM IS ALSO A CULPRIT BUT NISSAN WON'T RECALL/REPLACE THESE.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE SEAT BELTS AND AIR BAGS FAILED TO OPERATE PROPERLY. WHEN THE CONTACT FASTENED THE DRIVER'S SEAT BELT TO THE HARNESS, THE MESSAGE "SEAT BELT, AIR BAGS" IMMEDIATELY FLASHED ON THE INSTRUMENT PANEL. IN ADDITION, THE CONT…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, THE SEAT BELTS AND AIR BAGS FAILED TO OPERATE PROPERLY. WHEN THE CONTACT FASTENED THE DRIVER'S SEAT BELT TO THE HARNESS, THE MESSAGE "SEAT BELT, AIR BAGS" IMMEDIATELY FLASHED ON THE INSTRUMENT PANEL. IN ADDITION, THE CONTACT STATED THAT THE FUEL TANK FAILED ON MORE THAN ONE OCCASION. UPON FILLING THE FUEL TANK HALFWAY, FUEL SPILLED ONTO THE GROUND. IT TOOK THE CONTACT APPROXIMATELY FIVE MINUTES OR MORE TO FILL THE FUEL TANK HALFWAY. COURTESY NISSAN OF TAMPA (3800 WEST HILLSBOROUGH AVENUE, TAMPA, FLORIDA 33614, (813) 235-0318) DIAGNOSED THAT THE WIRING HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT A RECALL LETTER WAS RECEIVED FOR THE FUEL TANK; HOWEVER, A VIN SEARCH SHOWED THAT THERE WERE NO RECALLS ASSOCIATED WITH THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES AND PROVIDED THE CONTACT WITH CASE NUMBERS: 28501379 AND 32622188. THE MANUFACTURER ALSO PROVIDED THE OPTION OF A VEHICLE TRADE-IN. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.
I WAS LOOKING ON THIS WEBSITE AND SEEN 6 RECALLS FOR THE 2005 NISSAN TITAN WHICH I HAVE AND AND NOTICED THERE WAS A RECALL FOR THE WIRE HARNESS ON THE DRIVERSIDE REAR DOOR. WELL ALL THOSE WIRES ARE BROKEN OFF NO MUSIC FROM THE REAR SPEAKERS ON EITHER SIDE. I'M HAVING PROBLEMS WERE I TRY TO ACCELERATE AND THE TRUCK BARELY WANTS T…
Read full complaint
I WAS LOOKING ON THIS WEBSITE AND SEEN 6 RECALLS FOR THE 2005 NISSAN TITAN WHICH I HAVE AND AND NOTICED THERE WAS A RECALL FOR THE WIRE HARNESS ON THE DRIVERSIDE REAR DOOR. WELL ALL THOSE WIRES ARE BROKEN OFF NO MUSIC FROM THE REAR SPEAKERS ON EITHER SIDE. I'M HAVING PROBLEMS WERE I TRY TO ACCELERATE AND THE TRUCK BARELY WANTS TO MOVE AND SOMETIMES TAKES LONG TO FINALLY START. WHEN YOUR IDLING IT SOUNDS AS IF IT'S GOING TO BREAK DOWN. WHEN THE A.C. IS ON IT MAKES A VERY LOUD ANNOYING SOUND. I'VE ADDED PICS OF WHAT I FOUND ON YOUR WEBSITE AS I'VE INCLUDED A PIC OF THE FRAYED WIRES FROM THE HARNESS AND NISSAN OF MELBOURNE ISN'T TRYING TO FIX THIS BEING A RECALLED PART.
DRIVING DOWN A BUSY ROAD ON MY WAY HOME FROM WORK AND VEHICLE SPUTTERS AS IF OUT OF FUEL UNTIL IT DIED. COULD NOT GET TRUCK TO CRANK AND WAS CLEARLY A LACK OF FUEL. FUEL GAUGE READ 1/4 TANK FULL EXACTLY AS DESCRIBED IN CAMPAIGN 10V074000. FORTUNATRLY A POLICE OFFICER ASSISTED IN PUSHING MY TRUCK INTO A PARKING LOT. I CALLED A FA…
Read full complaint
DRIVING DOWN A BUSY ROAD ON MY WAY HOME FROM WORK AND VEHICLE SPUTTERS AS IF OUT OF FUEL UNTIL IT DIED. COULD NOT GET TRUCK TO CRANK AND WAS CLEARLY A LACK OF FUEL. FUEL GAUGE READ 1/4 TANK FULL EXACTLY AS DESCRIBED IN CAMPAIGN 10V074000. FORTUNATRLY A POLICE OFFICER ASSISTED IN PUSHING MY TRUCK INTO A PARKING LOT. I CALLED A FAMILY MEMBER TO DRIVE UP WITH A GAS CONTAINER TO PUT A FEW GALLONS IN. SURE ENOUGH, CRANKED RIGHT UP. THE FOLLOWING DAY, I CONTACTED NISSAN OF USA, MY VEHICLE WAS NOT INCLUDED IN THE CAMPAIGN AND BECAUSE OF THE AGE AND MILEAGE OF MY TRUCK I WOULD NOT RECEIVE ASSISTANCE IN THE REPAIR OF THIS MANUFACTURER DEFECT.
I WAS DRIVING DOWN THE HWY AND MY ENGINE SHUT DOWN. I MADE IT TO THE SHOULDER, PUT IT IN PARK TURN THE KEY OFF THEN STARTS RIGHT BACK UP. STARTED YESTERDAY, AND DOES IT ABOUT EVERY TEN MILES. STARTS RIGHT BACK UP EVERY TIME. SOUNDS LIKE THE IPDM BUT FENTON NISSAN IN LEES SUMMIT MISSOURI SAID MY TRUCKS NOT RECALLED. PLEASE HELP! …
Read full complaint
I WAS DRIVING DOWN THE HWY AND MY ENGINE SHUT DOWN. I MADE IT TO THE SHOULDER, PUT IT IN PARK TURN THE KEY OFF THEN STARTS RIGHT BACK UP. STARTED YESTERDAY, AND DOES IT ABOUT EVERY TEN MILES. STARTS RIGHT BACK UP EVERY TIME. SOUNDS LIKE THE IPDM BUT FENTON NISSAN IN LEES SUMMIT MISSOURI SAID MY TRUCKS NOT RECALLED. PLEASE HELP! NO SPIT AND SPUTTER, IT JUST DIES OUT OF NO WHERE. IT ALMOST CAUSED A REAR END COLLISION WHILE PULLIN ON INTERSTATE. THIS RELAY PROBLEM IS VERY UNSAFE. PLEASE HELP!
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WITHOUT WARNING AND RESTARTED AFTER SEVERAL ATTEMPTS. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. WHILE DRIVING 50 MPH, THE VEHICLE LOST POWER WITHOUT WARNING AND RESTARTED AFTER SEVERAL ATTEMPTS. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD HAVE TO PAY FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS UNKNOWN.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WIRING HARNESS FAILED. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER FRONTAL SEAT BELTS MAY NOT OPERATE AS INTENDED IN THE EVENT OF A CRASH. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER SEAT BELTS MAY RETRACT ABNORMALLY AND CAUSE EXTREME T…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE WIRING HARNESS FAILED. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER FRONTAL SEAT BELTS MAY NOT OPERATE AS INTENDED IN THE EVENT OF A CRASH. THE CONTACT WAS CONCERNED THAT THE DRIVER AND PASSENGER SEAT BELTS MAY RETRACT ABNORMALLY AND CAUSE EXTREME TIGHTNESS. THE CONTACT WAS REPAIRING THE VEHICLE HIMSELF. THE CONTACT LOCATED THE WIRING HARNESS ON THE REAR PASSENGER DOOR AND DISCOVERED THAT IT DID NOT HAVE A PROTECTIVE SHIELD. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE APPROXIMATE FAILURE MILEAGE WAS 150,447.
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE AIR BAGS FAILED AND THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V459000 (ELECTRICAL SYSTEM); HOWEVER; THE REPAIR DID NOT CORRECT THE FAILURE. THE DEALER DIAGNOSED THAT THE AIR BAG WIRE WAS LOOSE, BU…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN TITAN. THE CONTACT STATED THAT THE AIR BAGS FAILED AND THE AIR BAG WARNING INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS REPAIRED PER NHTSA CAMPAIGN NUMBER: 06V459000 (ELECTRICAL SYSTEM); HOWEVER; THE REPAIR DID NOT CORRECT THE FAILURE. THE DEALER DIAGNOSED THAT THE AIR BAG WIRE WAS LOOSE, BUT THE WIRE REPAIR DID NOT CORRECT THE FAILURE. THE DEALER DIAGNOSED THE VEHICLE AGAIN AND DETERMINED THAT THE AIR BAG WIRING HARNESS ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 30,000.
NISSAN PREVIOUSLY ISSUED A RECALL DEALING WITH THE WIRING HARNESS ISSUE, #06V459000 TO REROUTE AND CHANGE THE WIRING COVER. THIS AFFECTS THE AIRBAGS AND THE OPERATION OF THE SEAT BELTS, AS WELL AS THE AUDIO SYSTEM. THE AIRBAG LIGHT IS FLASHING AND THE REAR PASSENGER DOOR SPEAKER DOESN'T WORK. THE RECALL WAS JUST A TEMPORARY COVE…
Read full complaint
NISSAN PREVIOUSLY ISSUED A RECALL DEALING WITH THE WIRING HARNESS ISSUE, #06V459000 TO REROUTE AND CHANGE THE WIRING COVER. THIS AFFECTS THE AIRBAGS AND THE OPERATION OF THE SEAT BELTS, AS WELL AS THE AUDIO SYSTEM. THE AIRBAG LIGHT IS FLASHING AND THE REAR PASSENGER DOOR SPEAKER DOESN'T WORK. THE RECALL WAS JUST A TEMPORARY COVER UP OF THE PROBLEM. THE ISSUE CAME UP AGAIN AND THEY REFUSE TO FIX IT, WANTING TO CHARGE UPWARDS OF $1000 TO REPLACE THE WIRING HARNESSS, A PROBLEM THEY ARE ALREADY AWARE OF. THE RECALL DID NOT FIX THE PROBLEM, ONLY A TEMPORARY COVER-UP.
Official recalls
410V517000 · Engine And Engine Cooling
Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
10V074000 · Fuel System, Other:storage:fuel Gauge System
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
08V284000 · Equipment:appliance:air Conditioner
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
06V459000 · Electrical System
Nov 30, 2006
ON CERTAIN KING CAB TRUCKS, THE WIRES IN THE HARNESS WERE ROUTED THROUGH THE REAR DOORS AND INTO THE BODY. THESE WIRES MAY BREAK DUE TO OVER BENDING OF THE HARNESS AS THE DOOR IS OPENED AND CLOSED. THE HARNESS CONTAINS WIRES FOR THE DRIVER SEAT BELT PRETENSIONER AND FOR THE FRONT PASSENGER SEAT BELT WHICH IS PART OF THE OCCUPANT CLASSIFICATION SYSTEM. WIRES FOR THE REAR AUDIO SPEAKERS ARE ALSO CONTAINED N THE HARNESS.
Consequence & remedy
Consequence: IF THE WIRES FOR THE SEAT BELTS AND SPEAKER WIRES BREAK AND MAKE CONTACT, THERE IS A POSSIBILITY THAT THE PRETENSIONER MAY DEPLOY. IF THIS HAPPENS WHEN THE SEAT BELT IS RETRACTED, IT WILL NOT BE POSSIBLE TO USE THE SEAT BELT. IF ONE OF THE WIRES ON THE RIGHT SIDE HARNESS FOR THE SEAT BELT TENSION SENSOR BREAKS, THE PASSENGER SIDE FRONT AIR BAG WILL NOT DEPLOY AS DESIGNED IN A FRONTAL COLLISION INCREASING THE RISK OF A CRASH AND PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE WIRE HARNESS COVER WITH A DIFFERENT TYPE THAT PREVENTS OVER BENDING OF THE HARNESS AND THE HARNESS WILL BE REROUTED FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 19, 2007. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.