NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
373 reports171,000 miles · Jul 26, 2016
Service Brakes
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING LESS THAN 15 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE VEHICLE HAD A DELAY WHEN STOPPING. WHEN THE VEHICLE WAS SHUT OFF AND RESTARTED, THE BRAKING PERFORMANCE WOULD RETURN TO NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSE…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING LESS THAN 15 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD WHEN IT WAS DEPRESSED. THE VEHICLE HAD A DELAY WHEN STOPPING. WHEN THE VEHICLE WAS SHUT OFF AND RESTARTED, THE BRAKING PERFORMANCE WOULD RETURN TO NORMAL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DELTA STROKE SENSOR FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 171,000.
NHTSA ODI #10888700
187,355 miles · Jul 5, 2016
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE FUEL GAGE ON THE INSTRUMENT PANEL BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 …
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. THE CONTACT STATED THAT THE FUEL GAGE ON THE INSTRUMENT PANEL BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL GAUGE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 10V074000 (FUEL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 187,355. THE VIN WAS NOT AVAILABLE.
NHTSA ODI #10882658
162,000 miles · Jun 23, 2016
Service Brakes
I HAVE HAD THE SAME ISSUE THAT MANY PEOPLE ARE EXPLAINING. I WILL BE DRIVING DOWN THE ROAD AND OUT OF NO WHERE THE DASH BRAKE LIGHT WILL TURN ON. WHEN I PROCEED TO STOP THE CAR THE BRAKE WILL PUSH DOWN TO THE FLOOR AND IT WILL GRIND AND ALMOST SOUND LIKE A SPRING. I PULL OVER, TURN THE CAR OFF AND THEN IT GOES AWAY. IT HAS H…
Read full complaint
I HAVE HAD THE SAME ISSUE THAT MANY PEOPLE ARE EXPLAINING. I WILL BE DRIVING DOWN THE ROAD AND OUT OF NO WHERE THE DASH BRAKE LIGHT WILL TURN ON. WHEN I PROCEED TO STOP THE CAR THE BRAKE WILL PUSH DOWN TO THE FLOOR AND IT WILL GRIND AND ALMOST SOUND LIKE A SPRING. I PULL OVER, TURN THE CAR OFF AND THEN IT GOES AWAY. IT HAS HAPPENED MULTIPLE TIMES AND THERE IS NO WARNING AS TO WHEN IT WILL HAPPEN.
NHTSA ODI #10876076
117,000 miles · May 31, 2016
Service Brakes
WHILE I AM DRIVING MY EMERGENCY BRAKE LIGHT TURNS ON AND MY BRAKES LOCKED AND IT'S REALLY HARD FOR ME TO BREAK THE BRAKE PEDAL ALSO SHAKES ALMOST LEADING INTO AN ACCIDENT.
NHTSA ODI #10871713
112,869 miles · May 20, 2016
Air BagsFuel/propulsion SystemService Brakes
THE DRIVER SIDE AIRBAG IS NOT WORKING DUE TO A FAULTY HARNESS ASSEMBLY. THE FUEL GAUGE DOES NOT MEASURE FUEL ACCURATELY. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES STOP WORKING WHILE YOU ARE DRIVING. NISSAN REFUSES TO FIX THE ISSUES WITHOUT US PAYING OVER 3 GRAND EVEN THOUGH THESE ITEMS WERE RECALLED ON OTHER NISSANS BUT THERE …
Read full complaint
THE DRIVER SIDE AIRBAG IS NOT WORKING DUE TO A FAULTY HARNESS ASSEMBLY. THE FUEL GAUGE DOES NOT MEASURE FUEL ACCURATELY. THE ABS BRAKE LIGHT COMES ON AND THE BRAKES STOP WORKING WHILE YOU ARE DRIVING. NISSAN REFUSES TO FIX THE ISSUES WITHOUT US PAYING OVER 3 GRAND EVEN THOUGH THESE ITEMS WERE RECALLED ON OTHER NISSANS BUT THERE IS NO RECALL ON THIS PARTICULAR NISSAN. THIS NISSAN NEEDS TO BE ADDED TO THE RECALLS. WE BOUGHT THE CAR 5 MONTHS AGO FROM GO AUTOMOTIVE AND THEY ALSO REFUSED TO FIX THE ISSUES.
NHTSA ODI #10870106
154,385 miles · May 5, 2016
Electrical SystemFuel/propulsion System
I RECENTLY LEARNED OF THE SAFETY RECALL 10V-074 THAT DESCRIBED THE EXACT SITUATION I ENCOUNTERED IN 2014. I WAS DRIVING ON EXPRESSWAY AT 70 MPH WHEN ENGINE DIED. LUCKILY I WAS ABLE TO COAST OVER TO SIDE OF ROAD, BUT WAS BETWEEN AN ON RAMP AND OFF RAMP--VERY DANGEROUS. FUEL GAUGE SHOWED 1/3 OF A TANK. ROADSIDE ASSISTANCE ADDED A …
Read full complaint
I RECENTLY LEARNED OF THE SAFETY RECALL 10V-074 THAT DESCRIBED THE EXACT SITUATION I ENCOUNTERED IN 2014. I WAS DRIVING ON EXPRESSWAY AT 70 MPH WHEN ENGINE DIED. LUCKILY I WAS ABLE TO COAST OVER TO SIDE OF ROAD, BUT WAS BETWEEN AN ON RAMP AND OFF RAMP--VERY DANGEROUS. FUEL GAUGE SHOWED 1/3 OF A TANK. ROADSIDE ASSISTANCE ADDED A COUPLE GALLONS OF GAS. I WAS ABLE TO START AND DRIVE TO DEALER. NO RECALLS WERE IDENTIFIED FOR MY VIN AT THE TIME SO I WAS CHARGED NEARLY $1000 TO REPLACE FUEL PUMP/SENDER. I AM BRINGING THIS TO YOUR ATTENTION BECAUSE I HAVE SO FAR BEEN UNSUCCESSFUL IN NEGOTIATING REIMBURSEMENT FROM NISSAN. BASED ON THE NUMBER OF COMPLAINTS I SEE ON YOUR WEBSITE, I BELIEVE A NON-VIN SPECIFIC SAFETY RECALL CAMPAIGN MUST BE INITIATED BECAUSE THIS PROBLEM WILL MOST LIKELY CONTINUE SINCE THESE VEHICLES CAN LAST A LONG TIME--MY ARMADA HAD 154,000 MILES ON IT AT THAT TIME.
NHTSA ODI #10863332
73,000 miles · May 4, 2016
Air BagsSeat BeltsService Brakes
THE AIR BAG LIGHT WAS FLASHING SO I TOOK MY 2005 ARMADA TO THE DEALERSHIP TO FIND OUT THE REASON. THE DEALER IS CHARGING ME ABOUT $500.00 TO REPLACE THE HARNESS. THEY SAID THE AIR BAG MAY NOT DEPLOY IF I AM INVOLVED IN AN ACCIDENT. ALSO, I'VE HAD TWO INSTANCES WHERE MY BRAKES GOT JAMMED AND MADE A LOUD NOISE WHEN I STOPPED AT A…
Read full complaint
THE AIR BAG LIGHT WAS FLASHING SO I TOOK MY 2005 ARMADA TO THE DEALERSHIP TO FIND OUT THE REASON. THE DEALER IS CHARGING ME ABOUT $500.00 TO REPLACE THE HARNESS. THEY SAID THE AIR BAG MAY NOT DEPLOY IF I AM INVOLVED IN AN ACCIDENT. ALSO, I'VE HAD TWO INSTANCES WHERE MY BRAKES GOT JAMMED AND MADE A LOUD NOISE WHEN I STOPPED AT A STOP SIGN.
NHTSA ODI #10863189
91,227 miles · May 3, 2016
Engine
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE EXHAUST MANIFOLD FRACTURED AND CAUSED THE AIR FUEL SENSOR TO PLACE THE VEHICLE IN LIMP MODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE M…
Read full complaint
TL* THE CONTACT OWNS A 2005 NISSAN ARMADA. WHILE DRIVING 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE DEALER DIAGNOSED THAT THE EXHAUST MANIFOLD FRACTURED AND CAUSED THE AIR FUEL SENSOR TO PLACE THE VEHICLE IN LIMP MODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,227.
NHTSA ODI #10862888
143,000 miles · Apr 20, 2016
Fuel/propulsion System
THE INSTRUMENT PANEL FUEL GAUGE IS INACCURATELY DISPLAYING THAT THE VEHICLE STILL HAS SOME FUEL, BETWEEN HALF AND ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY. THIS HAS CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, CAUSING A DANGEROUS SAFETY SITUATION. THE DEALER DIAGNOSED THE ISSUE AND NEEDS TO REPLACE THE F…
Read full complaint
THE INSTRUMENT PANEL FUEL GAUGE IS INACCURATELY DISPLAYING THAT THE VEHICLE STILL HAS SOME FUEL, BETWEEN HALF AND ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY. THIS HAS CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, CAUSING A DANGEROUS SAFETY SITUATION. THE DEALER DIAGNOSED THE ISSUE AND NEEDS TO REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK TOGETHER WITH THE O-RING.
NHTSA ODI #10860500
87,632 miles · Mar 18, 2016
Fuel/propulsion System
ON MARCH 18, 2016, MY HUSBAND WAS DRIVING OUR 2005 NISSAN ARMADA AT APPROX 60MPH ON THE HIGHWAY. ALL OF A SUDDEN WITHOUT WARNING VEHICLE LOST POWER, LUCKILY MY HUSBAND WAS ABLE TO STEER AND COAST VEHICLE TO THE SIDE.THIS COULD HAVE BEEN TRAGEDY.GAS TANK NEEDLE INDICATED THAT VEHICLE HAD A QUARTER TANK OF GAS IN IT. NO LOW GAS …
Read full complaint
ON MARCH 18, 2016, MY HUSBAND WAS DRIVING OUR 2005 NISSAN ARMADA AT APPROX 60MPH ON THE HIGHWAY. ALL OF A SUDDEN WITHOUT WARNING VEHICLE LOST POWER, LUCKILY MY HUSBAND WAS ABLE TO STEER AND COAST VEHICLE TO THE SIDE.THIS COULD HAVE BEEN TRAGEDY.GAS TANK NEEDLE INDICATED THAT VEHICLE HAD A QUARTER TANK OF GAS IN IT. NO LOW GAS LIGHT INDICATOR WAS ON OR EVER CAME ON!! OUR TEENAGE SON HAD BEEN DRIVING IT FOR OVER A WEEK. WHAT IF HE WAS DRIVING THIS WHEN THIS OCCURRED, HE COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE!!!! VEHICLE WAS AT 87,632 MILES WHEN THIS OCCURRED. I CAME TO THIS WEBSITE AND OBSERVED WHERE OTHER DRIVERS HAD THE SAME INCIDENT HAPPEN.ALSO OBSERVED WHERE NISSAN IS AWARE OF THIS FLAW IN THE ARMADA. I ADVISED MY HUSBAND ABOUT THIS AFTER HE HAD ALREADY CALLED A TOW TRUCK. ONCE HE PUT GAS IN IT, IT STARTED RIGHT BACK UP. THIS COULD HAVE BEEN REALLY BAD, BUT IT WAS ONLY THE GRACE OF GOD THAT SAVED MY HUSBAND SURELY NOT NISSAN!! USUALLY KEEP A 1/2 OF TANK OF GAS OR MORE, BUT TEENAGE SON HAD BEEN DRIVING IT FOR THE LAST WEEK. WHAT IF MY TEENAGER WAS DRIVING IT WHEN IT SHUT DOWN ON THE HIGHWAY?? THIS PROBABLY WOULD NOT HAVE BEEN THE SAME OUTCOME.NO LOW GAS LIGHT INDICATOR CAME ON TO WARN MY HUSBAND THAT GAS WAS LOW. MY HUSBAND, SON OR SOMEONE ELSE COULD HAVE BEEN KILLED!! AT THE TIME OF INCIDENT MILEAGE WAS AT 87,632
NHTSA ODI #10850486
Official recalls
3Oct 28, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2004-2006 ARMADA, TITAN, INFINITI QX56 AND MODEL YEAR 2005-2006 FRONTIER, PATHFINDER AND XTERRA VEHICLES. THE INTELLIGENT POWER DISTRIBUTION MODULE (IPDM) ASSEMBLY CONTAINS AN ENGINE CONTROL MODULE (ECM) RELAY THAT HAS A DIODE FOR ELECTRICAL CURRENT NOISE REDUCTION. THE ECM RELAY MAY ALLOW SILICON VAPOR TO FORM AND, OVER TIME, THE SILICON EVAPORATES FROM THE DIODE MOLDING WHICH CAUSES SILICON OXIDE TO DEVELOP ON THE ECM RELAY CONTACT DUE TO ARCING.
Consequence & remedy
Consequence: THIS COULD CAUSE ENGINE STALLING INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE ECM RELAY INSIDE THE IPDM ASSEMBLY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 6, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Mar 3, 2010
NISSAN IS RECALLING CERTAIN MODEL YEAR 2005-2009 TITAN, ARMADA, AND INFINITI QX56 VEHICLES. THE INSTRUMENT PANEL FUEL GAUGE MAY INACCURATELY DISPLAY THAT THE VEHICLE STILL HAS SOME FUEL, TYPICALLY ABOUT ONE QUARTER TANK, WHEN THE FUEL TANK IS EMPTY.
Consequence & remedy
Consequence: THIS COULD CAUSE THE VEHICLE TO RUN OUT OF GAS AND STALL ON THE HIGHWAY, WHICH COULD CAUSE A CRASH.
Remedy: DEALERS WILL REPLACE THE FUEL SENDER UNIT INSIDE THE FUEL TANK WITH A NEW IMPROVED SENDER CARD. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Jun 27, 2008
NISSAN IS RECALLING 180,664 MY 2005-2006 TITAN, ARMADA AND INFINITY QX56 VEHICLES MANUFACTURED AFTER MARCH 17, 2005, THAT ARE EQUIPPED WITH A VISTEON AIR CONDITIONING CONDENSER FAN MOTOR. THE FAN MOTOR MAY NOT BE PROPERLY SEALED ALLOWING EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE.
Consequence & remedy
Consequence: THIS COULD CAUSE CORROSION IN THE MOTOR LEADING POSSIBLY TO OVERHEATING AND A FIRE.
Remedy: DEALERS WILL INSTALL A 'THERMAL PROTECTOR KIT' AND TEST THE AIR CONDITIONING CONDENSER FAN MOTOR AND REPLACE IT IF NECESSARY. THE RECALL BEGAN ON AUGUST 2, 2008. OWNERS MAY CONTACT NISSAN AT 1-800-647-7261.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE08037 · Engine Compartment Fire
Opened May 30, 2008 · Closed Aug 25, 2008
Status: closed (inferred from source dates) · Electrical System:wiring; Electrical System:wiring:front Underhood; Engine And Engine Cooling; Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (4)
Electrical System:wiring:front Underhood
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Electrical System:wiring
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling:engine
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Engine And Engine Cooling
ON MAY 30, 2008, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION BASED ON CONSUMER COMPLAINTS ALLEGING THAT SMOKE AND/OR FIRE ERUPTED IN THE ENGINE COMPARTMENT OF MODEL YEAR (MY) 2005-2006 NISSAN ARMADA AND TITAN VEHICLES.BY LETTER DATED JUNE 24, 2008, NISSAN NOTIFIED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA #08V284) FOR MY2005-2006 NISSAN TITAN, ARMADA AND INFINITI QX56 VEHICLES MANUFACTURED FROM MARCH 17, 2005 TO AUGUST 21, 2006 THAT ARE EQUIPPED WITH A 90-WATT AIR CONDITIONING CONDENSER FAN.THE RECALL INVOLVES APPROXIMATELY 180,664 VEHICLES.THIS ALSO INCLUDES APPROXIMATELY 5,689 SUBJECT CONDENSER FANS, SOME OF WHICH MAY HAVE BEEN INSTALLED IN MY2004 AND PRE-MARCH 17, 2005 MY NISSAN TITAN, ARMADA OR INFINITI QX56 VEHICLES AS A SERVICE REPLACEMENT PART.NISSAN DEALERS WILL INSTALL A SPECIAL THERMAL PROTECTOR KIT ON EXISTING FANS THAT WILL ELIMINATE THE POTENTIAL FOR A FIRE TO OCCUR.NISSAN NORTH AMERICA, INC. (NISSAN) INFORMED ODI THAT THE 90-WATT AIR CONDITIONING CONDENSER FAN WAS MANUFACTURED OUT-OF-SPECIFICATION ALLOWING FOR EXCESSIVE WATER INTRUSION AND INADEQUATE DRAINAGE OF MOISTURE THAT MAY ACCUMULATE IN THE MOTOR AS A RESULT OF WATER INTRUSION OR CONDENSATION.IF SUFFICIENT MOISTURE ACCUMULATES IN THE MOTOR WITHOUT ADEQUATE DRAINAGE, CORROSION MAY OCCUR.THE CORROSION CAN CAUSE AN INCREASE IN INTERNAL FRICTION AND AN INCREASE IN THE ELECTRICAL CURRENT DRAW, RESULTING IN AN INCREASE IN THE TEMPERATURE OF THE MOTOR THAT COULD MELT ITS WIRING INSULATION AND OTHER PLASTIC COMPONENTS AND FORM A GAS.IF TWO WIRES WITHOUT INSULATION TOUCH EACH OTHER AND CREATE A SPARK, THIS GAS COULD IGNITE AND RESULT IN A FIRE.THE ACTION TAKEN BY NISSAN IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
PE08004 · Side Air Bag NON-DEPLOYMENT
Opened Jan 25, 2008 · Closed May 30, 2008
Status: closed (inferred from source dates) · Air Bags:side/window
THE SUBJECT VEHICLES ARE EQUIPPED WITH OPTIONAL SEAT-MOUNTED SIDE AIR BAGS.ALL VEHICLES ARE EQUIPPED WITH STANDARD FRONTAL AIR BAGS AND SIDE AIR CURTAINS.INSTALLATION OF THE INCORRECT SRS DIAGNOSIS SENSOR UNIT DOES NOT IMPAIR DEPLOYMENT OF THE FRONTAL AIR BAG AND SIDE AIR CURTAIN IN THE EVENT OF A CRASH.NO REPORTS OF NON-DEPLOYMENT OF THE SUBJECT SEAT-MOUNTED SIDE AIR BAGS HAVE BEEN RECEIVED BY THE MANUFACTURER OR BY NHTSA.THE WARRANTY REPORTS CITED ABOVE REPRESENT VEHICLE INSPECTIONS CONDUCTED UNDER THE SERVICE CAMPAIGN AND SENSOR REPLACEMENT WAS REQUIRED IN 32 OF THESE CASES.THE MANUFACTURER REPORTS A TOTAL OF 151 SENSOR UNITS SOLD AS REPLACEMENT PARTS FOR ALL PURPOSES.INVESTIGATION DISCLOSED A LOW INCIDENCE OF SENSOR REPLACEMENT REQUIRED UNDER THE SERVICE CAMPAIGN TO DATE.NO INCIDENTS OF REAL WORLD NON-DEPLOYMENT OF THE SUBJECT AIR BAGS WERE IDENTIFIED.THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration