IllustrationI WAS DRIVING ABOUT 50 MPH WHEN I HEARD A NOISE COMING OUT OF THE ENGINE CRANK NOISE WHEN I STOPPED TO CHECK , THE ENGINE STOPPED AND NEVER STARTED AGAIN I TOWED TO GARAGE AND THEY SAY IT IS THE TIMING CHAIN. *TR
2004 Nissan Quest
Owner reports · Recalls · Investigations
More warning signs than most Quest years
Owner complaints for the 2004 Nissan Quest are substantially higher than the model-year median of 66.
About this comparison →How this year compares
Owner complaints by model year
Compare all Quest years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1420–25K
3125–50K
4150–75K
3775–100K
55100–150K
15150K+
321 reports with mileage · 124 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 77 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports10 fire reports30 injury reports
What owners actually said
445 reportsTL* THE CONTACT OWNS A 2004 NISSAN QUEST. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT THE SLIP, ABS, AND TCS WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE SUDDENLY STALLED. THE FAILURE RECURRED FOUR TIMES WHILE TRAVELING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. TH…
Read full complaint
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. WHILE DRIVING APPROXIMATELY 10 MPH, THE CONTACT THE SLIP, ABS, AND TCS WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL AS THE VEHICLE SUDDENLY STALLED. THE FAILURE RECURRED FOUR TIMES WHILE TRAVELING AT VARIOUS SPEEDS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 102,000.
MY NISSAN QUEST HAS BEEN MAKING A RATTLING NOISE THAT IS PROGRESSIVELY GETTING WORSE. I TOOK IT IN TODAY AND WAS TOLD THAT I HAD PROBLEMS WITH THE TIMING CHAIN AND THAT I SHOULD TAKE IT TO A DEALER OR ENGINE SHOP THAT IS EQUIPPED TO FIX SUCH AN ISSUE. ONE OF THE REASONS I FAVORED BUYING THIS CAR WAS BECAUSE OF THE FACT THAT NI…
Read full complaint
MY NISSAN QUEST HAS BEEN MAKING A RATTLING NOISE THAT IS PROGRESSIVELY GETTING WORSE. I TOOK IT IN TODAY AND WAS TOLD THAT I HAD PROBLEMS WITH THE TIMING CHAIN AND THAT I SHOULD TAKE IT TO A DEALER OR ENGINE SHOP THAT IS EQUIPPED TO FIX SUCH AN ISSUE. ONE OF THE REASONS I FAVORED BUYING THIS CAR WAS BECAUSE OF THE FACT THAT NISSAN USES A TIMING CHAIN RATHER THAN A TIMING BELT. THUS, I WOULDN'T HAVE THE EXPENSE OF REPLACING A TIMING BELT IN THE FUTURE. I WAS LEAD TO BELIEVE THAT TIMING CHAINS WOULD NOT BE SOMETHING THAT I WOULD NEED TO FIX. BECAUSE THIS PROBLEM IS PREVALENT AMONG QUEST OWNERS, I BELIEVE THAT NISSAN SHOULD RECALL THEIR VEHICLES THAT SUFFER FROM THE SAME DESIGN FLAW. IF NISSAN DOESN'T ADDRESS THIS ISSUE, SOMEONE IS GOING TO GET INJURED OR KILLED AS A RESULT OF ONE OF THEIR FAULTY TIMING BELTS BREAKING WHILE ONE OF THEIR FAULTY CARS IS BEING DRIVEN. *TR
MY MECHANIC NOTICED SEVERE ROTTING OF RIGHT SIDE OF SUBFRAME WHICH HOLDS THE ENGINE AND OTHER IMPORTANT CAR PARTS IN PLACE. I WAS MADE AWARE THAT IF THE SUBFRAME BROKE, THE ENGINE WOULD FALL OUT AND THE RIGHT WHEEL WOULD SLIDE TO THE SIDE, CAUSING COMPLETE LOSS OF CONTROL OF THE CAR. VERY DANGEROUS, POSSIBLY FATAL. I WAS LUCK…
Read full complaint
MY MECHANIC NOTICED SEVERE ROTTING OF RIGHT SIDE OF SUBFRAME WHICH HOLDS THE ENGINE AND OTHER IMPORTANT CAR PARTS IN PLACE. I WAS MADE AWARE THAT IF THE SUBFRAME BROKE, THE ENGINE WOULD FALL OUT AND THE RIGHT WHEEL WOULD SLIDE TO THE SIDE, CAUSING COMPLETE LOSS OF CONTROL OF THE CAR. VERY DANGEROUS, POSSIBLY FATAL. I WAS LUCKY IT WAS FOUND BEFORE SUCH AN ACCIDENT OCCURRED. I HAVE FOUND TWO OTHER SIMILAR COMPLAINTS ABOUT THE SUBFRAME ROTTING OUT. THERE IS A DRIP FROM THE AIR CONDITIONER THAT IS DESIGNED TO FALL RIGHT ON THIS IMPORTANT STRUCTURE AND POOLS THERE. MY FEAR IS THAT OTHERS ARE UNAWARE OF THE STRUCTURAL ISSUE AND COULD NOT BE SO LUCKY TO FIND IT IN TIME BEFORE FATALITY OCCURS. I BELIEVE THE CAR NEEDS TO BE RECALLED TO FIX THE IMPROPER DRAINAGE OF THE AIR CONDITIONING. *TR *JS
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. WHILE PARKED, THE CONTACT NOTICED THAT THE INSTRUMENT PANEL GAUGES WERE NOT PROVIDING ANY ACCURATE READINGS. THE CONTACT STATED THE VEHICLE HAD BEEN PARKED FOR TWO DAYS DURING A HURRICANE PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WA…
Read full complaint
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. WHILE PARKED, THE CONTACT NOTICED THAT THE INSTRUMENT PANEL GAUGES WERE NOT PROVIDING ANY ACCURATE READINGS. THE CONTACT STATED THE VEHICLE HAD BEEN PARKED FOR TWO DAYS DURING A HURRICANE PRIOR TO THE FAILURE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 66,100.
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THE VEHICLE STARTED TO MAKE A LOUD NOISE AND THE WARNING LAMPS FOR THE ABS SYSTEM AND TRACTION CONTROLS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ABS PUMP ACTUATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AW…
Read full complaint
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THE VEHICLE STARTED TO MAKE A LOUD NOISE AND THE WARNING LAMPS FOR THE ABS SYSTEM AND TRACTION CONTROLS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ABS PUMP ACTUATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 102,000.
I HAVE HAD AN INTERMITTENT ELECTRICAL ISSUE WITH MY NISSAN QUEST FOR THE LAST FEW YEARS (SINCE 60,000 MILES, NOW AT 100,000 MILES). THE DEALER HAS BEEN UNABLE TO PROPERLY DIAGNOSE THIS ISSUE OVER A PERIOD OF YEARS, AND IT IS A SAFETY CONCERN. SUDDENLY THE SPEEDOMETER DROPS TO ZERO WHEN I AM DRIVING AND ALL THE DASHBOARD HAZARD L…
Read full complaint
I HAVE HAD AN INTERMITTENT ELECTRICAL ISSUE WITH MY NISSAN QUEST FOR THE LAST FEW YEARS (SINCE 60,000 MILES, NOW AT 100,000 MILES). THE DEALER HAS BEEN UNABLE TO PROPERLY DIAGNOSE THIS ISSUE OVER A PERIOD OF YEARS, AND IT IS A SAFETY CONCERN. SUDDENLY THE SPEEDOMETER DROPS TO ZERO WHEN I AM DRIVING AND ALL THE DASHBOARD HAZARD LIGHTS GO ON. WHEN I AM ABLE TO PULL OVER AND TURN OFF AND RESTART THE CAR, THE CHECK ENGINE LIGHT REMAINS ON AND THE CAR IS OK FOR A FEW DAYS/WEEKS/MONTHS. THEN IT ALL HAPPENS AGAIN. THEY HAVE CHANGED SENSORS, TIGHTENED ALL ELECTRICAL CONNECTIONS, AND NOW WOULD LIKE TO CHANGE THE ABS ACTUATOR ASSEMBLY. I NOTICE ONLINE THAT THIS IS A PROBLEM THAT MANY OWNERS OF 2004 QUESTS HAVE, AND SEEMS TO BE A SERIOUS SAFETY ISSUE. I HAVE NOT ALLOWED MY CHILDREN TO DRIVE MY CAR. I FEEL THIS NEEDS A RECALL FROM NISSAN TO CORRECT. *TR
A FAMILY TRIP FROM ST AUGUSTINE HEADING SOUTHBOUND ON I-95 TOWARDS W.PALM BEACH 75 MILES INTO JOURNEY THE VEHICLE SHUTS DOWN WITH NO WARNING SIGNS. HAD THIS VAN TOWED TO NEAREST REPAIR SHOP 25 MILES AND HAD THE THROTTLE BODY REPLACE. THERE WAS NO CHECK ENGINE LIGHT ON PRIOR TO THIS REPAIR. PARTS THAT WAS DEFECTIVE WAS THE THROTT…
Read full complaint
A FAMILY TRIP FROM ST AUGUSTINE HEADING SOUTHBOUND ON I-95 TOWARDS W.PALM BEACH 75 MILES INTO JOURNEY THE VEHICLE SHUTS DOWN WITH NO WARNING SIGNS. HAD THIS VAN TOWED TO NEAREST REPAIR SHOP 25 MILES AND HAD THE THROTTLE BODY REPLACE. THERE WAS NO CHECK ENGINE LIGHT ON PRIOR TO THIS REPAIR. PARTS THAT WAS DEFECTIVE WAS THE THROTTLE BODY, IGNITION COIL AND WAS TOLD BY REPAIR SHOP A POSSIBLE DEFECTIVE FUEL INJECTOR. *TR
2004 NISSAN QUEST. CONSUMER STATES SAFETY PROBLEM WITH THE POWER WINDOWS AND POWER DOORS *TGW THE CONSUMER STATED THE PASSENGER SIDE WINDOW WOULD NOT STAY CLOSED. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, HE WAS INFORMED TO FIX THE PROBLEM IT WOULD REQUIRE REPLACING THE MOTOR, WHICH WOULD BE VERY EXPENSIVE. THE CONSUMER…
Read full complaint
2004 NISSAN QUEST. CONSUMER STATES SAFETY PROBLEM WITH THE POWER WINDOWS AND POWER DOORS *TGW THE CONSUMER STATED THE PASSENGER SIDE WINDOW WOULD NOT STAY CLOSED. WHEN THE CONSUMER TOOK THE VEHICLE TO THE DEALER, HE WAS INFORMED TO FIX THE PROBLEM IT WOULD REQUIRE REPLACING THE MOTOR, WHICH WOULD BE VERY EXPENSIVE. THE CONSUMER DECLINED THE REPAIR. LATER ON, THE WINDOW REVERTED BACK TO ITS PROPER CLOSING PROCEDURE AND OPERATED AS IT WAS DESIGNED. HOWEVER, THE DRIVER'S WINDOW WOULD NOT CLOSE AUTOMATICALLY AND THE CONSUMER WAS FORCED TO HOLD DOWN THE BUTTON MANUALLY. THE DOOR ON THE PASSENGER SIDE WOULD NOT CLOSE COMPLETELY. IT WOULD STOP ABOUT HALF WAY. THE CONSUMER HAD TO PHYSICALLY PUSH THE DOOR CLOSED WHICH LASTED FOR WEEKS. THEN, SUDDENLY THE DOOR BEGAN CLOSING CORRECTLY WITHOUT ANY ATTEMPT AT REPAIR. THE SLIDING DOOR ON THE DRIVER'S SIDE DIDN'T FUNCTION AS IT SHOULD. IT ALL STARTED WHEN THE CONSUMER'S GRANDSON WAS EXITING THE VEHICLE BY PUSHING THE OPEN BUTTON FROM THE INSIDE. AS HE WAS GETTING OUT, THE DOOR REVERSED ITSELF BEFORE IT OPENED COMPLETELY AND BEGAN CLOSING, HITTING HIM AND WOULDN'T STOP AS IT WAS SUPPOSED TO WHEN MEETING AN OBJECT. FORTUNATELY, HE WAS ONLY FRIGHTENED, BUT NOT INJURED. THE DOOR CONTINUED TO MALFUNCTION, SO THE CONSUMER NO LONGER USED IT ANYMORE. THE CONSUMER REFERENCED RECALL # 04V186000. HOWEVER, HIS VIN WAS NOT INCLUDED IN THE RECALL. *JB
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THERE WAS A RUMBLING NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT ALL OF THE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE ABS ACTUATOR NEEDED TO BE REPLAC…
Read full complaint
TL* THE CONTACT OWNS A 2004 NISSAN QUEST. THE CONTACT STATED THAT THERE WAS A RUMBLING NOISE COMING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE CONTACT ALSO STATED THAT ALL OF THE LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE ABS ACTUATOR NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 136,000.
Official recalls
405V480000 · Seats:mid/rear Assembly
Oct 17, 2005
ON CERTAIN MINI VANS EQUIPPED WITH A FOLDING THIRD ROW REAR SEAT, WHEN THE THIRD ROW SEAT IS RAISED FROM ITS STOWED POSITION, IT ENGAGES STRIKER BRACKETS, ONE ON EACH SIDE OF THE SEAT CUSHION. THE FOLD-AWAY STRIKER LOOP IS WELDED TO A MOUNTING BRACKET. THE STRIKER MAY BECOME DETACHED FROM ITS MOUNTING BRACKET DUE TO A BROKEN WELD AT THE POINT OF ATTACHMENT TO THE BRACKET.
Consequence & remedy
Consequence: IF THE THIRD ROW SEAT STRIKER WELD FAILS, THE STRIKER COULD SEPARATE FROM THE MOUNTING BRACKET. STRIKER SEPARATION COULD AFFECT THE RISK OF INJURY IN CERTAIN TYPES OF CRASHES.
Remedy: DEALERS WILL REPLACE THE THIRD ROW SEAT STRIKER BRACKETS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
05V474000 · Seats:mid/rear Assembly
Oct 13, 2005
ON CERTAIN MINI VANS, THERE IS A SEAT ADJUSTMENT MECHANISM THAT CONTAINS EXPOSED MOVING COMPONENTS LOCATED AT THE REAR INSIDE EDGE OF THE SECOND ROW SEAT.
Consequence & remedy
Consequence: WHEN THE OPERATOR ATTEMPTS SEAT ADJUSTMENT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM WHICH COULD CAUSE AN INJURY.
Remedy: ON EARLIER MODEL VEHICLES BUILT THROUGH JUNE 28, 2004, DEALERS WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE, RIVET A PLASTIC REINFORCEMENT TO BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE TO THE INBOARD SIDE SHIELD. ON VEHICLES PRODUCED FROM JUNE 29, 2004 THROUGH SEPTEMBER 26, 2005, DEALERS WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL TIE-DOWNS AND A FLANGE ON THE INBOARD SIDE SHIELD. THE RECALL BEGAN ON DECEMBER 19, 2005. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
04V186000 · Latches/locks/linkages:doors:latch
Apr 16, 2004
ON CERTAIN MINIVANS EQUIPPED WITH A POWER SLIDING DOOR(S), AT AN AMBIENT TEMPERATURE BELOW APPROXIMATELY 40 DEGREES FAHRENHEIT, THE ACTUATOR FOR THE POWER SLIDING DOOR(S) MAY EXPERIENCE BINDING DUE TO AN OUT-OF-SPECIFICATION CONDITION. IN ORDER TO OPEN, CLOSE OR REVERSE A POWER SLIDING DOOR, THE SHIFT SELECTOR LEVER MUST BE IN "PARK." IF THE ACTUATOR IS EXPERIENCING BINDING AND THE DRIVER SHIFTS THE VEHICLE OUT OF "PARK" WHILE A POWER SLIDING DOOR IS STILL CLOSING, THE DOOR LATCHES MAY NOT ENGAGE.
Consequence & remedy
Consequence: THIS CAN RESULT IN THE DOOR COMING OPEN UNEXPECTEDLY UPON RAPID ACCELERATION, AND AN OCCUPANT COULD FALL OUT OF THE DOOR AND BE INJURED.
Remedy: DEALERS WILL REPLACE THE ACTUATOR FOR THE POWER SLIDING DOOR(S). OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
04V103000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Mar 1, 2004
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE ADVANCED AIR BAG REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE AIR BAG FOR THE FRONT PASSENGER SEAT IS TO BE TURNED OFF (SO THAT IT DOES NOT INFLATE) WHEN CERTAIN OCCUPANTS, SUCH AS SMALL CHILDREN, ARE IN THE FRONT SEAT.
Consequence & remedy
Consequence: THIS REDUCES THE RISK OF SUCH OCCUPANTS BEING UNJURED BY AN INFLATING AIR BAG IN A COLLISION.
Remedy: DEALERS WILL INSPECT THE FRONT PASSENGER SEAT CUSHION/SENSOR ASSEMBLY. IF THE SEAT CUSHION/SENSOR IS FOUND TO BE OPERATING IMPROPERLY, THE SEAT WILL BE REMOVED AND RECALIBRATED. OWNER NOTIFICATION BEGAN ON JUNE 23, 2004. OWNERS SHOULD CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
EA05012 · Finger Pinch Point
Opened Aug 19, 2005 · Closed Oct 20, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
THE SEAT ADJUSTMENT MECHANISM CONTAINS EXPOSED MOVING COMPONENTS, LOCATED AT THE REAR EDGE OF THE SECOND ROW SEAT.WHEN THE OPERATOR ATTEMPTS TO ADJUST THE SEAT, A FINGER MAY BE PINCHED IN THE MOVING SEAT ADJUSTMENT MECHANISM.NISSAN WILL CONDUCT A SAFETY RECALL ON AN EXPANDED SCOPE OF NISSAN QUEST VEHICLES.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005, NISSAN WILL RIVET A PLASTIC REINFORCEMENT TO THE BACKSIDE OF THE EXISTING SEAT BACK COVER CARPETING, INSTALL THREE TIE-DOWNS AND INSTALL A FLANGE TO THE INBOARD SIDE SHIELD.ON VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH JUNE 28, 2004, IN ADDITION TO THE ABOVE CORRECTIVE ACTIONS, NISSAN WILL REPLACE THE INBOARD SECOND ROW SEAT ADJUSTMENT HANDLE WITH THE CURRENT PRODUCTION SEAT LEVER. NISSAN NORTH AMERICA, INC. WILL RECALL 109,437 MY 2004-2005 NISSAN QUEST VEHICLES PRODUCED FROM MARCH 26, 2003 THROUGH SEPTEMBER 26, 2005.ODI IS AWARE OF A TOTAL OF 11 COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS REPORTING 11 FINGER INJURIES.THE RECALL IS IDENTIFIED BY NHTSA NUMBER 05V474.
PE05019 · Finger Pinch Point
Opened Apr 21, 2005 · Closed Aug 19, 2005
Status: closed (inferred from source dates) · Seats:mid/rear Assembly
ODI HAS RECEIVED FIVE REPORTS ALLEGING THAT THE CONSUMER WAS INJURED USING THE VEHICLE'S SECOND-ROW SEAT RELEASE LEVER TO FOLD THE SECOND ROW SEAT.NISSAN STATES, ...THE CUSTOMER OPERATION OF THE LEVER IN SOME CASES AND SUBSEQUENT ORIENTATION OF THEIR FINGERS IS DIFFERENT THAN EXPECTED.NISSAN ALSO REPORTED ADDITIONAL COMPLAINTS FOR A TOTAL OF 11 INJURIES.NISSAN MODIFIED THE LEVER FOR PRODUCTION TWICE.THE LATEST (SECOND MODIFICATION) DESIGN PROVIDES A LARGER SIZED HANDLE THAT CONTAINS A CUP INTO WHICH THE SEAT OCCUPANT CAN PLACE THEIR FINGERS TO OPERATE THE ADJUSTMENT LEVER.NISSAN REPORTS NO INJURIES ASSOCIATED WITH THE CUP DESIGN LEVER.BEGINNING JUNE 2004, NISSAN INITIATED A CUSTOMER SATISFACTION INITIATIVE THAT INCLUDED REPLACING THE ORIGINAL DESIGN HANDLE WITH THE FIRST MODIFICATION HANDLE (THIS IS NOT THE CUP DESIGN HANDLE MENTIONED ABOVE).THE INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA05-012) TO ALLOW FURTHER ANALYSIS OF THE ISSUE.
PE04027 · POWER-SLIDING Door Opening
Opened Mar 15, 2004 · Closed Jun 2, 2004
Status: closed (inferred from source dates) · Latches/locks/linkages:doors:latch; Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.
Structure:body:door
IN JANUARY 2004, NISSAN RECEIVED REPORTS OF POWER SLIDING DOORS COMING OPEN WHILE DRIVING.NISSAN DETERMINED THAT AT TEMPERATURES BELOW 40 DEGREE F, AN OUT-OF-SPEC DOOR ACTUATOR COULD BIND AND PREVENT THE DOOR LATCHES FROM FULLY ENGAGING.THIS CAN LEAD TO THE DOOR COMING OPEN UNEXPECTEDLY.NISSAN NOTIFIED NHTSA BY LETTER DATED APRIL 1, 2004, THAT IT IS CONDUCTING A SAFETY RECALL CAMPAIGN (NHTSA NO. 04V186) ON MY 2004 NISSAN QUEST VEHICLES WITH POWER-SLIDING DOORS PRODUCED FROM MARCH 26, 2003 TO DECEMBER 17, 2003.NISSAN MODIFIED THE ACUTATOR DOOR MOTOR ON VEHICLES BUILT AFTER DECEMBER 17, 2003 FOR REASONS NOT RELATED TO THE INADVERTENT DOOR OPENING ISSUE.NISSAN REPORTS THAT VEHICLES BUILT AFTER DECEMBER 17, 2003 ARE NOT SUBJECT TO THE FAILURE MODE THAT CAUSES INADVERTENT OPENING.ODI'S REVIEW OF THE ODI OWNER REPORTS WITH KNOWN BUILD DATES (7 OF 9 REPORTS, PLUS ONE REPORT RECEIVED PRIOR TO DEC 17 BUT WITH UNKNOWN BUILD DATE) INDICATES THAT COMPLAINT VEHICLES WERE MANUFACTURED BEFORE THE DOOR ACTUATOR IMPROVEMENT DATE (DEC 17).ALSO, NISSAN REPORTS NO COMPLAINT VEHICLES WITH BUILD DATES AFTER DECEMBER 17.NISSAN'S ACTION ADDRESSES THE CONCERNS OF ODI.THEREFORE, THIS INVESTIGATION IS CLOSED.